Experimental investigation of different brines imbibition influences on co- and counter-current oil flows in carbonate reservoirs

doi:10.1016/j.cjche.2020.08.028

Abstract

Abstract: Imbibition of water, as wetting phase in oil-wet fractured carbonate reservoirs, plays a key role in fluid flow between matrix and fracture system. The type of injected seawater and its chemistry would profoundly influence the imbibition process. In this study, the impact of smart water (a brine that its ions have been adjusted to facilitate oil recovery) and low salinity water on co- and counter-current imbibition processes for oil-wet carbonate cores has been experimentally investigated. The results show an increase of about 10% in oil recovery for co- and counter-currents for smart seawater imbibition compared to that of low salinity seawater. In addition, as a result of the influence of co- and counter-current on each other, by co-current removal from one core face, the countercurrent in the other face would be intensified by as much as about 75%. A close examination of different lengths (5, 7 and 9 cm) of carbonate cores with the same permeability revealed that by decreasing porous medium length, the amount of counter-current producing oil would be decreased so that in the 5 cm core, counter current oil production will not happen. For similar core lengths by increasing permeability, the share of counter current flow would be decreased approximately 18% since the capillary pressure could not overcome non-wetting phase viscous forces. Considering the role of matrix length along with a modified brine (which is designed according to the matrix mixture) strengthen the relevant mechanisms to have more oil production so that the higher thickness of matrix causes the higher amount of co-current oil producing and consequently more total recovery.

Key words: Smart water, Co-current, Counter current, Wettability alteration, Oil recovery

摘要： Imbibition of water, as wetting phase in oil-wet fractured carbonate reservoirs, plays a key role in fluid flow between matrix and fracture system. The type of injected seawater and its chemistry would profoundly influence the imbibition process. In this study, the impact of smart water (a brine that its ions have been adjusted to facilitate oil recovery) and low salinity water on co- and counter-current imbibition processes for oil-wet carbonate cores has been experimentally investigated. The results show an increase of about 10% in oil recovery for co- and counter-currents for smart seawater imbibition compared to that of low salinity seawater. In addition, as a result of the influence of co- and counter-current on each other, by co-current removal from one core face, the countercurrent in the other face would be intensified by as much as about 75%. A close examination of different lengths (5, 7 and 9 cm) of carbonate cores with the same permeability revealed that by decreasing porous medium length, the amount of counter-current producing oil would be decreased so that in the 5 cm core, counter current oil production will not happen. For similar core lengths by increasing permeability, the share of counter current flow would be decreased approximately 18% since the capillary pressure could not overcome non-wetting phase viscous forces. Considering the role of matrix length along with a modified brine (which is designed according to the matrix mixture) strengthen the relevant mechanisms to have more oil production so that the higher thickness of matrix causes the higher amount of co-current oil producing and consequently more total recovery.

关键词: Smart water, Co-current, Counter current, Wettability alteration, Oil recovery

Pouyan Ahmadi, Mohammad Reza Aghajanzadeh, Masoud Riazi, Mohammad Reza Malayeri, Mohammad Sharifi. Experimental investigation of different brines imbibition influences on co- and counter-current oil flows in carbonate reservoirs[J]. Chinese Journal of Chemical Engineering, 2021, 33(5): 17-29.

References

[1] A.D. Sarvestani, S. Ayatollahi, M.B. Moghaddam, Smart water flooding performance in carbonate reservoirs: an experimental approach for tertiary oil recovery, J. Pet. Explor. Prod. Technol. 9(2019) 2643-2657.
[2] M.R. Aghajanzadeh, P. Ahmadi, M. Sharifi, M. Riazi, Wettability modification of oilwet carbonate reservoirs using silica-based nanofluid: An experimental approach, J. Petroleum Sci. Eng. 178(2019) 700-710.
[3] P. Ahmadi, H. Asaadian, A. Khadivi, S. Kord, A new approach for determination of carbonate rock electrostatic double layer variation towards wettability alteration, J. Mol. Liq. 275(2019) 682-698.
[4] I. Nowrouzi, A.K. Manshad, A.H. Mohammadi, The mutual effects of injected fluid and rock during imbibition in the process of low and high salinity carbonated water injection into carbonate oil reservoirs, J. Mol. Liq. 305(2020), 112432,.
[5] A. Rezaei, M. Riazi, M. Escrochi, R. Elhaei, Integrating surfactant, alkali and nanofluid flooding for enhanced oil recovery: A mechanistic experimental study of novel chemical combinations, J. Mol. Liq. 308(2020) 113106.
[6] A. RezaeiDoust, T. Puntervold, S. Strand, T. Austad, Smart water as wettability modifier in carbonate and sandstone: A discussion of similarities/differences in the chemical mechanisms, Energy Fuel 23(2009) 4479-4485.
[7] S. Berg, A.W. Cense, E. Jansen, K. Bakker, Direct experimental evidence of wettability modification by low salinity, Petrophysics. 51(5) (2010) 314-322.
[8] P. Ahmadi, E. Ghandi, M. Riazi, M.R. Malayeri, Experimental and CFD studies on determination of injection and production wells location considering reservoir heterogeneity and capillary number, Oil Gas Sci. Technol. d’IFP Energies Nouv. 74(2019) 4.
[9] P. Ahmadi, B. Shahsavani, M.R. Malayeri, M. Riazi, Impact of different injection sites on the water and oil exchange in a fractured porous medium for different polymers: A visual study, J. Pet. Sci. Eng. 174(2019) 948-958.
[10] A.K. Manshad, M. Olad, S.A. Taghipour, I. Nowrouzi, A.H. Mohammadi, Effects of water soluble ions on interfacial tension (IFT) between oil and brine in smart and carbonated smart water injection process in oil reservoirs, J. Mol. Liq. 223(2016) 987-993.
[11] I. Nowrouzi, A.K. Manshad, A.H. Mohammadi, Evaluation of interfacial tension (IFT), oil swelling and oil production under imbibition of carbonated water in carbonate oil reservoirs, J. Mol. Liq. 312(2020) 113455.
[12] I. Nowrouzi, A.K. Manshad, A.H. Mohammadi, Effects of ions and dissolved carbon dioxide in brine on wettability alteration, contact angle and oil production in smart water and carbonated smart water injection processes in carbonate oil reservoirs, Fuel. 235(2019) 1039-1051.
[13] I. Nowrouzi, A.K. Manshad, A.H. Mohammadi, Effects of dissolved binary ionic compounds and different densities of brine on interfacial tension (IFT), wettability alteration, and contact angle in smart water and carbonated smart water injection processes in carbonate oil reservoirs, J. Mol. Liq. 254(2018) 83-92.
[14] M.R. Aghajanzadeh, M. Sharifi, Stabilizing silica nanoparticles in high saline water by using polyvinylpyrrolidone for reduction of asphaltene precipitation damage under dynamic condition, Chin. J. Chem. Eng. 27(2019) 1021-1029.
[15] I. Nowrouzi, A.K. Manshad, A.H. Mohammadi, Effects of concentration and size of TiO₂ nano-particles on the performance of smart water in wettability alteration and oil production under spontaneous imbibition, J. Pet. Sci. Eng. 183(2019) 106357.
[16] I. Nowrouzi, A.K. Manshad, A.H. Mohammadi, Effects of TiO₂, MgO, and γ-Al₂O₃ nanoparticles in carbonated water on water-oil interfacial tension (IFT) reduction in chemical enhanced oil recovery (CEOR) process, J. Mol. Liq. 292(2019) 111348.
[17] P.P. Jadhunandan, N.R. Morrow, Effect of wettability on waterflood recovery for crude-oil/brine/rock systems, SPE Reservoir Engineering 10(1) (1995) 40-46.
[18] N.R. Morrow, G. Mason, Recovery of oil by spontaneous imbibition, Curr. Opin. Colloid Interface Sci. 6(2001) 321-337.
[19] H. Mahani, A.L. Keya, S. Berg, W.-B. Bartels, R. Nasralla, W.R. Rossen, Insights into the mechanism of wettability alteration by low-salinity flooding (LSF) in carbonates, Energy Fuel 29(2015) 1352-1367.
[20] H. Mahani, S. Berg, D. Ilic, W.-B. Bartels, V. Joekar-Niasar, Kinetics of low-salinityflooding effect, SPE J. 20(2015) 8-20.
[21] M. Stoll, J. Hofman, D.J. Ligthelm, M.J. Faber, P. van den Hoek, Toward field-scale wettability modification—the limitations of diffusive transport, SPE Reserv. Eval. Eng. 11(2008) 633-640.
[22] H. Mahani, A.L. Keya, S. Berg, R. Nasralla, Electrokinetics of carbonate/brine interface in low-salinity waterflooding: Effect of brine salinity, composition, rock type, and pH on ζ-potential and a surface-complexation model, SPE J. 22(2017) 53-68.
[23] A.A. Yousef, S. Al-Saleh, A.U. Al-Kaabi, M.S. Al-Jawfi, Laboratory investigation of novel oil recovery method for carbonate reservoirs, In: Can. Unconv. Resour. Int. Pet. Conf. Society of Petroleum Engineers, 2010.
[24] S.J. Fathi, T. Austad, S. Strand, “Smart water” as a wettability modifier in chalk: the effect of salinity and ionic composition, Energy Fuel 24(2010) 2514-2519.
[25] M. AlShaikh, J. Mahadevan, Impact of brine composition on calcite wettability: A sensitivity study, SPE J. 21(2016) 1-214.
[26] Z. Derikvand, A. Rezaei, R. Parsaei, M. Riazi, F. Torabi, A mechanistic experimental study on the combined effect of Mg²⁺, Ca²⁺, and SO₄^2- ions and a cationic surfactant in improving the surface properties of oil/water/rock system, Colloids Surfaces A Physicochem. Eng. Asp. 587(2020) 124327.
[27] J.M. Bell, F.K. Cameron, The flow of liquids through capillary spaces, J. Phys. Chem. 10(2002) 658-674.
[28] K.S. Schmid, S. Geiger, K.S. Sorbie, Analytical solutions for co-and countercurrent imbibition of sorbing-dispersive solutes in immiscible two-phase flow, In: ECMOR XII-12th Eur. Conf. Math. Oil Recover, 163, European Association of Geoscientists & Engineers, 2010.
[29] A.Y. Foley, H.A. Nooruddin, M.J. Blunt, The impact of capillary backpressure on spontaneous counter-current imbibition in porous media, Adv. Water Resour. 107(2017) 405-420.
[30] A. Rezaei, H. Abdollahi, Z. Derikvand, A. Hemmati-Sarapardeh, A. Mosavi, N. Nabipour, Insights into the effects of pore size distribution on the flowing behavior of carbonate rocks: Linking a nano-based enhanced oil recovery method to rock typing, Nanomaterials 10(2020) 972.
[31] S.J. Fathi, T. Austad, S. Strand, Water-based enhanced oil recovery (EOR) by “smart water”: Optimal ionic composition for EOR in carbonates, Energy Fuel 25(2011) 5173-5179.
[32] P. Zhang, M.T. Tweheyo, T. Austad, Wettability alteration and improved oil recovery by spontaneous imbibition of seawater into chalk: Impact of the potential determining ions Ca²⁺, Mg²⁺, and SO₄^2-, Colloids Surfaces A Physicochem. Eng. Asp. 301(2007) 199-208.
[33] A. Gandomkar, M.R. Rahimpour, The impact of monovalent and divalent ions on wettability alteration in oil/low salinity brine/limestone systems, J. Mol. Liq. 248(2017) 1003-1013.
[34] H. Mahani, A.L. Keya, S. Berg, R. Nasralla, The effect of salinity, rock type and ph on the electrokineticsofcarbonate-brineinterfaceandsurfacecomplexationmodeling,In:SPE Reserv. Characterisation Simul. Conf. Exhib. Society of Petroleum Engineers, 2015.
[35] S. Ma, X. Zhang, N.R. Morrow, Influence of fluid viscosity on mass transfer between rock matrix and fractures, J. Can. Pet. Technol. 38(1999) 25-30.
[36] T. Austad, Water-based EOR in carbonates and sandstones. Enhanced Oil Recovery Field Case Studies. Elsevier, Amsterdam, (2013) 301-335.
[37] M.O. Denekas, C.C. Mattax, G.T. Davis, Effects of crude oil components on rock wettability, 1st216, Trans. AIME, (1959) 330-333.
[38] T. Puntervold, S. Strand, T. Austad, Water flooding of carbonate reservoirs: effects of a model base and natural crude oil bases on chalk wettability, Energy Fuel 21(2007) 1606-1616.
[39] M.P. Yutkin, H. Mishra, T.W. Patzek, J. Lee, C.J. Radke, Radke, Bulk and surface aqueous speciation of calcite: Implications for low-salinity waterflooding of carbonate reservoirs, 1st23, SPE J., (2018) 84-101.
[40] M. Lashkarbolooki, M. Riazi, F. Hajibagheri, S. Ayatollahi, Low salinity injection into asphaltenic-carbonate oil reservoir, mechanistical study, J. Mol. Liq. 216(2016) 377-386.
[41] A.K. Manshad, M. Rezaei, S. Moradi, I. Nowrouzi, A.H. Mohammadi, Wettability alteration and interfacial tension (IFT) reduction in enhanced oil recovery (EOR) process by ionic liquid flooding, J. Mol. Liq. 248(2017) 153-162.
[42] Å. Haugen, M.A. Fernø, G. Mason, N.R. Morrow, The effect of viscosity on relative permeabilities derived from spontaneous imbibition tests, Transp. Porous Media 106(2015) 383-404.
[43] G. Mason, H. Fischer, N.R. Morrow, D.W. Ruth, Spontaneous counter-current imbibition into core samples with all faces open, Transp. Porous Media 78(2009) 199-216.
[44] Å. Haugen, M.A. Fernø, G. Mason, N.R. Morrow, Capillary pressure and relative permeability estimated from a single spontaneous imbibition test, J. Pet. Sci. Eng. 115(2014) 66-77.
[45] Q. Meng, H. Liu, J. Wang, H. Zhang, Effect of wetting-phase viscosity on cocurrent spontaneous imbibition, Energy Fuel 30(2016) 835-843.
[46] S. Herminghaus, Roughness-induced non-wetting, EPL, Europhysics Lett. 52(2000) 165.
[47] A.A. Yousef, S.H. Al-Saleh, A. Al-Kaabi, M.S. Al-Jawfi, Laboratory investigation of the impact of injection-water salinity and ionic content on oil recovery from carbonate reservoirs, SPE Reserv. Eval. Eng. 14(2011) 578-593.
[48] H.M. Meighani, C. Ghotbi, T.J. Behbahani, K. Sharifi, A new investigation of wax precipitation in Iranian crude oils: Experimental method based on FTIR spectroscopy and theoretical predictions using PC-SAFT model, J. Mol. Liq. 249(2018) 970-979.
[49] O. Torsæter, A comparative study of wettability test methods based on experimental results from North Sea reservoir rocks, SPE Annu. Tech. Conf. Exhib. Society of Petroleum Engineers, 1988.
[50] J. Toth, T. Bodi, P. Szucs, F. Civan, Convenient formulae for determination ofrelative permeability from unsteady-state fluid displacements in core plugs, J. Pet. Sci. Eng. 36(2002) 33-44.
[51] P.C. Myint, A. Firoozabadi, Thin liquid films in improved oil recovery from lowsalinity brine, Curr. Opin. Colloid Interface Sci. 20(2015) 105-114.
[52] I. Nowrouzi, A.K. Manshad, A.H. Mohammadi, Effects of dissolved carbon dioxide and ions in water on the dynamic interfacial tension of water and oil in the process of carbonated smart water injection into oil reservoirs, Fuel. 243(2019) 569-578.
[53] S. Wickramathilaka, J.J. Howard, J.C. Stevens, N.R. Morrow, G. Mason, Å. Haugen, A. Graue, M.A. Fernø, Magnetic resonance imaging of oil recovery during spontaneous imbibition from cores with two-ends open boundary condition, Proc. Int. Soc. Core Anal. Annu. Meet 18-21(2011).
[54] X. Zhou, N.R. Morrow, S. Ma, Interrelationship of wettability, initial water saturation, aging time, and oil recovery by spontaneous imbibition and waterflooding, SPE/DOE Improv. Oil Recover. Symp. Society of Petroleum Engineers, 1996.
[55] E. Unsal, G. Mason, D.W. Ruth, N.R. Morrow, Co-and counter-current spontaneous imbibition into groups of capillary tubes with lateral connections permitting cross-flow, J. Colloid Interface Sci. 315(2007) 200-209.
[56] B. Ataie-Ashtiani, S.M. Hassanizadeh, M.A. Celia, Effects of heterogeneities on capillary pressure-saturation-relative permeability relationships, J. Contam. Hydrol. 56(2002) 175-192.
[57] S.K. Masalmeh, The effect of wettability heterogeneity on capillary pressure and relative permeability, J. Pet. Sci. Eng. 39(2003) 399-408.
[58] G.R. Jerauld,S.J. Salter, Theeffect ofpore-structureon hysteresisin relative permeability and capillary pressure: pore-level modeling, Transp. Porous Media 5(1990) 103-151.