Experimental Study on Revolving Cross-flow Microfiltration of Highly Viscous Liquids

›› 2008, Vol. 16 ›› Issue (6): 961-964.

• RESEARCH NOTES • Previous Articles

Experimental Study on Revolving Cross-flow Microfiltration of Highly Viscous Liquids

Sonil Ri^1,2, XU Zhenliang¹, ZHOU Ying¹, CHEN Gui'e^1,3, Yongguk Kim²

1. State Key Lab of Chemical Engineering, Chemical Engineering Research Center, East China University of Science and Technology, Shanghai 200237, China;
2. Department of Mechanical Engineering, HamHung Chemical University, HamHung, D. P. R. Korea;
3. Department of Chemical Engineering, Shanghai Institute of Technology, Shanghai 200233, China

Received:2007-06-27 Revised:2008-09-21 Online:2008-12-28 Published:2008-12-28
Supported by:
Supported by the State Key Development Program for Basic Research of China (2003CB615705)

Experimental Study on Revolving Cross-flow Microfiltration of Highly Viscous Liquids

Sonil Ri^1,2, 许振良¹, 周颖¹, 陈桂娥^1,3, Yongguk Kim²

1. State Key Lab of Chemical Engineering, Chemical Engineering Research Center, East China University of Science and Technology, Shanghai 200237, China;
2. Department of Mechanical Engineering, HamHung Chemical University, HamHung, D. P. R. Korea;
3. Department of Chemical Engineering, Shanghai Institute of Technology, Shanghai 200233, China

通讯作者: To whom correspondence should be addressed. E-mail:chemxuzl@ecust.edu.cn
基金资助:
Supported by the State Key Development Program for Basic Research of China (2003CB615705)

Abstract

Abstract: Experimental investigation of the microfiltration(MF) using a revolving cross-flow membrane filter was performed under the condition of constant pressure difference,and different flat membranes made of polyvinylidene fluoride(PVDF,0.1μm),cellulose acetate(CA,0.22μm),sulfonated polyethersulfone(SPES,0.22μm) and polyamide(PA,0.45μm),respectively,were used in filtration experiments.The dependence of the filtrate mass of the cross-flow MF on time was measured on-line.The experimental results showed that the effect of the cross-flow on high viscosity medium was more significant than that on the low viscosity one.

Key words: microfiltration membrane, viscous liquid, cross-flow

摘要： Experimental investigation of the microfiltration(MF) using a revolving cross-flow membrane filter was performed under the condition of constant pressure difference,and different flat membranes made of polyvinylidene fluoride(PVDF,0.1μm),cellulose acetate(CA,0.22μm),sulfonated polyethersulfone(SPES,0.22μm) and polyamide(PA,0.45μm),respectively,were used in filtration experiments.The dependence of the filtrate mass of the cross-flow MF on time was measured on-line.The experimental results showed that the effect of the cross-flow on high viscosity medium was more significant than that on the low viscosity one.

关键词: microfiltration membrane, viscous liquid, cross-flow

Sonil Ri, XU Zhenliang, ZHOU Ying, CHEN Gui'e, Yongguk Kim. Experimental Study on Revolving Cross-flow Microfiltration of Highly Viscous Liquids[J]. , 2008, 16(6): 961-964.

Sonil Ri, 许振良, 周颖, 陈桂娥, Yongguk Kim. Experimental Study on Revolving Cross-flow Microfiltration of Highly Viscous Liquids[J]. , 2008, 16(6): 961-964.

References

1 Zhou, X.T., Chen, W.M., Chu, L.Y., Yi, M.G., Chen, M.H., “Theoretical study on dynamic filtration with the membrane in simple harmonic motion”, Chin. J. Chem. Eng., 12, 723-727(2004).
2 Brou, A., Ding, L.H., Jaffrin, M.Y., “Dynamic microfiltration of yeast suspensions using rotating disks equipped with vanes”, J. Membr. Sci., 197, 269-282(2002).
3 Moulai-Mostefa, N., Akoum, O., Nedjihoui, M., Ding, L.H., Jaffrin, M.Y., “Comparison between rotating disk and vibratory membranes in the ultrafiltration of oil-in-water emulsions”, Desalination, 206, 494-498(2007).
4 Beier, S.P., Guerra, M., Garde, A., Jonsson, G., “Dynamic microfiltration with a vibrating hollow fiber membrane module:Filtration of yeast suspensions”, J. Membr. Sci., 281, 281-287(2006).
5 Jaffrin, M.Y., Ding, L.H., Akoum, O., Brou, A., “A hydrodynamic comparison between rotating disk and vibratory dynamic filtration systems”, J. Membr. Sci., 242, 155-167(2004).
6 Murase, T., Ohn, T., Katumi K., “Filtration flux in cross flow microfiltration of dilute suspension forming a highly compressible fouling cake-layer”, J. Membr. Sci., 108, 121-128(1995).
7 Fradin, B., Field, R.W., “Cross flow micro filtration of magnesium hydroxide suspensions:determination of critical fluxes, measurement and modelling of fouling”, Sep. Purif. Technol., 16, 25-45(1999).
8 Ferreira, A.S., Massarani, G., “Physico-mathematical modeling of cross flow filtration”, Chem. Eng. J., 111, 199-204(2005).
9 Altmann, J., Ripperger, S., “Particle deposition and layer formation at the cross flow microfiltration”, J. Membr. Sci., 124, 119-128(1997).
10 Yang, G.C.C., Yang, T.Y., “Electrofiltration of silica nanoparticle-containing wastewater using tubular ceramic membranes”, Sep. Purif. Technol., 58, 159-165(2007).
11 Yang, G.C.C., Yang, T.Y., Tsai, S.H., “Crossflow electro-microfiltration of oxide-CMP wastewater”, Water Res., 37, 785-792(2003).
12 Malinovskaya, T.A., Kobrinsky, I.A., “The separation of finely divided suspension in a dynamic filter”, Mechanical Liquid Separation, 10, 47-51(1971).
13 Cagatayhan, B.E., Washington, B., “Ultrafiltration of ink and latex wastewaters using cellulose membranes”, Desalination, 164, 63-70(2004).
14 Carrère, H., “Study of hydrodynamic parameters in the cross-flow filtration of guar gum pseudo plastic solutions”, J. Membr. Sci., 174, 135-145(2000).
15 Jiraratananon, R., Uttapap, D., Sampranpiboon, P., “Cross flow micro filtration of a colloidal suspension with the presence of macromolecules”, J. Membr. Sci., 140, 57-66(1998).
16 Lojkine, M.H., Field, R.W., Howell, J.A., “Crossflow microfiltration of cell suspensions:A review of models with emphasis on particle size effects”, Trans. IChemE. C, 70, 149-164(1992).
17 Krusteva, E.D., Doneva, T.A., Vassilieff, C.S., “Pseudoplasticity of filter cakes explains cross-flow micro filtration”, Colloids Surfaces A Physicochem. Eng. Aspects, 149, 499-506(1999).
18 Doneva, T.A., Vassilieff, C.S., Krusteva, E.D., “Cross flow micro filtration of latex suspensions:Test of different models”, Colloids Surfaces A Physicochem. Eng. Aspects, 138, 245-254(1998).

[1]	Yang Liu, Qiu Han, Guiliang Li, Haibo Lin, Fu Liu, Gang Deng, Dingfeng Lv, Weijie Sun. Purifying chylous plasma by precluding triglyceride via carboxylated polyethersulfone microfiltration membrane [J]. Chinese Journal of Chemical Engineering, 2022, 49(9): 130-139.
[2]	Jiajia Luo, Jinfu Wang, Tiefeng Wang. Experimental study of partially decoupled oxidation of ethane for producing ethylene and acetylene [J]. Chin.J.Chem.Eng., 2018, 26(6): 1312-1320.
[3]	Xinyu Yu, Tianwen Chen, Qi Zhang, Tiefeng Wang. CFD simulations of quenching process for partial oxidation of methane: Comparison of jet-in-cross-flow and impinging flow configurations [J]. Chin.J.Chem.Eng., 2018, 26(5): 903-913.
[4]	CAI Ziqi, BAO Yuyun, GAO Zhengming. Hydrodynamic Behavior of a Single Bubble Rising in Viscous Liquids [J]. , 2010, 18(6): 923-930.
[5]	LIU Changjun, LIANG Bin, TANG Shengwei, ZHANG Haiguang, MIN Enze. A Theoretical Model for the Size Prediction of Single Bubbles Formed under Liquid Cross-flow [J]. , 2010, 18(5): 770-776.
[6]	LI Woyuan, WU Wei, ZOU Haikui, CHU Guangwen, SHAO Lei, CHEN Jianfeng. A Mass Transfer Model for Devolatilization of Highly Viscous Media in Rotating Packed Bed [J]. , 2010, 18(2): 194-201.
[7]	ZOU Caisong, LUO Guangsheng, SUN Yong, DAI Youyuan. Mechanism of Coalescence Demulsification with Microfiltration Membrane [J]. , 2003, 11(3): 344-347.

Experimental Study on Revolving Cross-flow Microfiltration of Highly Viscous Liquids

Experimental Study on Revolving Cross-flow Microfiltration of Highly Viscous Liquids

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 7

Recommended Articles

Metrics

Comments