Chinese Journal of Chemical Engineering ›› 2024, Vol. 65 ›› Issue (1): 106-116.DOI: 10.1016/j.cjche.2023.07.009
Previous Articles Next Articles
Songling Guo, Xun Tao, Fan Zhou, Mengyan Yu, Yufan Wu, Yunfei Gao, Lu Ding, Fuchen Wang
Received:
2022-12-07
Revised:
2023-07-04
Online:
2024-04-17
Published:
2024-01-28
Contact:
Fuchen Wang,E-mail:wfch@ecust.edu.cn
Supported by:
Songling Guo, Xun Tao, Fan Zhou, Mengyan Yu, Yufan Wu, Yunfei Gao, Lu Ding, Fuchen Wang
通讯作者:
Fuchen Wang,E-mail:wfch@ecust.edu.cn
基金资助:
Songling Guo, Xun Tao, Fan Zhou, Mengyan Yu, Yufan Wu, Yunfei Gao, Lu Ding, Fuchen Wang. Investigation of oxy-fuel combustion for methane and acid gas in a diffusion flame[J]. Chinese Journal of Chemical Engineering, 2024, 65(1): 106-116.
Songling Guo, Xun Tao, Fan Zhou, Mengyan Yu, Yufan Wu, Yunfei Gao, Lu Ding, Fuchen Wang. Investigation of oxy-fuel combustion for methane and acid gas in a diffusion flame[J]. 中国化学工程学报, 2024, 65(1): 106-116.
Add to citation manager EndNote|Ris|BibTeX
URL: https://cjche.cip.com.cn/EN/10.1016/j.cjche.2023.07.009
[1] J.S. Eow, Recovery of sulfur from sour acid gas:A review of the technology, Environ. Prog. 21(3)(2002)143-162. [2] O. Abed Habeeb, R. Kanthasamy, G.A.M. Ali, S. Sethupathi, R. Bin Mohd Yunus, Hydrogen sulfide emission sources, regulations, and removal techniques:A review, Rev. Chem. Eng. 34(6)(2018)837-854. [3] J.S. Lar, X.J. Li, Removal of H2S during anaerobic bioconversion of dairy manure, Chin. J. Chem. Eng. 17(2)(2009)273-277. [4] J.F. Zhang, Z.Q. Tong, H2S removal with cupric chloride for producing sulfur, Chin. J. Chem. Eng. 14(6)(2006)810-813. [5] A.K. Gupta, S. Ibrahim, A. Al Shoaibi, Advances in sulfur chemistry for treatment of acid gases, Prog. Energy Combust. Sci. 54(2016)65-92. [6] X.H. Lü, H. Li, X.H. Du, X.E. Wang, M.Y. Lan, J.L. Wu, J. Zhu, J.L. Sun, F. Jiang, Simultaneous catalytic reduction of SO2 and NO from flue gas using H2S as a reductant at low temperatures, React. Chem. Eng. 5(3)(2020)561-569. [7] S. Sinha, A. Raj, A.S. AlShoaibi, S.M. Alhassan, S.H. Chung, Toluene destruction in the Claus process by sulfur dioxide:A reaction kinetics study, Ind. Eng. Chem. Res. 53(42)(2014)16293-16308. [8] R. Schmidt, J.B. Cross, E.G. Latimer, Tail-gas cleanup by simultaneous SO2 and H2S removal, Energy Fuels 23(7)(2009)3612-3616. [9] I.A. Gargurevich, Hydrogen sulfide combustion:Relevant issues under Claus furnace conditions, Ind. Eng. Chem. Res. 44(20)(2005)7706-7729. [10] A. Mehmood, H. Alhasani, N. Alamoodi, Y.F. AlWahedi, S. Ibrahim, A. Raj, An evaluation of kinetic models for the simulation of Claus reaction furnaces in sulfur recovery units under different feed conditions, J. Nat. Gas Sci. Eng. 74(2020)103106. [11] F. Manenti, D. Papasidero, A. Frassoldati, G. Bozzano, S. Pierucci, E. Ranzi, Multi-scale modeling of Claus thermal furnace and waste heat boiler using detailed kinetics, Comput. Chem. Eng. 59(2013)219-225. [12] M. FrenkLach, J.H. Lee, J.N. White, W.C. Gardiner, Oxidation of hydrogen sulfide, Combust. Flame 41(1981)1-16. [13] H. Selim, S. Ibrahim, A. Al Shoaibi, A.K. Gupta, Investigation of sulfur chemistry with acid gas addition in hydrogen/air flames, Appl. Energy 113(2014)1134-1140. [14] H. Kazempour, F. Pourfayaz, M. Mehrpooya, Modeling and multi-optimization of thermal section of Claus process based on kinetic model, J. Nat. Gas Sci. Eng. 38(2017)235-244. [15] Y. Li, Q.H. Guo, Z.H. Dai, Y.C. Dong, G.S. Yu, F.C. Wang, Study of oxidation for gas mixture of H2S and CH4 in a non-premixed flame under oxygen deficient condition, Appl. Therm. Eng. 117(2017)659-667. [16] A. Raj, S. Ibrahim, A. Jagannath, Combustion kinetics of H2S and other sulfurous species with relevance to industrial processes, Prog. Energy Combust. Sci. 80(2020)100848. [17] Y.L. Xie, J.H. Wang, M. Zhang, J. Gong, W. Jin, Z.H. Huang, Experimental and numerical study on laminar flame characteristics of methane oxy-fuel mixtures highly diluted with CO2, Energy Fuels 27(10)(2013)6231-6237. [18] Y. Li, Q.H. Guo, X.L. Yu, Z.H. Dai, Y.F. Wang, G.S. Yu, F.C. Wang, Effect of O2 enrichment on acid gas oxidation and formation of COS and CS2 in a rich diffusion flame, Appl. Energy 206(2017)947-958. [19] M. Abián, M. Cebrián, Á. Millera, R. Bilbao, M.U. Alzueta, CS2 and COS conversion under different combustion conditions, Combust. Flame 162(5)(2015)2119-2127. [20] Y. Li, X.L. Yu, H.J. Li, Q.H. Guo, Z.H. Dai, G.S. Yu, F.C. Wang, Detailed kinetic modeling of homogeneous H2S CH4 oxidation under ultra-rich condition for H2 production, Appl. Energy 208(2017)905-919. [21] Y. Li, X.L. Yu, H.J. Li, Q.H. Guo, Z.H. Dai, G.S. Yu, F.C. Wang, Detailed kinetic modelling of H2S oxidation with presence of CO2 under rich condition, Appl. Energy 190(2017)824-834. [22] S.M. Wang, D. Wu, H.L. Huang, Q.Y. Yang, M.M. Tong, D.H. Liu, C.L. Zhong, Computational exploration of H2S/CH4 mixture separation using acid-functionalized UiO-66(Zr) membrane and composites, Chin. J. Chem. Eng. 23(8)(2015)1291-1299. [23] Y. Li, Z.H. Dai, Y.C. Dong, J.L. Xu, Q.H. Guo, F.C. Wang, Equilibrium prediction of acid gas partial oxidation with presence of CH4 and CO2 for hydrogen production, Appl. Therm. Eng. 107(2016)125-134. [24] D. Bongartz, A.F. Ghoniem, Chemical kinetics mechanism for oxy-fuel combustion of mixtures of hydrogen sulfide and methane, Combust. Flame 162(3)(2015)544-553. [25] H. Selim, A.K. Gupta, A. Al Shoaibi, Effect of CO2 and N2 concentration in acid gas stream on H2S combustion, Appl. Energy 98(2012)53-58. [26] S. Ibrahim, A. Raj, Kinetic simulation of acid gas (H2S and CO2) destruction for simultaneous syngas and sulfur recovery, Ind. Eng. Chem. Res. 55(24)(2016)6743-6752. [27] C.E. Lee, S.R. Lee, J.W. Han, J. Park, Numerical study on effect of CO2 addition in flame structure and NOx formation of CH4 air counterflow diffusion flames, Int. J. Energy Res. 25(4)(2001)343-354. [28] J. Berner-Cambot, C. Vovelle, R. Delbourgo, Flame structures of H2S—air diffusion flames, Symp. Int. Combust. 18(1)(1981)777-783. [29] K. Karan, L.A. Behie, CS2 formation in the Claus reaction furnace:A kinetic study of methane-sulfur and methane-hydrogen sulfide reactions, Ind. Eng. Chem. Res. 43(13)(2004)3304-3313. [30] J.M. Colom-Díaz, M. Leciñena, A. Peláez, M. Abián, R. Millera, M.U.A. Bilbao, Study of the conversion of CH4/H2S mixtures at different pressures, Fuel 262(2020)116484. [31] S. Ibrahim, A. Al Shoaibi, A.K. Gupta, Role of toluene to acid gas (H2S and CO2) combustion in H2/O2 N2 flame under Claus condition, Appl. Energy 149(2015)62-68. [32] S. Ibrahim, A. Al Shoaibi, A.K. Gupta, Effect of benzene on product evolution in a H2S/O2 flame under Claus condition, Appl. Energy 145(2015)21-26. [33] S. Ibrahim, A. Al Shoaibi, A.K. Gupta, Xylene addition effects to H2S combustion under Claus condition, Fuel 150(2015)1-7. [34] V. Palma, V. Vaiano, D. Barba, M. Colozzi, E. Palo, L. Barbato, S. Cortese, H2 production by thermal decomposition of H2S in the presence of oxygen, Int. J. Hydrog. Energy 40(1)(2015)106-113. [35] H. Selim, A. Al Shoaibi, A.K. Gupta, Effect of H2S in methane/air flames on sulfur chemistry and products speciation, Appl. Energy 88(8)(2011)2593-2600. [36] H.S.F. Chin, K. Karan, A.K. Mehrotra, L.A. Behie, The fate of methane in a Claus plant reaction furnace, Can. J. Chem. Eng. 79(4)(2001)482-490. [37] P.D. Clark, N.I. Dowling, M. Huang, W.Y. Svrcek, W.D. Monnery, Mechanisms of CO and COS formation in the Claus furnace, Ind. Eng. Chem. Res. 40(2)(2001)497-508. [38] K. Karan, A.K. Mehrotra, L.A. Behie, A high-temperature experimental and modeling study of homogeneous gas-phase COS reactions applied to Claus plants, Chem. Eng. Sci. 54(15-16)(1999)2999-3006. [39] P. Glarborg, B. Halaburt, P. Marshall, A. Guillory, J. Troe, M. Thellefsen, K. Christensen, Oxidation of reduced sulfur species:Carbon disulfide, Chem. A Eur. J. 118(34)(2014)6798-6809. [40] P.D. Clark, N.I. Dowling, M. Huang, Conversion of CS2 and COS over alumina and titania under Claus process conditions:Reaction with H2O and SO2, Appl Catal B 31(2)(2001)107-112. [41] L.G. Blevins, W.M. Pitts, Modeling of bare and aspirated thermocouples in compartment fires, Fire Saf. J. 33(4)(1999)239-259. [42] D. Green, M. Southard, Perry's Chemical Engineers'Handbook, ninth ed., McGraw-Hill, New York, USA, 2019. [43] S. Whitaker, Forced convection heat transfer correlations for flow in pipes, past flat plates, single cylinders, single spheres, and for flow in packed beds and tube bundles, AIChE J 18(2)(1972)361-371. [44] V. Kaloidas, N. Papayannakos, Kinetics of thermal, non-catalytic decomposition of hydrogen sulphide, Chem. Eng. Sci. 44(11)(1989)2493-2500. [45] H. Selim, S. Ibrahim, A. Al Shoaibi, A.K. Gupta, Effect of oxygen enrichment on acid gas combustion in hydrogen/air flames under Claus conditions, Appl. Energy 109(2013)119-124. [46] K.A. Hawboldt, W.D. Monnery, W.Y. Svrcek, New experimental data and kinetic rate expression for H2S pyrolysis and re-association, Chem. Eng. Sci. 55(5)(2000)957-966. [47] A. Stagni, S. Arunthanayothin, L. Pratali Maffei, O. Herbinet, F. Battin-Leclerc, T. Faravelli, An experimental, theoretical and kinetic-modeling study of hydrogen sulfide pyrolysis and oxidation, Chem. Eng. J. 446(2022)136723. [48] P.D. Clark, M. Huang, S. Liu, X. Long, Partial oxidation of hydrogen sulphide in the manufacture of hydrogen, sulphur, ethylene and propylene, Sulphuric Acid Ind. 4(2004)1-8. [49] C. Rhodes, S.A. Riddel, J. West, B.P. Williams, G.J. Hutchings, The lowtemperature hydrolysis of carbonyl sulfide and carbon disulfide:A review, Catal. Today 59(3-4)(2000)443-464. [50] A.M. El-Melih, L. Iovine, A. Al Shoaibi, A.K. Gupta, Production of hydrogen from hydrogen sulfide in presence of methane, Int. J. Hydrog. Energy 42(8)(2017)4764-4773. [51] H. Selim, A. Al Shoaibi, A.K. Gupta, Fate of sulfur with H2S injection in methane/air flames, Appl. Energy 92(2012)57-64. [52] D.V. Demidov, I.V. Mishin, M.N. Mikhailov, Gibbs free energy minimization as a way to optimize the combined steam and carbon dioxide reforming of methane, Int. J. Hydrog. Energy 36(10)(2011)5941-5950. [53] T.L. Zhu, A. Dreher, M. Flytzani-Stephanopoulos, Direct reduction of SO2 to elemental sulfur by methane over ceria-based catalysts, Appl Catal B 21(2)(1999)103-120. [54] Y. Murakami, M. Kosugi, K.J. Susa, T. Kobayashi, N. Fujii, Kinetics and mechanism for the oxidation of CS2 and COS at high temperature, Bull. Chem. Soc. Jpn 74(7)(2001)1233-1240. |
[1] | Yuanyuan Yin, Xujun Wang, Lei Xu, Binbin He, Yunxiang Nie, Yi Mei. Simultaneous removal of sulfur dioxide and nitrogen oxide from flue gas by phosphorus sludge: The performance and absorption mechanism [J]. Chinese Journal of Chemical Engineering, 2024, 65(1): 212-221. |
[2] | Binxia Zhao, Yijia Gao, Tiancheng Hun, Xiaoxiao Fan, Nan Shao, Xiaoqian Chen. Preparation of PrFexCo1-xO3/Mt catalyst and study on degradation of 2-hydroxybenzoic acid wastewater by catalytic wet peroxide oxidation [J]. Chinese Journal of Chemical Engineering, 2024, 65(1): 286-297. |
[3] | Xun Tao, Fan Zhou, Xinlei Yu, Songling Guo, Yunfei Gao, Lu Ding, Guangsuo Yu, Zhenghua Dai, Fuchen Wang. Effect of carbon dioxide on oxy-fuel combustion of hydrogen sulfide: An experimental and kinetic modeling [J]. Chinese Journal of Chemical Engineering, 2023, 59(7): 105-117. |
[4] | Zijie Zhang, Qianyu Zha, Ying Liu, Zhibing Zhang, Jia Liu, Zheng Zhou. Study on the epoxidation of olefins with H2O2 catalyzed by biquaternary ammonium phosphotungstic acid [J]. Chinese Journal of Chemical Engineering, 2023, 58(6): 146-154. |
[5] | Chenyang Zhao, Yinhan Cheng, Guangfei Qu, Yongheng Yuan, Fenghui Wu, Ye Liu, Shan Liu, Junyan Li, Ping Ning. High-performance liquid-phase catalytic purification of phosphine in tail gas using Pd(II)/Cu(II) composite [J]. Chinese Journal of Chemical Engineering, 2023, 57(5): 98-108. |
[6] | Bingxiao Feng, Lining Hao, Chaoting Deng, Jiaqiang Wang, Hongbing Song, Meng Xiao, Tingting Huang, Quanhong Zhu, Hengjun Gai. A highly hydrothermal stable copper-based catalyst for catalytic wet air oxidation of m-cresol in coal chemical wastewater [J]. Chinese Journal of Chemical Engineering, 2023, 57(5): 338-348. |
[7] | Shengfeng Luo, Song Zhang, Yiping Zeng, Hui Zhang, Lili Zheng, Zhaopeng Xu. Study on oxygen transport and titanium oxidation in coating cracks under parallel gas flow based on LBM modelling [J]. Chinese Journal of Chemical Engineering, 2023, 56(4): 15-24. |
[8] | Yuxi Chai, Yanan Zhang, Yannan Tan, Zhiwei Li, Huangzhao Wei, Chenglin Sun, Haibo Jin, Zhao Mu, Lei Ma. Life cycle assessment of high concentration organic wastewater treatment by catalytic wet air oxidation [J]. Chinese Journal of Chemical Engineering, 2023, 56(4): 80-88. |
[9] | Peiyin Chen, Yanxiong Fang, Kaihong Xie, Yao Chen, Yang Liu, Hongliang Zuo, Weijian Lu, Baoyu Liu. Lacunary silicotungstic heteropoly salts as high-performance catalysts in oxidation of cyclopentene [J]. Chinese Journal of Chemical Engineering, 2023, 56(4): 152-159. |
[10] | Tinghao Jia, Yunbo Yu, Qing Liu, Yao Yang, Ji-Jun Zou, Xiangwen Zhang, Lun Pan. Theoretical and experimental study on the inhibition of jet fuel oxidation by diarylamine [J]. Chinese Journal of Chemical Engineering, 2023, 56(4): 225-232. |
[11] | Da Ke, Minjia Wang, Jiancheng Ruan, Xinzhi Chen, Shaodong Zhou. Efficient, continuous oxidation of durene to pyromellitic dianhydride mediated by a V-Ti-P ternary catalyst: The remarkable doping effect [J]. Chinese Journal of Chemical Engineering, 2023, 55(3): 156-164. |
[12] | Qiongna Xiao, Yuyan Jiang, Weiqiang Yuan, Jingjing Chen, Haohong Li, Huidong Zheng. Styrene epoxidation catalyzed by polyoxometalate/quaternary ammonium phase transfer catalysts: The effect of cation size and catalyst deactivation mechanism [J]. Chinese Journal of Chemical Engineering, 2023, 55(3): 192-201. |
[13] | Mengting Liu, Xuexue Dong, Zengjing Guo, Aihua Yuan, Shuying Gao, Fu Yang. Enabling tandem oxidation of benzene to benzenediol over integrated neighboring V-Cu oxides in mesoporous silica [J]. Chinese Journal of Chemical Engineering, 2023, 55(3): 236-245. |
[14] | Jitendra Diwakar, Selvamani Arumugam, Bhavna Saini, Anup Prakash Tathod, Nagabhatla Viswanadham. Mesoporous titanium-aluminosilicate as an efficient catalyst for selective oxidation of cyclohexene at mild reaction conditions [J]. Chinese Journal of Chemical Engineering, 2023, 55(3): 257-265. |
[15] | Yu Wang, Qunfeng Zhang, Xinlei Liu, Junqi Weng, Guanghua Ye, Xinggui Zhou. Probing deactivation by coking in catalyst pellets for dry reforming of methane using a pore network model [J]. Chinese Journal of Chemical Engineering, 2023, 55(3): 293-303. |
Viewed | ||||||
Full text |
|
|||||
Abstract |
|
|||||