Sustainable Activated Carbons from Agricultural Residues Dedicated to Antibiotic Removal by Adsorption

摘要/Abstract

摘要： The objectives of this study are to convert at laboratory scale agricultural residues into activated carbons(AC) with specific properties,to characterize them and to test them in adsorption reactor for tetracycline removal,a common antibiotic.Two new ACs were produced by direct activation with steam from beet pulp(BP-H₂O) and peanut hulls(PH-H₂O) in environmental friendly conditions.BP-H₂O and PH-H₂O present carbon content ranged between 78% and 91%,similar BET surface areas(821 and 829 m²·g^-1 respectively) and pHPZC values(9.8).Their porosities are different:PH-H₂O is mainly microporous(84%) with 0.403 cm³·g^-1 of total porous volume,whereas BP-H₂O develops a mesoporous volume of 0.361 cm³·g^-1 representing 50% of the total porous volume.Two other commercial granular AC carbons(GAC1 and GAC2) were also characterised and used for comparison.The adsorption study is conducted in batch reactors.Two parts can be observed from kinetic decay curves:a very fast concentration decrease during the first 12 h,followed by a slow adsorption.An optimal contact time of 120 h is also deduced from these curves.It is shown as well that adsorption decreases with an increase of pH,indicating that the form preferentially adsorbed is probably the zwitterion form of the tetracycline.From equilibrium isotherms data,two adsorption models have been used:Langmuir and Freundlich.Both of them lead to a very good description of the experimental data.Maximum adsorption capacities deduced from the Langmuir equation follow the sequence:GAC2(817 mg·g^-1)>BP-H₂O(288 mg·g^-1)>GAC1(133 mg·g^-1)>PH-H₂O(28 mg·g^-1).In real spring waters spiked with TC(tetracyclines),adsorption isotherms show that the maximum adsorption capacity of BP-H₂O is slightly increased to 309 mg·g^-1 while it is decreased by one third to 550 mg·g^-1 in the case of GAC2.This study demonstrates that the production of AC from agricultural residues,at lab-scale,is feasible and leads to genuine activated carbons with different intrinsic properties.

关键词: activated carbon, adsorption, antibiotic, characterisation, waste valorisation, water treatment

Abstract: The objectives of this study are to convert at laboratory scale agricultural residues into activated carbons(AC) with specific properties,to characterize them and to test them in adsorption reactor for tetracycline removal,a common antibiotic.Two new ACs were produced by direct activation with steam from beet pulp(BP-H₂O) and peanut hulls(PH-H₂O) in environmental friendly conditions.BP-H₂O and PH-H₂O present carbon content ranged between 78% and 91%,similar BET surface areas(821 and 829 m²·g^-1 respectively) and pHPZC values(9.8).Their porosities are different:PH-H₂O is mainly microporous(84%) with 0.403 cm³·g^-1 of total porous volume,whereas BP-H₂O develops a mesoporous volume of 0.361 cm³·g^-1 representing 50% of the total porous volume.Two other commercial granular AC carbons(GAC1 and GAC2) were also characterised and used for comparison.The adsorption study is conducted in batch reactors.Two parts can be observed from kinetic decay curves:a very fast concentration decrease during the first 12 h,followed by a slow adsorption.An optimal contact time of 120 h is also deduced from these curves.It is shown as well that adsorption decreases with an increase of pH,indicating that the form preferentially adsorbed is probably the zwitterion form of the tetracycline.From equilibrium isotherms data,two adsorption models have been used:Langmuir and Freundlich.Both of them lead to a very good description of the experimental data.Maximum adsorption capacities deduced from the Langmuir equation follow the sequence:GAC2(817 mg·g^-1)>BP-H₂O(288 mg·g^-1)>GAC1(133 mg·g^-1)>PH-H₂O(28 mg·g^-1).In real spring waters spiked with TC(tetracyclines),adsorption isotherms show that the maximum adsorption capacity of BP-H₂O is slightly increased to 309 mg·g^-1 while it is decreased by one third to 550 mg·g^-1 in the case of GAC2.This study demonstrates that the production of AC from agricultural residues,at lab-scale,is feasible and leads to genuine activated carbons with different intrinsic properties.

Key words: activated carbon, adsorption, antibiotic, characterisation, waste valorisation, water treatment

Jonatan Torres-PΦrez, Claire GΦrente, Yves AndrŁs. Sustainable Activated Carbons from Agricultural Residues Dedicated to Antibiotic Removal by Adsorption[J]. , 2012, 20(3): 524-529.

参考文献

1 Choy, K.K.H., Barford, J.P., McKay, G., "Production of activated carbon from bamboo scaffolding waste-Process design, evaluation and sensitivity analysis", Chem. Eng. J., 109, 147-165 (2005).
2 Ioannidou, O., Zabaniotou, A., "Agricultural residues as precursors for activated carbon production-A review", Renew. Sust. Energ. Rev., 11, 1966-2005 (2007).
3 Julcour Lebigue, C., Andriantsiferana, C., Krou, N., Ayral, C., Mohameda, E., Wilhelm, A-M., Delmas, H., Le Coq, L., Gerente, C., Smith, K.M., Pullket, S., Fowler, G.D., Graham, N.J.D., "Application of sludge-based carbonaceous materials in an hybrid water treatment process based on adsorption and catalytic wet air oxidation", J. Env. Manag., 91, 2432-2439 (2010).
4 Mui, E.L.K., Cheung, W.H., Valix, M., McKay, G., "Mesoporous activated carbon from waste tyre rubber for dye removal from effluents", Micro. Meso. Mat., 130, 287-294 (2010).
5 Kuemmerer, K., "Antibiotics in the aquatic environment-A review (I)", Chemosphere, 75, 417-434 (2009).
6 Kuemmerer, K., "Antibiotics in the aquatic environment-A review (Ⅱ)", Chemosphere, 75, 435-441 (2009).
7 Sarmah, A.K., Meyer, M.T., Boxall, A.B.A., "A global perspective on the use, sales, exposure pathways, occurrence, fate and effects of veterinary antibiotics (VAs) in the environment", Chemosphere, 65, 725-759 (2006).
8 Schmitt, H., Stoob, K., Hamscher, G., Smit, E., Seinen, W., "Tetracyclines and tetracycline resistance in agricultural soils: Microcosm and field studies", Microb. Ecol., 51, 267-276 (2006).
9 Jia, D.A., Zhou, D.M., Wang, Y.J., Zhu, H.W., Chen, J.L., "Adsorption and cosorption of Cu(Ⅱ) and tetracycline on two soils with different characteristics", Geoderma, 146, 224-230 (2008).
10 Lindsey, M.E., Meyer, M., Thurman, E.M., "Analysis of trace levels of sulfonamide and tetracycline antimicrobials, in groundwater and surface water using solid phase extraction and liquid chromatography/mass spectrometry", Anal. Chem., 73, 4640-4646 (2001).
11 Batt, A.L., Aga, D.S., "Simultaneous analysis of multiple classes of antibiotics by ion trap LC/MS/MS for assessing surface water and groundwater contamination", Anal. Chem., 77, 2940-2947 (2005).
12 Kim, S., Eichhorn, P., Jensen, J.N., Werber, A.S., Aga, D.S., "Removal of antibiotics in wastewater: Effect of hydraulic and solid retention times on the fate of tetracycline in the activated sludge process", Env. Sci. Technol., 39, 5816-5823 (2005).
13 Xu, W., Zhang, G., Li, X., Zou, S., Li, P., Hu, Z., "Occurrence and elimination of antibiotics at four sewage treatment plants in the Pearl River Delta (PRD), South China", Wat. Res., 41 (19), 4526-4534 (2007).
14 Prado, N., Ochoa, J., Amrane, A., "Biodegradation by activated sludge and toxicity of tetracycline into a semi-industrial membrane bioreactor", Bior. Technol., 100, 3769-3774 (2009).
15 Bautitz, I.R., Pupo Nogueira, R.F., "Degradation of tetracycline by photo-Fenton process -Solar irradiation and matrix effects", J. Photochem. Photobio. A Chem., 187, 33-39 (2007).
16 Khan, M.H., Bae, H., Jung, J.Y., "Tetracycline degradation by ozonation in the aqueous phase: Proposed degradation intermediates and pathway", J. Hazard. Mat., 181, 659-665 (2010).
17 Maroga Mboula, V., Héquet, V., Gru, Y., Colin, R., Andrès, Y., "Assessment of the efficiency of photocatalysis on tetracycline biodegradation", J. Haz. Mat., 209-210, 355-364 (2012).
18 Choi, K.J., Kim, S.G., Kim, S.H., "Removal of tetracycline and sulfonamide classes of antibiotic compounds by powdered activated carbon", Env. Technol., 29, 333-342 (2008).
19 Ji, L., Chen, W., Duan, L., Zhu, D. "Mechanisms for strong adsorption of tetracycline to carbon nanotubes: A comparative study using activated carbon and graphite as adsorbents", Env. Sci. Technol., 43, 2322-2327 (2009).
20 ASTM Standards, "Standard test method for total ash content of activated carbon", ASTM D2866-11, American Society for Testing and Materials, USA (1994).
21 Faria, P.C.C., Orfao, J.J.M., Pereira, M.F.R., "Adsorption of anionic and cationic dyes on activated carbons with different surface chemistries", Wat. Res., 38, 2043-2052 (2004).
22 Torres-Pérez, J., Gerente, C., Andres, Y., "Conversion of agricultural residues into activated carbons for water purification: Application to arsenate removal", J. Env. Sci. Health A, 47, 1173-1185 (2012).
23 Reddad, Z., Gerente, C., Andrès, Y., Ralet, M.C., Thibault, J-F., Le Cloirec, P., "Ni(Ⅱ) and Cu(Ⅱ) binding properties of native and modified sugar beet pulp", Carb. Polym., 49, 23-31 (2002).

[1]	Yingli Li, Zhishuncheng Li, Guangfei Qu, Rui Li, Shuaiyu Liang, Junhong Zhou, Wei Ji, Huiming Tang. Mechanism, behaviour and application of iron nitrate modified carbon nanotube composites for the adsorption of arsenic in aqueous solutions[J]. 中国化学工程学报, 2023, 60(8): 26-36.
[2]	Jing Huang, Honghui Cai, Qian Zhao, Yunpeng Zhou, Haibo Liu, Jing Wang. Dual-functional pyrene implemented mesoporous silicon material used for the detection and adsorption of metal ions[J]. 中国化学工程学报, 2023, 60(8): 108-117.
[3]	Yifan Jiang, Bingqi Xie, Jisong Zhang. Highly reactive and reusable heterogeneous activated carbons-based palladium catalysts for Suzuki-Miyaura reaction[J]. 中国化学工程学报, 2023, 60(8): 165-172.
[4]	Lingli Chen, Yueting Shi, Sijun Xu, Junle Xiong, Fang Gao, Shengtao Zhang, Hongru Li. Enhanced adsorption of target branched compounds including antibiotic norfloxacin frameworks on mild steel surface for efficient protection: An experimental and molecular modelling study[J]. 中国化学工程学报, 2023, 60(8): 212-227.
[5]	Alexander Nti Kani, Evans Dovi, Aaron Albert Aryee, Runping Han, Zhaohui Li, Lingbo Qu. Mechanisms and reusability potentials of zirconium-polyaziridine-engineered tiger nut residue towards anionic pollutants[J]. 中国化学工程学报, 2023, 60(8): 275-292.
[6]	Yuan Liu, Hanting Xiong, Jingwen Chen, Shixia Chen, Zhenyu Zhou, Zheling Zeng, Shuguang Deng, Jun Wang. One-step ethylene separation from ternary C₂ hydrocarbon mixture with a robust zirconium metal-organic framework[J]. 中国化学工程学报, 2023, 59(7): 9-15.
[7]	Hui Jiang, Zijian Zhao, Ning Yu, Yi Qin, Zhengwei Luo, Wenhua Geng, Jianliang Zhu. Synthesis, characterization, and performance comparison of boron using adsorbents based on N-methyl-D-glucosamine[J]. 中国化学工程学报, 2023, 59(7): 16-31.
[8]	Chaoyi Yin, Jingyuan Ma, Jian Qiu, Ruifang Liu, Long Ba. Mass-producible low-cost flexible electronic fabrics for azo dye wastewater treatment by electrocoagulation[J]. 中国化学工程学报, 2023, 59(7): 222-230.
[9]	Runze Chen, Yuran Chen, Xuemin Liang, Yapeng Kong, Yangyang Fan, Quan Liu, Zhenyu Yang, Feiying Tang, Johnny Muya Chabu, Maru Dessie Walle, Liqiang Wang. Oxidative exfoliation of spent cathode carbon: A two-in-one strategy for its decontamination and high-valued application[J]. 中国化学工程学报, 2023, 59(7): 262-269.
[10]	Shanghong Ma, Haitao Zhang, Jianbo Qu, Xiuzhong Zhu, Qingfei Hu, Jianyong Wang, Peng Ye, Futao Sai, Shiwei Chen. Preparation of waterborne polyurethane/β-cyclodextrin composite nanosponge by ion condensation method and its application in removing of dyes from wastewater[J]. 中国化学工程学报, 2023, 58(6): 124-136.
[11]	Yueting Shi, Junhai Zhao, Lingli Chen, Hongru Li, Shengtao Zhang, Fang Gao. Double open mouse-like terpyridine parts based amphiphilic ionic molecules displaying strengthened chemical adsorption for anticorrosion of copper in sulfuric acid solution[J]. 中国化学工程学报, 2023, 57(5): 233-246.
[12]	Jian Wang, Yuanhui Shen, Donghui Zhang, Zhongli Tang, Wenbin Li. Integrated vacuum pressure swing adsorption and Rectisol process for CO₂ capture from underground coal gasification syngas[J]. 中国化学工程学报, 2023, 57(5): 265-279.
[13]	Yujia Cui, Zhiqiang Tan, Yanan Wang, Shuxian Shi, Xiaonong Chen. One-step crosslinking preparation of tannic acid particles for the adsorption and separation of cationic dyes[J]. 中国化学工程学报, 2023, 57(5): 309-318.
[14]	Shanshan Mao, Tao Shen, Qing Zhao, Tong Han, Fan Ding, Xin Jin, Manglai Gao. Selective capture of silver ions from aqueous solution by series of azole derivatives-functionalized silica nanosheets[J]. 中国化学工程学报, 2023, 57(5): 319-328.
[15]	Yuxi Chai, Yanan Zhang, Yannan Tan, Zhiwei Li, Huangzhao Wei, Chenglin Sun, Haibo Jin, Zhao Mu, Lei Ma. Life cycle assessment of high concentration organic wastewater treatment by catalytic wet air oxidation[J]. 中国化学工程学报, 2023, 56(4): 80-88.