Energy Recovery Device with a Fluid Switcher for Seawater Reverse Osmosis System

›› 2008, Vol. 16 ›› Issue (2): 329-332.

• • 上一篇

Energy Recovery Device with a Fluid Switcher for Seawater Reverse Osmosis System

孙家喜, 王越, 徐世昌, 王世昌

Chemical Engineering Research Center, State Key Laboratory of Chemical Engineering, School of Chemical Engi-neering and Technology, Tianjin University, Tianjin 300072, China

收稿日期:2007-06-06 修回日期:2007-11-28 出版日期:2008-04-28 发布日期:2008-04-28
通讯作者: WANG Shichang,E-mail:jiswang@tju.edu.cn
基金资助:
the Seawater Desalination Research Programs of Tianjin(0431852114)

Energy Recovery Device with a Fluid Switcher for Seawater Reverse Osmosis System

SUN Jiaxi, WANGYue, XU Shichang, WANG Shichang

Chemical Engineering Research Center, State Key Laboratory of Chemical Engineering, School of Chemical Engi-neering and Technology, Tianjin University, Tianjin 300072, China

Received:2007-06-06 Revised:2007-11-28 Online:2008-04-28 Published:2008-04-28
Supported by:
the Seawater Desalination Research Programs of Tianjin(0431852114)

摘要/Abstract

摘要： Energy recovery device(ERD)is an important part of the seawater reverse osmosis(SWRO)desalination system.There are principally two kinds of ERDs,the centrifugal type and the positive displacement(PD)type. The PD type is of extensive concern and is preferred in large-scale plants.In this article,an innovative fluid switcher was presented and a two-cylinder hydraulic energy recovery unit with a labscale fluid switcher was set up. Tap water was used as the working medium instead of the actual seawater and brine in SWRO desalination plants. Under steady state operating conditions,the experimental results were obtained on the variations of the pressure and flow rate to and from the energy recovery unit.The hydraulic recovery efficiency(E_H)of the energy recovery unit with the fluid switcher reached up to 76.83%.

关键词: energy recovery, seawater reverse osmosis, work exchanger, fluid switcher

Abstract: Energy recovery device(ERD)is an important part of the seawater reverse osmosis(SWRO)desalination system.There are principally two kinds of ERDs,the centrifugal type and the positive displacement(PD)type. The PD type is of extensive concern and is preferred in large-scale plants.In this article,an innovative fluid switcher was presented and a two-cylinder hydraulic energy recovery unit with a labscale fluid switcher was set up. Tap water was used as the working medium instead of the actual seawater and brine in SWRO desalination plants. Under steady state operating conditions,the experimental results were obtained on the variations of the pressure and flow rate to and from the energy recovery unit.The hydraulic recovery efficiency(E_H)of the energy recovery unit with the fluid switcher reached up to 76.83%.

Key words: energy recovery, seawater reverse osmosis, work exchanger, fluid switcher

孙家喜, 王越, 徐世昌, 王世昌. Energy Recovery Device with a Fluid Switcher for Seawater Reverse Osmosis System[J]. , 2008, 16(2): 329-332.

SUN Jiaxi, WANGYue, XU Shichang, WANG Shichang. Energy Recovery Device with a Fluid Switcher for Seawater Reverse Osmosis System[J]. , 2008, 16(2): 329-332.

参考文献

1 Farooque, A.M., Jamaluddin, A.T.M., Al-Reweli, A.R., Jalaluddin, P.A.M., Al-Marwani, S.M., Al-Mobayed, A.A., Qasim, A.H., “Parametric analyses of energy consumption and losses in SWCC SWRO plants utilizing energy recovery devices”, Desalination, 219, 137-159 (2008).
2 McHarg, J., Turby, R., “West coast researchers seek to demonstrate SWRO affordability”, Desalination & Water Reuse, 14 (3), 10-16(2004).
3 Manth, T., Gabor, M., Oklejas, E., Jr., “Minimizing RO energy consumption under variable conditions of operation”, Desalination, 157, 9-21 (2003).
4 Oklejas, E., Jr., Pergande, W.F., “Integration of advanced high-pressure pumps and energy recovery equipment yields reduced capital and operating costs of seawater RO systems”, Desalination, 127, 181-188 (2000).
5 MacHarg, J.P., “The evolution of SWRO energy recovery system”, Desalination & Water Reuse, 11 (3), 49-53(2001).
6 Bouzayani, N., Galanis, N., Orfi, J., “Comparative study of power and water cogeneration systems”, Desalination, 205, 243-253 (2007).
7 Avlonitis, S.A., Kouroumbas, K., Vlachakis, N., “Energy consumption and membrane replacement cost for seawater RO desalination plants”, Desalination, 157, 151-158(2003).
8 Schneider, B., “Selection, operation and control of a work exchanger energy recovery system based on the Singapore project”, Desalination, 184, 197-210 (2005).
9 Shumway, S.A., “Linear spool valve device for work exchanger system”, U. S. Pat., 5797429(1998).
10 Andrews, W.T., Pergande, W. F., McTaggart, G.S., “Energy performance enhancements of a 950 m³/d seawater reverse osmosis unit in Grand Cayman”, Desalination, 135, 195-204(2001).
11 Andrews, W.T., Laker, D.S., “A twelve-year history of large scale application of work exchanger energy recovery technology”, Desalination, 138, 201-206 (2001).
12 Stover, R.L., “Development of a fourth generation energy recovery device. A ‘CTO's notebook’”, Desalination, 165, 313-321 (2004).
13 Stovera, R.L., Amegliob, A., Khanc, P.A.K., “The Ghalilah SWRO plant: An overview of the solutions adopted to minimize energy consumption”, Desalination, 184, 217-221 (2005).
14 Giorgio, M., Elena, L., “Seawater reverse osmosis plant using the pressure exchanger for energy recovery: A calculation model”, Desalination, 165, 289-298 (2004).
15 Stover, R.L., “Seawater reverse osmosis with isobaric energy recovery devices”, Desalination, 203, 168-175 (2007).
16 Bross, S., Kochanowski, W., “SWRO core hydraulic module-The right concept decides in terms of energy consumption and reliability Part II. Advanced pressure exchanger design”, Desalination, 165, 351-361 (2004).
17 Bross, S., “SWRO-core-hydraulic system: First field test experience”, Desalination, 184, 223-232 (2005).
18 Bross, S., Kochanowski, W., “SWRO core hydraulic system: Extension of the SalTec DT to higher flows and lower energy consumption”, Desalination, 203, 160-167(2007).
19 Wang, Y., Wang S.C., Xu, S.C., “Experimental studies on dynamic process of energy recovery device for RO desalination plants”, Desalination, 160, 187-193 (2004).
20 Wang, Y., Wang, S.C., Xu, S.C., “Investigations on characteristics and efficiency of a positive displacement energy recovery unit”, Desalination, 177, 179-185 (2005).
21 Wang, Y., Wang, S.C., Xu, S.C., “Hydraulic energy recovery for SWRO desalination plants”, J. Chem. Ind. Eng. (China), 54 (6), 878-879 (2003).

[1]	Tongtong Zhang, Xiaohui She, Yulong Ding. A power plant for integrated waste energy recovery from liquid air energy storage and liquefied natural gas[J]. 中国化学工程学报, 2021, 34(6): 242-257.
[2]	Zhenyuan Yin, Praveen Linga. Methane hydrates: A future clean energy resource[J]. 中国化学工程学报, 2019, 27(9): 2026-2036.
[3]	Wangliang Li, Changbo Lu, Gaojun An, Yuming Zhang, Yen Wah Tong. Integration of high-solid digestion and gasification to dispose horticultural waste and chicken manure[J]. Chinese Journal of Chemical Engineering, 2018, 26(5): 1145-1151.
[4]	乞炳蔚, 王越, 王照成, 张燕平, 徐世昌, 王世昌. Theoretical Investigation on Internal Leakage and Its Effect on the Efficiency of Fluid Switcher-Energy Recovery Device for Reverse Osmosis Desalting Plant[J]. Chinese Journal of Chemical Engineering, 2013, 21(11): 1216-1223.

Energy Recovery Device with a Fluid Switcher for Seawater Reverse Osmosis System

Energy Recovery Device with a Fluid Switcher for Seawater Reverse Osmosis System

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价