Effects of CO2 Dilution on Methane Ignition in Moderate or Intense Low-oxygen Dilution(MILD) Combustion: A Numerical Study

Chinese Journal of Chemical Engineering ›› 2012, Vol. 20 ›› Issue (4): 701-709.

Effects of CO₂ Dilution on Methane Ignition in Moderate or Intense Low-oxygen Dilution(MILD) Combustion: A Numerical Study

曹甄俊^1,2, 朱彤¹

1. College of Mechanical Engineering, Tongji University, Shanghai 200092, China;
2. Shanghai DFYH Tech Services Co., Ltd., Shanghai 201114, China

收稿日期:2011-03-02 修回日期:2012-02-18 出版日期:2012-08-28 发布日期:2012-09-15
通讯作者: ZHU Tong, E-mail:zhu_tong@tongji.edu.cn
基金资助:
Supported by the National Natural Science Foundation of China (50206014);the Shuguang Scholar Program of Shanghai Education Development Foundation (05SG23)

Effects of CO₂ Dilution on Methane Ignition in Moderate or Intense Low-oxygen Dilution(MILD) Combustion: A Numerical Study

CAO Zhenjun^1,2, ZHU Tong¹

1. College of Mechanical Engineering, Tongji University, Shanghai 200092, China;
2. Shanghai DFYH Tech Services Co., Ltd., Shanghai 201114, China

Received:2011-03-02 Revised:2012-02-18 Online:2012-08-28 Published:2012-09-15
Supported by:
Supported by the National Natural Science Foundation of China (50206014);the Shuguang Scholar Program of Shanghai Education Development Foundation (05SG23)

摘要/Abstract

摘要： Homogeneous mixtures of CH₄/air under moderate or intense low-oxygen dilution(MILD) combustion conditions were numerically studied to clarify the fundamental effects of exhaust gas recirculation(EGR),especially CO₂ in EGR gases,on ignition characteristics.Specifically,effects of CO₂ addition on autoignition delay time were emphasized at temperature between 1200 K and 1600 K for a wide range of the lean-to-rich equivalence ratio(0.2~2).The results showed that the ignition delay time increased with equivalence ratio or CO₂ dilution ratio.Furthermore,ignition delay time was seen to be exponentially related with the reciprocal of initial temperature.Special concern was given to the chemical effects of CO₂ on the ignition delay time.The enhancement of ignition delay time with CO₂ addition can be mainly ascribed to the decrease of H,O and OH radicals.The predictions of temperature profiles and mole fractions of CO and CO₂ were strongly related to the chemical effects of CO₂.A single ignition time correlation was obtained in form of Arrhenius-type for the entire range of conditions as a function of temperature,CH₄ mole fraction and O₂ mole fraction.This correlation could successfully capture the complex behaviors of ignition of CH₄/air/CO₂ mixture.The results can be applied to MILD combustion as "reference time",for example,to predict ignition delay time in turbulent reacting flow.

关键词: moderate or intense low-oxygen dilution combustion, ignition delay time, autoignition, methane

Abstract: Homogeneous mixtures of CH₄/air under moderate or intense low-oxygen dilution(MILD) combustion conditions were numerically studied to clarify the fundamental effects of exhaust gas recirculation(EGR),especially CO₂ in EGR gases,on ignition characteristics.Specifically,effects of CO₂ addition on autoignition delay time were emphasized at temperature between 1200 K and 1600 K for a wide range of the lean-to-rich equivalence ratio(0.2~2).The results showed that the ignition delay time increased with equivalence ratio or CO₂ dilution ratio.Furthermore,ignition delay time was seen to be exponentially related with the reciprocal of initial temperature.Special concern was given to the chemical effects of CO₂ on the ignition delay time.The enhancement of ignition delay time with CO₂ addition can be mainly ascribed to the decrease of H,O and OH radicals.The predictions of temperature profiles and mole fractions of CO and CO₂ were strongly related to the chemical effects of CO₂.A single ignition time correlation was obtained in form of Arrhenius-type for the entire range of conditions as a function of temperature,CH₄ mole fraction and O₂ mole fraction.This correlation could successfully capture the complex behaviors of ignition of CH₄/air/CO₂ mixture.The results can be applied to MILD combustion as "reference time",for example,to predict ignition delay time in turbulent reacting flow.

Key words: moderate or intense low-oxygen dilution combustion, ignition delay time, autoignition, methane

曹甄俊, 朱彤. Effects of CO₂ Dilution on Methane Ignition in Moderate or Intense Low-oxygen Dilution(MILD) Combustion: A Numerical Study[J]. Chinese Journal of Chemical Engineering, 2012, 20(4): 701-709.

CAO Zhenjun, ZHU Tong. Effects of CO₂ Dilution on Methane Ignition in Moderate or Intense Low-oxygen Dilution(MILD) Combustion: A Numerical Study[J]. Chin.J.Chem.Eng., 2012, 20(4): 701-709.

参考文献

1 Yang,W.,Blasiak,W.,"Flame entrainments induced by a turbulent reacting jet using high-temperature and oxygen-deficient oxidizers", Energy Fuels,19(4),1473-1483(2005).
2 Gupta,A.K.,Bolz,S.,Hasegawa,T.,"Effect of air preheat temperature and oxygen concentration on flame structure and emission",J. Energy Resources Technol.,121(3),209-216(1999).
3 Yang,W.,Blasiak,W.,"Numerical simulation of properties of a LPG flame with high-temperature air",Int.J.Therm.Sci.,44(10),973-985(2005).
4 Yuan,J.,Naruse,L.,"Effects of air dilution on highly preheated air combustion in a regenerative furnace",Energy Fuels,13(1),99-104 (1998).
5 Cavaliere,A.,de Joannon,M.,"Mild combustion",Progr.Energy Combust.Sci.,30(4),329-366(2004)
6 Wünning,J.A.,Wünning,J.G.,"Flameless oxidation to reduce thermal NO-formation",Progr.Energy Combust.Sci.,23(1),81-94 (1997).
7 Yang,W.,Blasiak,W.,"Numerical study of fuel temperature influence on single gas jet combustion in highly preheated and oxygen deficient air",Energy,30(2-4),385-398(2005).
8 Spadaccini,L.J.,Colket Iii,M.B.,"Ignition delay characteristics of methane fuels",Progr.Energy Combust.Sci.,20(5),431-460(1994).
9 Holton,M.M.,Gokulakrishnan,P.,Klassen,M.S.,Roby,R.J.,Jackson,G.S.,"Autoignition delay time measurements of methane,ethane,and propane pure fuels and methane-based fuel blends",J.Eng. Gas Turbines Power,132(9),091502(2010).
10 Petersen,E.L.,Kalitan,D.M.,Simmons,S.,Bourque,G.,Curran, H.J.,Simmie,J.M.,"Methane/propane oxidation at high pressures: Experimental and detailed chemical kinetic modeling",Proc.Combust.Inst.,31(1),447-454(2007).
11 Healy,D.,Curran,H.J.,Simmie,J.M.,Kalitan,D.M.,Zinner,C.M., Barrett,A.B.,Petersen,E.L.,Bourque,G.,"Methane/ethane/propane mixture oxidation at high pressures and at high,intermediate and low temperatures",Combust.Flame,155(3),441-448(2008).
12 Healy,D.,Curran,H.J.,Dooley,S.,Simmie,J.M.,Kalitan,D.M., Petersen,E.L.,Bourque,G.,"Methane/propane mixture oxidation at high pressures and at high,intermediate and low temperatures", Combust.Flame,155(3),451-461(2008).
13 Noorpoor,A.R.,Ghaffarpour,M.,Aghsaee,M.,Hamedani,A.,"Effects of fuel additives on ignition timing of methane fuelled HCCI engine",J.Energy Inst.,82(1),37-42(2009).
14 Morsy,M.H.,Chung,S.H.,"Effect of additives on ignition of methane at homogeneous charge compression ignition engine-like conditions", Proc.Inst.Mech.Eng.D J.Automobile Eng.,221(5),605-619(2007).
15 Lutz,A.E.,Kee,R.J.,Miller,J.A.,"Senkin:A Fortran program for predicting homogeneous gas phase chemical kinetics with sensitivity analysis",Sandia National Laboratories Report,SAND87-8248 (1987).
16 Donato,N.S.,Petersen,E.L.,"Simplified correlation models for CO/H₂ chemical reaction times",Int.J.Hydrogen Energy,33(24),7565-7579(2008).
17 Golovitchev,V.I.,Pilia,M.L.,Bruno,C.,"Autoignition of methane mixtures—The effect of hydrogen peroxide",J.Propul.Power,12 (4),699-707(1996).
18 Golovitchev,V.I.,Chomiak,J.,"Evaluation of ignition improvers for methane autoignition",Combust.Sci.Technol.,135(1),31-47(1998).
19 Westbrook,C.K.,"Chemical kinetics of hydrocarbon ignition in practical combustion systems",Proc.Combust.Inst.,28(2),1563-1577 (2004).
20 Kee,R.J.,Rupley,F.M.,Miller,J.A.,Coltrin,M.E.,Grcar,J.F., Meeks,E.,Moffat,H.K.,Lutz,A.E.,Dixon-Lewis,G.,Smooke, M.D.,Warnatz,J.,Evans,G.H.,Larson,R.S.,Mitchell,R.E.,Petzold, L.R.,Reynolds,W.C.,Caracotsios,M.,Stewart,W.E.,Glarborg,P., Wang,C.,Adigun,O.,Houf,W.G.,Chou,C.P.,Miller,P.,Ho,P., Young,D.J.,CHEMKIN Release 4.0,Reaction Design,Inc.,San Diego,CA(2004).
21 Smith,G.P.,Golden,D.M.,Frenklach,M.,Moriarty,N.W., "GRI-Mech 3.0",[2010-10-10],http://www.me.berkeley.edu/gri-mech/
22 Park,J.,Hwang,D.J.,Park,J.S.,Kim,J.S.,Keel,S.I.,Cho,H.C., Noh,D.S.,Kim,T.K.,"Hydrogen utilization as a fuel:Hydrogen-blending effects in flame structure and NO emission behaviour of CH₄-air flame",Int.J.Energy Res.,31(5),472-485(2007).
23 Liu,F.,Guo,H.,Smallwood,G.J.,"The chemical effect of CO₂ replacement of N₂ in air on the burning velocity of CH₄ and H₂ premixed flames",Combust.Flame,133(4),495-497(2003).

[1]	Yu Wang, Qunfeng Zhang, Xinlei Liu, Junqi Weng, Guanghua Ye, Xinggui Zhou. Probing deactivation by coking in catalyst pellets for dry reforming of methane using a pore network model[J]. 中国化学工程学报, 2023, 55(3): 293-303.
[2]	Yimin Zhang, Ruiming Zeng, Yun Zu, Linhua Zhu, Yi Mei, Yongming Luo, Dedong He. Low-temperature dry reforming of methane tuned by chemical speciations of active sites on the SiO₂ and γ-Al₂O₃ supported Ni and Ni-Ce catalysts[J]. 中国化学工程学报, 2022, 48(8): 76-90.
[3]	Xinyu Yan, Bobo Wang, Hongxia Liang, Jie Yang, Jie Zhao, Fabrice Ndayisenga, Hongxun Zhang, Zhisheng Yu, Zhi Qian. Enhanced straw fermentation process based on microbial electrolysis cell coupled anaerobic digestion[J]. 中国化学工程学报, 2022, 44(4): 239-245.
[4]	Xin Jiang, Baojiang Sun, Zhiyuan Wang, Wantian Zhou, Jiakai Ji, Litao Chen. Methane hydrate crystal growth on shell substrate[J]. 中国化学工程学报, 2022, 43(3): 50-61.
[5]	Tongan Yan, Dahuan Liu, Qingyuan Yang, Chongli Zhong. Screening and design of COF-based mixed-matrix membrane for CH₄/N₂ separation[J]. 中国化学工程学报, 2022, 42(2): 170-177.
[6]	Jia Ren, Feng Xin, Yongsheng Xu. A review on direct synthesis of dimethoxymethane[J]. 中国化学工程学报, 2022, 50(10): 43-55.
[7]	Yu Zhang, Lei Zhang, Chang Chen, Hao-Peng Zeng, Xiao-Sen Li, Bo Yang. Role of different types of water in bentonite clay on hydrate formation and decomposition[J]. 中国化学工程学报, 2022, 50(10): 310-316.
[8]	Zhixia Deng, Shuanshi Fan, Yanhong Wang, Xuemei Lang, Gang Li. Enhance hydrates formation with stainless steel fiber for high capacity methane storage[J]. 中国化学工程学报, 2022, 50(10): 435-443.
[9]	Jian Song, Claudia Li, Shao Zhang, Xiuxia Meng, Bo Meng, Jaka Sunarso. Catalyst-modified perovskite hollow fiber membrane for oxidative coupling of methane[J]. 中国化学工程学报, 2022, 41(1): 412-419.
[10]	Ruolin Guan, Hairong Yuan, Liang Zhang, Xiaoyu Zuo, Xiujin Li. Combined pretreatment using CaO and liquid fraction of digestate of rice straw: Anaerobic digestion performance and electron transfer[J]. 中国化学工程学报, 2021, 36(8): 223-232.
[11]	Zichao Hu, Chao Li, Dengfeng Zhang. Interactions of dynamic supercritical CO₂ fluid with different rank moisture-equilibrated coals: Implications for CO₂ sequestration in coal seams[J]. 中国化学工程学报, 2021, 35(7): 288-301.
[12]	Shenglai Li, Lisong Fan, Lina Song, Dangguo Cheng, Fengqiu Chen. Influence of extra-framework Al in Fe-MOR catalysts for the direct conversion of methane to oxygenates by nitrous oxide[J]. 中国化学工程学报, 2021, 33(5): 132-138.
[13]	Bo Lu, Yuanhui Shen, Zhongli Tang, Donghui Zhang, Gaofei Chen. Vacuum pressure swing adsorption process for coalbed methane enrichment[J]. 中国化学工程学报, 2021, 32(4): 264-280.
[14]	Xuke Ruan, Xiao-Sen Li. Investigation of the methane hydrate surface area during depressurization-induced dissociation in hydrate-bearing porous media[J]. 中国化学工程学报, 2021, 32(4): 324-334.
[15]	Xitong Wang, Hairong Yuan, Xiaocong Song, Xiujin Li, Xiaoyu Zuo. Lower temperature hydrothermal pretreatment improves the anaerobic digestion performance of spent cow bedding[J]. 中国化学工程学报, 2021, 39(11): 255-260.

Effects of CO₂ Dilution on Methane Ignition in Moderate or Intense Low-oxygen Dilution(MILD) Combustion: A Numerical Study

Effects of CO₂ Dilution on Methane Ignition in Moderate or Intense Low-oxygen Dilution(MILD) Combustion: A Numerical Study

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价