A three-dimensional CFD study of the hydrodynamic behavior of equal and unequal-sized in-line methane bubbles at high pressure

doi:10.1016/j.cjche.2017.12.009

摘要/Abstract

摘要： The hydrodynamic behavior of multiple bubbles rising upward is a field of ongoing research since various aspects of their interaction require further analysis. Shape deformation, rise velocity, and drag coefficient are some of the uncertainties to be determined in a bubble upward flow. For this study the predictions of the three-dimensional numerical simulations of the volume of fluid (VOF) CFD model were first compared with experimental results available in the literature, serving as benchmark cases. Next, 28 cases of pairs of equal and unequal-sized in-line pairs of bubbles moving upwards were simulated. The bubble size varied between 2.0-10 mm. Breakthrough of the present study is the small initial distance of 2.5 R between the center of the bubbles. To provide a more practical nature in this study material properties were selected to match methane gas and seawater properties at deepsea conditions of 15 MPa and 4℃, thus yielding a fluid-to-bubble density ratio λ=7.45 and viscosity ratio n=100.46. This is one of the few studies to report results of the coalescence procedure in this context. The hydrodynamic behavior of the leading and trailing bubbles was thoroughly studied. Simulation results of the evolution of the rise velocity and the shape deformation with time indicate that the assumption that the leading bubble is rising as a free rising single one is not valid for bubbles between 2.0-7.0 mm. Finally, results of the volume of the daughter bubble exhibited an oscillating nature.

关键词: Bubble, Coalescence, Computational fluid dynamics, CFD, Methane, Rise velocity, Shape deformation

Abstract: The hydrodynamic behavior of multiple bubbles rising upward is a field of ongoing research since various aspects of their interaction require further analysis. Shape deformation, rise velocity, and drag coefficient are some of the uncertainties to be determined in a bubble upward flow. For this study the predictions of the three-dimensional numerical simulations of the volume of fluid (VOF) CFD model were first compared with experimental results available in the literature, serving as benchmark cases. Next, 28 cases of pairs of equal and unequal-sized in-line pairs of bubbles moving upwards were simulated. The bubble size varied between 2.0-10 mm. Breakthrough of the present study is the small initial distance of 2.5 R between the center of the bubbles. To provide a more practical nature in this study material properties were selected to match methane gas and seawater properties at deepsea conditions of 15 MPa and 4℃, thus yielding a fluid-to-bubble density ratio λ=7.45 and viscosity ratio n=100.46. This is one of the few studies to report results of the coalescence procedure in this context. The hydrodynamic behavior of the leading and trailing bubbles was thoroughly studied. Simulation results of the evolution of the rise velocity and the shape deformation with time indicate that the assumption that the leading bubble is rising as a free rising single one is not valid for bubbles between 2.0-7.0 mm. Finally, results of the volume of the daughter bubble exhibited an oscillating nature.

Key words: Bubble, Coalescence, Computational fluid dynamics,CFD, Methane, Rise velocity, Shape deformation

Nikolaos A. Avgerinos, Dionissios P. Margaris. A three-dimensional CFD study of the hydrodynamic behavior of equal and unequal-sized in-line methane bubbles at high pressure[J]. Chinese Journal of Chemical Engineering, 2018, 26(9): 1792-1802.

参考文献

[1] D.G. Karamanev, Equations for calculation of the terminal velocity and drag coefficient of solid spheres and gas bubbles, Chem. Eng. Commun. 147(1) (1996) 75-84.

[2] A. Koynov, J.G. Khinast, G. Tryggvason, Mass transfer and chemical reactions in bubble swarms with dynamic interfaces, AICHE J. 51(10) (2005)2786-2800.

[3] K. Terasaka, H. Shibata, Oxygen transfer in viscous non-Newtonian liquids having yield stress in bubble columns, Chem. Eng. Sci. 58(23) (2003) 5331-5337.

[4] A. Tomiyama, G.P. Celata, S. Hosokawa, S. Yoshida, Terminal velocity of single bubbles in surface tension force dominant regime, Int. J. Multiphase Flow 28(9) (2002) 1497-1519.

[5] G.P. Celata, M. Cumo, F. D'Annibale, A. Tomiyama, The wake effect on bubble rising velocity in one-component systems, Int. J. Multiphase Flow 30(7) (2004) 939-961.

[6] P. Chen, M.P. Dudukovi, J. Sanyal, Three-dimensional simulation of bubble column flows with bubble coalescence and breakup, AICHE J. 51(3) (2005) 696-712.

[7] T.J. Lin, G.M. Lin, Mechanisms of in-line coalescence of two-unequal bubbles in a non-Newtonian fluid, Chem. Eng. J. 155(3) (2009) 750-756.

[8] M. Martin, F.J. Montes, M.A. Galán, Mass transfer rates from oscillating bubbles in bubble columns operating with viscous fluids, Ind. Eng. Chem. Res. 47(23) (2008) 9527-9536.

[9] W. Kracht, J.A. Finch, Effect of frother on initial bubble shape and velocity, Int. J. Miner. Process. 94(3-4) (2010) 115-120.

[10] A. Tomiyama, I. Kataoka, I. Zun, T. Sakaguchi, Drag coefficients of single bubbles under normal and micro gravity conditions, JSME Int. J. Ser. B Fluids Therm. Eng. 41(2) (1998) 472-479.

[11] J. Zhang, L.S. Fan, On the rise velocity of an interactive bubble in liquids, Chem. Eng. J. 92(1-3) (2003) 169-176.

[12] J. Ramirez-Munoz, S. Baz-Rodriguez, E. Salinas-Rodriguez, E. Castellanos-Sahagún, H. Puebla, Forces on aligned rising spherical bubbles at low-to-moderate Reynolds number, Phys. Fluids 25(2013), 093303.

[13] S.A. Baz-Rodriguez, J. Ramirez-Munoz, A. Soria, J.C. Sacramento-Rivero, Hydrodynamic interaction of two spherical bubbles rising in-line:A semianalytical approach, Chem. Eng. Commun. 201(5) (2014) 674-687.

[14] C. Zhu, S.C. Liang, L.S. Fan, Particle wake effects on the drag force of an interactive particle, Int. J. Multiphase Flow 20(1) (1994) 117-129.

[15] J. Katz, C. Meneveau, Wake-induced relative motion of bubbles rising in line, Int. J. Multiphase Flow 22(2) (1996)239-258.

[16] M.C. Ruzicka, On bubbles rising in line, Int. J. Multiphase Flow 26(7) (2000) 1141-1181.

[17] L. Zhang, C. Yang, Z.S. Mao, Unsteady motion of a single bubble in highly viscous liquid and empirical correlation of drag coefficient, Chem. Eng. Sci. 63(8) (2008)2099-2106.

[18] X. Yan, Y. Jia, L. Wang, Y. Cao, Drag coefficient fluctuation prediction of a single bubble rising in water, Chem. Eng. J. 316(2017) 553-562.

[19] M. Cheng, J. Hua, J. Lou, Simulation of bubble-bubble interaction using a lattice Boltzmann method, Comput. Fluids 39(2) (2010)260-270.

[20] H. Yuan, A. Prosperetti, On the in-line motion of two spherical bubbles in a viscous fluid, J. Fluid Mech. 278(1994) 325-349.

[21] L. Chen, S.V. Garimella, J.A. Reizes, E. Leonardi, Motion of interacting gas bubbles in a viscous liquid including wall effects and evaporation, Numer. Heat Transf. A Appl. 31(6) (1997) 629-654.

[22] D. Legendre, J. Magnaudet, G. Mougin, Hydrodynamic interactions between two spherical bubbles rising side by side in a viscous liquid, J. Fluid Mech. 497(2003) 133-166.

[23] E.J. Sauter, S.I. Muyakshin, J.-L. Charlou, M. Schlüter, A. Boetius, K. Jerosch, E. Damm, J.-P. Foucher, M. Klages, Methane discharge from a deep-sea submarine mud volcano into the upper water column by gas hydrate-coated methane bubbles, Earth Planet. Sci. Lett. 243(2006) 354-365.

[24] C.W. Hirt, B.D. Nichols, Volume of fluid (VOF) method for the dynamics of free boundaries, J. Comput. Phys. 39(1) (1981)201-225.

[25] J. Brackbill, D. Kothe, C. Zemach, A continuum method for modelling surface tension, J. Comput. Phys. 100(1992) 335-354.

[26] G. Brereton, D. Korotney, Coaxial and Oblique Coalescence of Two Rising Bubbles, in Dynamics of Bubbles and Vortices Near a Free Surface, ASME, 119, 1991(New York).

[27] K. Laqua, K. Malone, M. Hoffmann, D. Krause, M. Schlüter, Methane bubble rise velocities under deep-sea conditions-Influence of initial shape deformation, Colloids Surf. A Physicochem. Eng. Asp. 505(2016) 106-117.

[28] M. van Sint Annaland, N.G. Deen, J.A.M. Kuipers, Numerical simulation of gas bubbles behaviour using a three-dimensional volume of fluid method, Chem. Eng. Sci. 60(2005)2999-3011.

[29] A. Zhang, P. Sun, F. Ming, An SPH modeling of bubble rising and coalescing in three dimensions, Comput. Methods Appl. Mech. Eng. 294(2015) 189-209.

[30] W. Dijkhuizen, E.I.V. van den Hengel, N.G. Deen, M. van Sint Annaland, J.A.M. Kuipers, Numerical investigation of closures for interface forces acting on single air-bubbles inwater usingVolume of Fluid and Front Tracking models, Chem. Eng. Sci. 60(2005) 6169-6175.