Properties of Bio-oil from Fast Pyrolysis of Rice Husk

›› 2011, Vol. 19 ›› Issue (1): 116-121.

Properties of Bio-oil from Fast Pyrolysis of Rice Husk

郭秀娟, 王树荣, 王琦, 郭祚刚, 骆仲泱

State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China

收稿日期:2010-07-05 修回日期:2010-10-13 出版日期:2011-02-28 发布日期:2011-02-28
通讯作者: WANG Shurong, E-mail: srwang@zju.edu.cn
基金资助:
Supported by the International Science and Technology Cooperation Program of China(2009DFA61050);the National High Technology Research and Development Program of China(2009AA05Z407);the National Natural Science Foundation of China(50676085,90610035)

Properties of Bio-oil from Fast Pyrolysis of Rice Husk

GUO Xiujuan, WANG Shurong, WANG Qi, GUO Zuogang, LUO Zhongyang

State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China

Received:2010-07-05 Revised:2010-10-13 Online:2011-02-28 Published:2011-02-28
Supported by:
Supported by the International Science and Technology Cooperation Program of China(2009DFA61050);the National High Technology Research and Development Program of China(2009AA05Z407);the National Natural Science Foundation of China(50676085,90610035)

摘要/Abstract

摘要： Physicochemical properties of bio-oil obtained from fast pyrolysis of rice husk were studied in the present work.Molecular distillation was used to separate the crude bio-oil into three fractions viz.light fraction,middle fraction and heavy fraction.Their chemical composition was analyzed by gas chromatograph and mass spectrometer(GC-MS).The thermal behavior,including evaporation and decomposition,was investigated using thermogravimetric analyzer coupled with Fourier transform infrared spectrometer(TG-FTIR).The product distribution was significantly affected by contents of cellulose,hemicellulose and lignin.The bio-oil yield was 46.36%(by mass) and the yield of gaseous products was 27%(by mass).The chemicals in the bio-oil included acids,aldehydes,ketones,alcohols,phenols,sugars,etc.The light fraction was mainly composed of acids and compounds with lower boiling point temperature,the middle and heavy fractions were consisted of phenols and levoglucosan.The thermal stability of the bio-oil was determined by the interactions and intersolubility of compounds.It was found that the thermal stability of bio-oil was better than the light fraction,but worse than the middle and heavy fractions.

关键词: biochemical engineering, bio-oil, fast pyrolysis, decomposition, distillation

Abstract: Physicochemical properties of bio-oil obtained from fast pyrolysis of rice husk were studied in the present work.Molecular distillation was used to separate the crude bio-oil into three fractions viz.light fraction,middle fraction and heavy fraction.Their chemical composition was analyzed by gas chromatograph and mass spectrometer(GC-MS).The thermal behavior,including evaporation and decomposition,was investigated using thermogravimetric analyzer coupled with Fourier transform infrared spectrometer(TG-FTIR).The product distribution was significantly affected by contents of cellulose,hemicellulose and lignin.The bio-oil yield was 46.36%(by mass) and the yield of gaseous products was 27%(by mass).The chemicals in the bio-oil included acids,aldehydes,ketones,alcohols,phenols,sugars,etc.The light fraction was mainly composed of acids and compounds with lower boiling point temperature,the middle and heavy fractions were consisted of phenols and levoglucosan.The thermal stability of the bio-oil was determined by the interactions and intersolubility of compounds.It was found that the thermal stability of bio-oil was better than the light fraction,but worse than the middle and heavy fractions.

Key words: biochemical engineering, bio-oil, fast pyrolysis, decomposition, distillation

郭秀娟, 王树荣, 王琦, 郭祚刚, 骆仲泱. Properties of Bio-oil from Fast Pyrolysis of Rice Husk[J]. , 2011, 19(1): 116-121.

GUO Xiujuan, WANG Shurong, WANG Qi, GUO Zuogang, LUO Zhongyang. Properties of Bio-oil from Fast Pyrolysis of Rice Husk[J]. , 2011, 19(1): 116-121.

参考文献

1 Mohan, D., Pittman, C.U., Steele, P.H., “Pyrolysis of wood/biomass for bio-oil: A critical review”, Energy Fuels, 20, 848-889 (2006).
2 Strezov, V., Patterson, M., Zymla, V., Fisher, K., Evans, T.J., Nelson, P.F., “Fundamental aspects of biomass carbonization”, J. Anal. Appl. Pyrolysis, 79, 91-100 (2007).
3 Xu, X.B., Lin, J.P., Cen, P.L., “Advanced in the research and development of acrylic acid production from biomass”, Chin. J. Chem. Eng., 14 (4), 419-427 (2006).
4 Huber, G.W., Iborra, S., Corma, A., “Synthesis of transportation fuels from biomass: Chemistry, catalysts and engineering”, Chem. Rev.,106, 4044-4098 (2006).
5 Budarin, V.L., Clark, J.H., Lanigan, B.A., Shuttleworth, P., Breeden, S.W., Wilson, A.J., Macquarrie, D.J., Milkowski, K., Jones, J., Bridgeman, T., Ross, A., “The preparation of high-grade bio-oils through the controlled, low temperature microwave activation of wheat straw”, Bioresour. Technol., 100, 6064-6068 (2009).
6 Lédé, J., Broust, F., Ndiaye, F.T., Ferrer, M., “Properties of bio-oils produced by biomass fast pyrolysis in a cyclone reactor”, Fuel, 86,1800-1810 (2007).
7 Bridgwater, A.V., Meier, D., Radlein, D., “An overview of fast pyrolysis of biomass”, Org. Geochem., 30, 1479-1493 (1999).
8 Luo, Z.Y., Wang, S.Y., Liao, Y.F., Zhou, J.S., Gu, Y.L., Cen, K.F., “Research on biomass fast pyrolysis for liquid fuel”, Biomass Bioenergy, 26, 455-462 (2004).
9 Park, H.J., Park, Y.K., Kim, J.S., “Influence of reaction conditions and the char separation system on the production of bio-oil from radiata pine sawdust by fast pyrolysis”, Fuel Process. Technol., 89,797-802 (2008).
10 Zheng, J.L., “Bio-oil from fast pyrolysis of rice husk: Yields and related properties and improvement of the pyrolysis system”, J. Anal. Appl. Pyrolysis, 80, 30-35 (2007).
11 Zheng, J.L., Yi, W.M., Wang, N.N., “Bio-oil production from cotton stalk”, Energy Convers. Manage., 49, 1724-1730 (2008).
12 Miao, X., Wu, Q., Yang, C., “Fast pyrolysis of microalgae to produce renewable fuels”, J. Anal. Appl. Pyrolysis, 71, 855-863 (2004).
13 zbay, N., Uzun, B.B., Varol, E.A., Pütün, A.E., “Comparative analysis of pyrolysis oils and its subfractions under different atmospheric conditions”, Fuel Process. Technol., 87, 1013-1019 (2006).
14 Qi, W., Qian, L., Bo, H., Wang, S.Y., Luo, Z.Y., Cen, K.F., “Experimental research on biomass flash pyrolysis for bio-oil in a fluidized bed reactor”, J. Eng. Thermophys., 29, 885-892 (2008).
15 Guo, X.J., Wang, S.R., Guo, Z.G., Luo, Z.Y., Cen, K.F., “Pyrolysis characteristics of bio-oil fractions separated by molecular distillation”, Appl. Energy, 87, 2892-2898 (2010).
16 Ranzi, E., Cuoci, A., Faravelli, T., Frassoldati, A., Migliavacca, G., Pierucci, S., Sommariva, S., “Chemical kinetics of biomass pyrolysis”, Energy Fuels, 22, 4292-4300 (2008).
17 Wang, G., Li, A.M., “Thermal decomposition and kinetics of mixtures of polylactic acid and biomass during copyrolysis”, Chin. J. Chem. Eng., 16 (6), 923-933 (2008).
18 Branca, C., Giudicianni, P., Blasi, C.D., “GC/MS characterization of liquids generated from low-temperature pyrolysis of wood”, Ind. Eng. Chem. Res., 42, 3190-3202 (2003).
19 Branca, C., Blasi, C.D., Elefante R., “Devolatilization and heterogeneous combustion of wood fast pyrolysis oils”, Ind. Eng. Chem. Res.,44, 799-810 (2005).
20 Caballero, J.A., Font, R., Marcilla, A., “Kinetic study of the secondary thermal decomposition of kraft lignin”, J. Anal. Appl. Pyrolysis,38, 131-152 (1996).
21 Branca, C., Blasi, C.D., Elefante, R., “Devolatilization of conventional pyrolysis oils generated from biomass and cellulose”, Energy Fuels, 20, 2253-2261 (2006).
22 Fu, P., Hu, S., Xiang, J., Sun, L.S., Yang, T., Zhang, A.C., Zhang, J.Y., “Mechanism study of rice straw pyrolysis by Fourier transform infrared technique”, Chin. J. Chem. Eng., 17 (3), 522-529 (2009).
23 Das, D., Lee, J.F., Cheng, S., “Selective synthesis of bisphenol-A over mesoporous MCM silica catalysts functionalized with sulfonic acid groups”, J. Catal., 223, 152-160 (2004).

[1]	Yingxi Gao, Jiayi Shi, Jie Wang, Fan Zhang, Shichao Tian, Zhiyong Zhou, Zhongqi Ren. Enrichment of nervonic acid in Acer truncatum Bunge oil by combination of two-stage molecular distillation, one-stage urea complexation and five-stage solvent crystallization[J]. 中国化学工程学报, 2023, 59(7): 61-71.
[2]	Kejin Huang, Shuaishuai Han, Lijing Zang, Haisheng Chen, Yihang Luo, Liang Zhang, Yang Yuan, Xing Qian, Shaofeng Wang. Configuring topologically optimum vapor recompressed dividing-wall distillation columns to maximize operating efficiency[J]. 中国化学工程学报, 2023, 57(5): 247-264.
[3]	Xinhao Li, Qing Ye, Jinlong Li, Lingqiang Yan, Xue Jian, Licheng Xie, Jianyu Zhang. Investigation of energy-efficient heat pump assisted heterogeneous azeotropic distillation for separating of acetonitrile/ethyl acetate/n-hexane mixture[J]. 中国化学工程学报, 2023, 55(3): 20-33.
[4]	Wei Qin, Lijing Zang, Kejin Huang, Haisheng Chen, Yang Yuan, Xing Qian, Liang Zhang, Shaofeng Wang. Reinforced temperature control of a reactive double dividing-wall distillation column[J]. 中国化学工程学报, 2023, 54(2): 288-295.
[5]	Qinggang Xu, Yasen Dai, Qing Zhao, Zhengrun Chen, Peizhe Cui, Zhaoyou Zhu, Yinglong Wang, Jun Gao, Yixin Ma. Economy, environmental assessment and energy conservation for separation of isopropanol/diisopropyl ether/water multi-azeotropes via extractive distillation coupled pervaporation process[J]. 中国化学工程学报, 2023, 54(2): 353-363.
[6]	Zhiwei Wang, Yu Zhang, Zhi Zhang, Daowei Zhou, Zhikai Cao, Yong Sha. Investigation on catalytic distillation for ethyl acetate production with different catalytic packing structures[J]. 中国化学工程学报, 2023, 53(1): 63-72.
[7]	Xinqiang You, Kai Zhao, Ling Li, Ting Qiu. Ionic liquids as entrainer in extractive distillation for effectively separating 1-propanol–water azeotropic mixture[J]. 中国化学工程学报, 2022, 49(9): 224-233.
[8]	Jia Ren, Zengqiang Chen, Mingwei Sun, Qinglin Sun, Zenghui Wang. Proportion integral-type active disturbance rejection generalized predictive control for distillation process based on grey wolf optimization parameter tuning[J]. 中国化学工程学报, 2022, 49(9): 234-244.
[9]	Lei Sun, Zhongjun Zhao, Xiushan Yang, Yan Sun, Quande Li, Chunhui Luo, Qiang Zhao. Thermochemical decomposition of phosphogypsum with Fe-P slag via a solid-state reaction[J]. 中国化学工程学报, 2022, 47(7): 113-119.
[10]	Xiaomin Qiu, Yuanyuan Shen, Zhengkun Hou, Qi Wang, Zhaoyou Zhu, Yinglong Wang, Jingwei Yang, Jun Gao. Mechanism analysis of solvent selectivity and energy-saving optimization in vapor recompression-assisted extractive distillation for separation of binary azeotrope[J]. 中国化学工程学报, 2022, 46(6): 271-279.
[11]	Song Hu, Jinlong Li, Qihua Wang, Weisheng Yang. Design and optimization of an integrated process for the purification of propylene oxide and the separation of propylene glycol by-product[J]. 中国化学工程学报, 2022, 45(5): 111-120.
[12]	Hui Pan, Xinshuang Li, Yichao Shen, Xiang Wu, Feng Ju, Yuzhe Li, Gaosheng Wu, Bo Ai, Baoyun Xu, Hao Ling. Novel design of lubricant-type vacuum distillation process for lube base oils production from hydrocracking tail oil[J]. 中国化学工程学报, 2022, 45(5): 121-132.
[13]	Weizhou Jiao, Xingyue Wei, Shengjuan Shao, Youzhi Liu. Catalytic decomposition and mass transfer of aqueous ozone promoted by Fe-Mn-Cu/γ-Al₂O₃ in a rotating packed bed[J]. 中国化学工程学报, 2022, 45(5): 133-142.
[14]	Jun Pan, Xianli Xu, Zhaohui Wang, Shi-Peng Sun, Zhaoliang Cui, Lassaad Gzara, Iqbal Ahmed, Omar Bamaga, Mohammed Albeirutty, Enrico Drioli. Innovative hydrophobic/hydrophilic perfluoropolyether (PFPE)/polyvinylidene fluoride (PVDF) composite membrane for vacuum membrane distillation[J]. 中国化学工程学报, 2022, 45(5): 248-257.
[15]	Ran An, Shengxin Chen, Shun Hou, Yuting Zhu, Chunhu Li, Xinbao Zhu, Ruixia Liu, Weizhong An. Simulation and design of a heat-integrated double-effect reactive distillation process for propylene glycol methyl ether production[J]. 中国化学工程学报, 2022, 52(12): 103-114.

Properties of Bio-oil from Fast Pyrolysis of Rice Husk

Properties of Bio-oil from Fast Pyrolysis of Rice Husk

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价