Selective oxidation of methylamine over zirconia supported Pt-Ru, Pt and Ru catalysts

doi:10.1016/j.cjche.2014.10.023

Chin.J.Chem.Eng. ›› 2015, Vol. 23 ›› Issue (7): 1206-1213.DOI: 10.1016/j.cjche.2014.10.023

• ENERGY, RESOURCES AND ENVIRONMENTAL TECHNOLOGY • Previous Articles Next Articles

Selective oxidation of methylamine over zirconia supported Pt-Ru, Pt and Ru catalysts

Aiying Song^1,2, Gongxuan Lu¹

1 State Key Laboratory for Oxo Synthesis and Selective Oxidation, Lanzhou Institute of Chemical Physics, Chinese Academy of Science, Lanzhou 730000, China;
2 College of Public Security Technology, Gansu Institute of Political Science and Law, Lanzhou 730070, China

Received:2014-05-05 Revised:2014-10-22 Online:2015-08-21 Published:2015-07-28
Contact: Gongxuan Lu
Supported by:
Supported by the National Natural Science Foundation of China (21373245, 21173242), the State Key Development Program for Basic Research of China (2013CB632404), the National High Technology Research and Development Program of China (2012AA051501), and the Project Support of Gansu Provincial Science & Technology Department (1304FKCA085).

Selective oxidation of methylamine over zirconia supported Pt-Ru, Pt and Ru catalysts

Aiying Song^1,2, Gongxuan Lu¹

1 State Key Laboratory for Oxo Synthesis and Selective Oxidation, Lanzhou Institute of Chemical Physics, Chinese Academy of Science, Lanzhou 730000, China;
2 College of Public Security Technology, Gansu Institute of Political Science and Law, Lanzhou 730070, China

通讯作者: Gongxuan Lu
基金资助:
Supported by the National Natural Science Foundation of China (21373245, 21173242), the State Key Development Program for Basic Research of China (2013CB632404), the National High Technology Research and Development Program of China (2012AA051501), and the Project Support of Gansu Provincial Science & Technology Department (1304FKCA085).

Abstract

Abstract: Pt-Ru, Pt and Ru catalysts supported on zirconia were prepared by impregnation method and were tested in selective oxidation of methylamine (MA) in aqueous media. Among three catalysts, Ru/ZrO₂ wasmore active than Pt/ZrO₂ while Pt-Ru/ZrO₂ demonstrated the best catalytic activity due to the fact that Pt addition efficiently promoted the dispersion of active species in bimetallic catalyst. Therefore, the ~100% TOC conversion and N₂ selectivity were achieved over Pt-Ru/ZrO₂, Pt/ZrO₂ and Ru/ZrO₂ catalysts at 190, 220 and 250 ℃, respectively.

Key words: Platinum-Ruthenium, Dispersion, Hysteresis, Zirconia, Methylamine, Catalytic wet air oxidation

摘要： Pt-Ru, Pt and Ru catalysts supported on zirconia were prepared by impregnation method and were tested in selective oxidation of methylamine (MA) in aqueous media. Among three catalysts, Ru/ZrO₂ wasmore active than Pt/ZrO₂ while Pt-Ru/ZrO₂ demonstrated the best catalytic activity due to the fact that Pt addition efficiently promoted the dispersion of active species in bimetallic catalyst. Therefore, the ~100% TOC conversion and N₂ selectivity were achieved over Pt-Ru/ZrO₂, Pt/ZrO₂ and Ru/ZrO₂ catalysts at 190, 220 and 250 ℃, respectively.

关键词: Platinum-Ruthenium, Dispersion, Hysteresis, Zirconia, Methylamine, Catalytic wet air oxidation

Aiying Song, Gongxuan Lu. Selective oxidation of methylamine over zirconia supported Pt-Ru, Pt and Ru catalysts[J]. Chin.J.Chem.Eng., 2015, 23(7): 1206-1213.

Aiying Song, Gongxuan Lu. Selective oxidation of methylamine over zirconia supported Pt-Ru, Pt and Ru catalysts[J]. Chinese Journal of Chemical Engineering, 2015, 23(7): 1206-1213.

References

[1] Y.Z. Xie, The photocatalytic degradation of p-fluorobenzoic acid in sewage over Pt/TiO₂, J. Mol. Catal. 26 (2012) 449-455. (in Chinese)

[2] L. Li, The preparation of nanocomposite ZnO-TiO₂ by CTAB-assisted and photocatalytic degradation rhodamine B with multiple modes, J. Mol. Catal. 27 (2013) 474-482. (in Chinese)

[3] X.M. Zhang, R.C. Wei, H.L. Chen, Treatment of glyphosate wastewater containing high concentration formaldehyde by the catalytic wet air oxidation, J. Mol. Catal. 27 (2013) 323-332. (in Chinese)

[4] F. Luck, Wet air oxidation: Past, present and future, Catal. Today 53 (1999) 81-91.

[5] S.H. Lin, S.J. Ho, Catalytic wet-air oxidation of high strength industrial wastewater, Appl. Catal. B Environ. 9 (1996) 133-147.

[6] J. Levec, A. Pintar, Catalytic wet-air oxidation processes: A review, Catal. Today 124 (2007) 172-184.

[7] A. Pintar, G. Bercic,M. Besson, P. Gallezot, Catalytic wet-air oxidation of industrial effluents: Totalmineralization of organics and lumped kineticmodelling, Appl. Catal. B Environ. 47 (2004) 143-152.

[8] A.Y. Song, G.X. Lu, Support effect on the catalytic activity of Pt catalysts in catalytic wet air oxidation of methylamine, J. Mol. Catal. 28 (2014) 242-250. (in Chinese)

[9] H.S. Joglekar, S.D. Samant, J.B. Joshi, Kinetics of wet air oxidation of phenol and substituted phenols, Water Res. 25 (1991) 135-145.

[10] J. Mikulová, S. Rossignol, J. Barbier Jr., D.Mesnard, D. Duprez, C. Kappenstein,Wet air oxidation of acetic acid over platinum catalysts supported on cerium based materials: influence of metal and oxide particle sizes, J. Catal. 251 (2007) 172-181.

[11] L. Oliviero, J. Barbier Jr., S. Labruquère, D. Duprez, Role of themetal-support interface in the total oxidation of carboxylic acids over Ru/CeO₂ catalysts, Catal. Lett. 60 (1999) 15-19.

[12] A. Cybulski, J. Trawczynski, Catalytic wet air oxidation of phenol over platinum and ruthenium catalysts, Appl. Catal. B Environ. 47 (2004) 1-13.

[13] B. Renard, J. Barbier Jr., D. Duprez, S. Durécu, Catalytic wet air oxidation of stearic acid on cerium oxide supported noble metal catalysts, Appl. Catal. B Environ. 55 (2005) 1-10.

[14] A. Trovarelli, Catalysis by ceria and related materials, Catal. Rev. Sci. Eng. 38 (1996) 439-520.

[15] J. Garcia, H.T. Gomes, P. Serp, P.J. Kalck, L. Figueiredo, J.L. Faria, Platinum catalysts supported on MWNT for catalytic wet air oxidation of nitrogen containing compounds, Catal. Today 102-103 (2005) 101-109.

[16] J. Levec, A. Pintar, Catalytic wet-air oxidation processes: A review, Catal. Today 124 (2007) 172-184.

[17] K.H. Kim, S.K. Ihm, Heterogeneous catalytic wet air oxidation of refractory organic pollutants in industrial wastewaters: a review, J. Hazard. Mater. 186 (2011) 16-34.

[18] Y. Gao, Y.Masuda, H. Ohta, K. Koumoto, Room-temperature preparation of ZrO₂ precursor thin film in an aqueous peroxozirconium-complex solution, Chem. Mater. 16 (2004) 2615-2622.

[19] M. Besson, P. Gallezot, Selective oxidation of alcohols and aldehydes on metal catalysts, Catal. Today 57 (2000) 127-141.

[20] G. Sun, A. Xu, Y. He, M. Yang, H. Du, C. Sun, Ruthenium catalysts supported on highsurface-area zirconia for the catalytic wet oxidation of N,N-dimethyl formamide, J. Hazard. Mater. 156 (2008) 335-341.

[21] M. Ábalos, J.M. Bayona, F. Ventura, Development of a solid-phase microextraction GC-NPD procedure for the determination of free volatile amines in wastewater and sewage-polluted waters, Anal. Chem. 71 (1999) 3531-3537.

[22] F. Sacher, S. Lenz, H.J. Brauch, Analysis of primary and secondary aliphatic amines in wastewater and surface water by gas chromatography-mass spectrometry after derivatization with 2,4-dinitrofluorobenzene or benzenesulfonyl chloride, J. Chromatogr. A 764 (1997) 85-93.

[23] L.V. Mattos, F.B. Noronha, Partial oxidation of ethanol on supported Pt catalysts, J. Power Sources 145 (2005) 10-15.

[24] L.Ma, D. He, Hydrogenolysis of glycerol to propanediols over highly active Ru-Re bimetallic catalysts, Top. Catal. 52 (2009) 834-844.

[25] A.S. Aricò, V. Baglio, A. DiBlasi, E.Modica, P.L. Antonucci, V. Antonucci, Analysis of the high-temperature methanol oxidation behaviour at carbon-supported Pt-Ru catalysts, J. Electroanal. Chem. 557 (2003) 167-176.

[26] A.Y. Song, G.X. Lu, Enhancement of Pt-Ru catalytic activity for catalytic wet air oxidation ofmethylamine via tuning the Ru surface chemical state and dispersion by Pt addition, RSC Adv. 4 (2014) 15325-15331.

Selective oxidation of methylamine over zirconia supported Pt-Ru, Pt and Ru catalysts

Selective oxidation of methylamine over zirconia supported Pt-Ru, Pt and Ru catalysts

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Chaojie Li, Xianxin Fang, Meiling Sun, Jihai Duan, Weiwen Wang. Study on two-phase cloud dispersion from liquefied CO₂ release [J]. Chinese Journal of Chemical Engineering, 2023, 60(8): 37-45.
[2]	Wenshi Huang, Yang Zhang, Yuxin Wu, Jingyu Wang, Minmin Zhou. Analysis of particle dispersion in a turbulent flow considering particle rotation [J]. Chinese Journal of Chemical Engineering, 2023, 58(6): 29-39.
[3]	Bingxiao Feng, Lining Hao, Chaoting Deng, Jiaqiang Wang, Hongbing Song, Meng Xiao, Tingting Huang, Quanhong Zhu, Hengjun Gai. A highly hydrothermal stable copper-based catalyst for catalytic wet air oxidation of m-cresol in coal chemical wastewater [J]. Chinese Journal of Chemical Engineering, 2023, 57(5): 338-348.
[4]	Yuxi Chai, Yanan Zhang, Yannan Tan, Zhiwei Li, Huangzhao Wei, Chenglin Sun, Haibo Jin, Zhao Mu, Lei Ma. Life cycle assessment of high concentration organic wastewater treatment by catalytic wet air oxidation [J]. Chinese Journal of Chemical Engineering, 2023, 56(4): 80-88.
[5]	Vladimir S. Derevschikov, Janna V. Veselovskaya, Anton S. Shalygin, Dmitry A. Yatsenko, Andrey Z. Sheshkovas, Oleg N. Martyanov. Operating limits and features of direct air capture on K₂CO₃/ZrO₂ composite sorbent [J]. Chinese Journal of Chemical Engineering, 2022, 46(6): 11-20.
[6]	Xiangjun Li, Shujun Li, Xiaoping Wang, Muhammad Asif Nawaz, Dianhua Liu. Polyoxymethylene dimethyl ethers synthesis from methanol and formaldehyde solution over one-pot synthesized spherical mesoporous sulfated zirconia [J]. Chinese Journal of Chemical Engineering, 2022, 46(6): 161-172.
[7]	Narjes Hemati Alam, Eslam Kashi, Razieh Habibpour. Computational fluid dynamics simulation of gas dispersion in complex facilities using Kit Fox field experiments: Validation and statistical evaluation [J]. Chinese Journal of Chemical Engineering, 2022, 44(4): 412-423.
[8]	Ying Xu, Pengru Chen, Wei Lv, Chenguang Wang, Longlong Ma, Qi Zhang. Hydrogenolysis of organosolv hydrolyzed lignin over high-dispersion Ni/Al-SBA-15 catalysts for phenolic monomers [J]. Chinese Journal of Chemical Engineering, 2021, 32(4): 307-314.
[9]	Jiyuan Li, Mifen Cui, Zhuxiu Zhang, Xian Chen, Qing Liu, Zhaoyang Fei, Jihai Tang, Xu Qiao. Promoting di-isobutene selectivity over ZnO/ZrO₂-SO₄ in isobutene oligomerization [J]. Chinese Journal of Chemical Engineering, 2021, 38(10): 165-171.
[10]	Rongzong Li, Zhaoyang Li, Qian Jiang, Zhaoxiang Zhong, Ming Zhou, Weihong Xing. Acid precipitation coupled membrane-dispersion advanced oxidation process (MAOP) to treat crystallization mother liquor of pulp wastewater [J]. Chinese Journal of Chemical Engineering, 2020, 28(7): 1911-1917.
[11]	Xiong Yu, Han Zhou, Qiang Zheng, Shan Jing, Wenjie Lan, Shaowei Li. Determining axial dispersion coefficients of pilot-scale annular pulsed disc and doughnut columns [J]. Chinese Journal of Chemical Engineering, 2020, 28(6): 1504-1513.
[12]	Jun Zhang, Hongzhou He, Shaohui Yang. Plume dynamics and dispersion characteristics in oil horizontal release from damaged submarine pipeline [J]. Chinese Journal of Chemical Engineering, 2020, 28(5): 1214-1224.
[13]	M. M. Haddadi, S. H. Hosseini, D. Rashtchian, G. Ahmadi. CFD modeling of immiscible liquids turbulent dispersion in Kenics static mixers: Focusing on droplet behavior [J]. Chinese Journal of Chemical Engineering, 2020, 28(2): 348-361.
[14]	Qiao Tang, Jiyizhe Zhang, Yuxin Wu, Yundong Wang, Zuohua Liu. An experimental study of immiscible liquid-liquid dispersions in a pump-mixer of mixer-settler [J]. Chinese Journal of Chemical Engineering, 2020, 28(1): 33-45.
[15]	Zengqiang Chen, Lian Ye, Bo Dai, Fang Wang. Feasibility analysis of a single-sensor-based approach for source identification of hazardous chemical releases [J]. Chinese Journal of Chemical Engineering, 2019, 27(7): 1642-1650.