Experimental and numerical investigations of scale-up effects on the hydrodynamics of slurry bubble columns

doi:10.1016/j.cjche.2016.05.009

Abstract

Abstract: Experiments and simulations were conducted for bubble columns with diameter of 0.2 m (180 mm i.d.), 0.5 m (476 mm i.d.) and 0.8 m (760 mm i.d.) at high superficial gas velocities (0.12-0.62 m·s^-1) and high solid concentrations (0-30 vol%). Radial profiles of time-averaged gas holdup, axial liquid velocity, and turbulent kinetic energy were measured by using in-house developed conductivity probes and Pavlov tubes. Effects of column diameter, superficial gas velocity, and solid concentration were investigated in a wide range of operating conditions. Experimental results indicated that the average gas holdup remarkably increases with superficial gas velocity, and the radial profiles of investigated flow properties become steeper at high superficial gas velocities. The axial liquid velocities significantly increase with the growth of the column size, whereas the gas holdup was slightly affected. The presence of solid in bubble columns would inhibit the breakage of bubbles, which results in an increase in bubble rise velocity and a decrease in gas holdup, but time-averaged axial liquid velocities remain almost the same as that of the hollow column. Furthermore, a 2-D axisymmetric k-ε model was used to simulate heterogeneous bubbly flow using commercial code FLUENT 6.2. The lateral lift force and the turbulent diffusion force were introduced for the determination of gas holdup profiles and the effects of solid concentration were considered as the variation of average bubble diameter in the model. Results predicted by the CFD simulation showed good agreement with experimental data.

Key words: Bubble column, CFD, Hydrodynamics, Multiphase flow, Scaling-up, Solid concentration

摘要： Experiments and simulations were conducted for bubble columns with diameter of 0.2 m (180 mm i.d.), 0.5 m (476 mm i.d.) and 0.8 m (760 mm i.d.) at high superficial gas velocities (0.12-0.62 m·s^-1) and high solid concentrations (0-30 vol%). Radial profiles of time-averaged gas holdup, axial liquid velocity, and turbulent kinetic energy were measured by using in-house developed conductivity probes and Pavlov tubes. Effects of column diameter, superficial gas velocity, and solid concentration were investigated in a wide range of operating conditions. Experimental results indicated that the average gas holdup remarkably increases with superficial gas velocity, and the radial profiles of investigated flow properties become steeper at high superficial gas velocities. The axial liquid velocities significantly increase with the growth of the column size, whereas the gas holdup was slightly affected. The presence of solid in bubble columns would inhibit the breakage of bubbles, which results in an increase in bubble rise velocity and a decrease in gas holdup, but time-averaged axial liquid velocities remain almost the same as that of the hollow column. Furthermore, a 2-D axisymmetric k-ε model was used to simulate heterogeneous bubbly flow using commercial code FLUENT 6.2. The lateral lift force and the turbulent diffusion force were introduced for the determination of gas holdup profiles and the effects of solid concentration were considered as the variation of average bubble diameter in the model. Results predicted by the CFD simulation showed good agreement with experimental data.

关键词: Bubble column, CFD, Hydrodynamics, Multiphase flow, Scaling-up, Solid concentration

Zhaoqi Li, Xiaoping Guan, Lijun Wang, Youwei Cheng, Xi Li. Experimental and numerical investigations of scale-up effects on the hydrodynamics of slurry bubble columns[J]. , 2016, 24(8): 963-971.

References

[1] J.H. Hills, Radial non-uniformity of velocity and voidage in a bubble column, Trans. Inst. Chem. Eng. 52(1974) 1-9.
[2] P. Zehner, Momentum, mass and heat transfer in bubble columns, Part 1:Flow model of the bubble column and liquid velocities, Int. Chem. Eng. 26(1986) 29-35.
[3] A. Lubbert, B. Larson, Detailed investigation of the multiphase flow in airlift tower loop reactors, Chem. Eng. Sci. 45(1990) 3047-3053.
[4] H. Luo, H.F. Svendsen, Turbulent circulation in bubble columns from eddy viscosity distributions of single-phase pipe flow, Can. J. Chem. Eng. 69(1991) 1389-1394.
[5] B.P. Yao, C. Zheng, H.E. Gasche, H. Hofmann, Bubble behavior and flow structure of bubble columns, J. Chem. Eng. Process Technol. 29(1991) 65-75.
[6] J.S. Groen, R.G.C. Oldeman, R.F. Mudde, H.E.A. Van, Coherent structures and axial dispersion in bubble column reactors, Chem. Eng. Sci. 51(1996) 2511-2520.
[7] A.A. Kulkarni, J.B. Joshi, V.R. Kumar, B.D. Kulkarni, Simultaneous measurement of hold-up profiles and interfacial area using LDA in bubble columns:predictions by multiresolution analysis and comparison with experiments, Chem. Eng. Sci. 56(2001) 6437-6445.
[8] J.M. Schweitzer, J. Bayle, T. Gauthier, Local gas hold-up measurements in fluidized bed and slurry bubble column, Chem. Eng. Sci. 56(2001) 1103-1110.
[9] S. Degaleesa, M.P. Dudukovic, Y. Pan, Experimental study of gas-induced liquid-flow structures in bubble columns, AIChE J. 47(2001) 1913-1931.
[10] U. Parasu Veera, K.L. Kataria, J.B. Joshi, Effect of superficial gas velocity on gas holdup profiles in foaming liquids in bubble column reactors, Chem. Eng. J. 99(2004) 53-58.
[11] L.A. Briens, N. Ellis, Hydrodynamics of three-phase fluidized bed systems examined by statistical, fractal, chaos and wavelet analysis methods, Chem. Eng. Sci. 60(2005) 6094-6106.
[12] M.R. Rampure, A.A. Kulkarni, V.V. Ranade, Hydrodynamics of bubble column reactors at high gas velocity:Experiments and computational fluid dynamics (CFD) simulations, Ind. Eng. Chem. Res. 46(2007) 8431-8447.
[13] L.J. Wang, Y. Zhang, X. Li, Studies on hydrodynamics of slurry turbulent bubble column (I) gas holdup and its radial distribution, CIESC J. 59(2008) 2996-3002(in Chinese).
[14] A. Tsutsumi, W. Chen, T. Hasegawa, et al., Neural networks for prediction of the dynamic heat-transfer rate in bubble columns, Ind. Eng. Chem. Res. 40(23) (2001) 5358-5361.
[15] A. Tsutsumi, R. Kikuchi, Design and scale-up methodology for multi-phase reactors based on non-linear dynamics, Appl. Energy 67(1) (2000) 195-219.
[16] R. Nottenkamper, A. Steiff, P.M. Weinspach, Experimental investigation of hydrodynamics of bubble columns, Ger. Chem. Eng. 6(1983) 147-155.
[17] A. Forret, J.M. Schweitzer, R. Gauthier, et al., Scale up of slurry bubble reactors, Oil Gas Sci. Technol. 61(2006) 443-458.
[18] A. Forret, J.M. Schweitzer, R. Gauthier, et al., Influence of scale on the hydrodynamics of bubble column reactors:an experimental study in columns of 0.1, 0.4 and 1 m diameters, Chem. Eng. Sci. 58(2003) 719-724.
[19] J.B. Joshi, Computational flow modeling and design of bubble column reactors, Chem. Eng. Sci. 56(2001) 5893-5933.
[20] J.B. Joshi, V.S. Vitankar, A.A. Kulkarni, et al., Coherent flow structures in bubble column reactors, Chem. Eng. Sci. 57(2002) 3047-3053.
[21] M.T. Dhotre, K. Ekambara, J.B. Joshi, CFD simulation of sparger design and height to diameter ratio on gas hold-up profiles in bubble column reactors, Exp. Thermal Fluid Sci. 28(2004) 407-421.
[22] K. Ekambara, M.T. Dhotre, J.B. Joshi, CFD simulations of bubble column reactors:1D, 2D and 3D approach, Chem. Eng. Sci. 60(2005) 6733-6746.
[23] A.A. Kulkarni, K. Ekambara, J.B. Joshi, On the development of flow pattern in a bubble column reactor:development of a 3D CFD code and verification with results from LDA measurements, Chem. Eng. Sci. 62(2007) 1049-1072.
[24] M.V. Tabib, S.A. Roy, J.B. Joshi, CFD simulation of bubble column-an analysis of interphase forces and turbulence models, Chem. Eng. J. 139(2008) 589-614.
[25] R. Krishna, J.M. Van, M.I. Urseanu, Three-phase Eulerian simulations of bubble column reactors operating in the churn-turbulent regime:A scale-up strategy, Chem. Eng. Sci. 55(2000) 3275-3286.
[26] R. Krishna, J.M. Van, Eulerian simulations of bubble columns operating at elevated pressures in the churn turbulent flow regime, Chem. Eng. Sci. 56(2001) 6249-6258.
[27] R. Krishna, J.M. Van, Scaling up bubble column reactors with highly viscous liquid phase, Chem. Eng. Technol. 25(2002) 1015-1020.
[28] J.M. Van, R. Krishna, Eulerian simulations for determination of the axial dispersion of liquid and gas phases in bubble columns operating in the churn-turbulent regime, Chem. Eng. Sci. 56(2001) 503-512.
[29] E. Olmos, C. Gentric, C. Vial, et al., Numerical simulation of multiphase flow in bubble column reactors. Influence of bubble coalescence and breakup, Chem. Eng. Sci. 56(2001) 6359-6365.
[30] P. Chen, M.P. Dudukovic, J. Sanyal, Three-dimensional simulation of bubble column flows with bubble coalescence and breakup, AIChE J. 51(2005) 696-712.
[31] H.A. Jakobsen, H. Lindborg, C.A. Dorao, Modeling of bubble column reactors:progress and limitations, Ind. Eng. Chem. Res. 44(2005) 5107-5151.
[32] M.R. Bhole, J.B. Joshi, D. Ramkrishna, CFD simulation of bubble columns incorporating population balance modeling, Chem. Eng. Sci. 63(2008) 2267-2282.
[33] J. Reimann, H. Kusterer, H. Jhon, Two-phase mass flow rate measurements with Pitot tube and density measurements, Symp. Measuring Techniques in Gas-Liquid Two-phase Flows, Nancy, France, 1983.
[34] T.H. Lee, G.C. Park, D.J. Lee, Local flow characteristics of subcooled boiling flow of water in a vertical concentric annulus, Int. J. Multiphase Flow 28(8) (2002) 1351-1368.
[35] Z. Li, L. Wang, X. Li, Experimental and numerical investigations of bubble column under large diameter, high superficial gas velocity, 244th National Fall Meeting of the ACS, Philadelphia, USA, 2012.
[36] Y. Zhang, L. Wang, X. Li, Studies on hydrodynamics of turbulent slurry bubble column (Ⅱ):axial liquid and slurry velocity distribution, CIESC J. 59(12) (2008) 3003-3008(in Chinese).
[37] H.A. Jakobsen, Chemical Reactor Modeling:Multiphase Reactive Flows, Springer, Berlin Heidelberg, 2008.
[38] R. Krishna, J.M. Van, M.I. Urseanu, et al., Design and scale up of a bubble column slurry reactor for Fischer-Tropsch synthesis, Chem. Eng. Sci. 56(2) (2001) 537-545.
[39] J.M. Van, J. Ellenberger, R. Krishna, Scale-up strategy for bubble column slurry reactors using CFD simulations, Catal. Today 79(2003) 259-265.
[40] T.F. Wang, J.F. Wang, Y. Jin, Experimental study and CFD simulation of hydrodynamic behaviours in an external loop airlift slurry reactor, Can. J. Chem. Eng. 82(6) (2004) 1183-1190.
[41] J.F. Brady, Computer simulation of viscous suspensions, Chem. Eng. Sci. 56(2001) 2921-2926.
[42] T.F. Wang, J.F. Wang, Y. Jin, Slurry reactors for gas-to-liquid processes:A review, Ind. Eng. Chem. Res. 46(2007) 5824-5847.
[43] C.O. Vandu, K. Koop, R. Krishna, Large bubble sizes and rise velocities in a bubble column slurry reactor, Chem. Eng. Technol. 27(2004) 1195-1199.
[44] G.Q. Yang, B. Du, L.S. Fan, Bubble formation and dynamics in gas-liquid-solid fluidization-a review, Chem. Eng. Sci. 62(2007) 2-27.
[45] L. Schiller, A. Naumann, A drag coefficient correlation, Vdi Ztg. 77(318) (1935) 51.
[46] B.M. Lopez, Turbulent Bubbly Two-phase Flow in a Triangular Duct(Ph.D. Thesis) Rensselaer Polytechnic Institute, New York, 1992.
[47] H.B. Stewart, B. Wendroff, Two-phase flow models and methods, J. Comput. Phys. 56(1984) 363-409.
[48] H.A. Jakobsen, B.H. Sannaes, S. Grevskott, et al., Modelling of vertical bubble-driven flows, Ind. Eng. Chem. Res. 36(1997) 4052-4074.
[49] A. Sokolichin, G. Eigenberger, A. Lapin, Simulation of buoyancy driven bubbly flow:established simplifications and open questions, AIChE J. 50(2004) 24-45.
[50] H.P. Riquarts, Strömungsprofile, impulsaustausch und durchmischung der flüssigen phase in blasensäulen, Chem. Ing. Tech. 53(1981) 60-61.
[51] P. Gupta, B. Ong, M.H. Al-Dahhan, et al., Hydrodynamics of churn turbulent bubble columns:Gas-liquid recirculation and mechanistic modeling, Catal. Today 64(2001) 253-269.