Three-dimensional Computational Fluid Dynamics Modeling of Two-phase Flow in a Structured Packing Column

doi:10.1016/S1004-9541(13)60576-5

Chinese Journal of Chemical Engineering ›› 2013, Vol. 21 ›› Issue (9): 959-966.DOI: 10.1016/S1004-9541(13)60576-5

Three-dimensional Computational Fluid Dynamics Modeling of Two-phase Flow in a Structured Packing Column

张小斌, 姚蕾, 邱利民, 张学军

Institute of Refrigeration and Cryogenics, Zhejiang University, Hanghzou 310027, China

收稿日期:2012-06-18 修回日期:2013-06-06 出版日期:2013-09-28 发布日期:2013-10-01
通讯作者: ZHANG Xuejun
基金资助:
Supported by the Major State Basic Research Development Program of China (2011CB706501) and the National Natural Science Foundation of China (51276157)

Three-dimensional Computational Fluid Dynamics Modeling of Two-phase Flow in a Structured Packing Column

ZHANG Xiaobin, YAO Lei, QIU Limin, ZHANG Xuejun

Institute of Refrigeration and Cryogenics, Zhejiang University, Hanghzou 310027, China

Received:2012-06-18 Revised:2013-06-06 Online:2013-09-28 Published:2013-10-01
Contact: ZHANG Xuejun
Supported by:
Supported by the Major State Basic Research Development Program of China (2011CB706501) and the National Natural Science Foundation of China (51276157)

摘要/Abstract

摘要： Characterizing the complex two-phase hydrodynamics in structured packed columns requires a powerful modeling tool. The traditional two-dimensional model exhibits limitations when one attempts to model the detailed two-phase flow inside the columns. The present paper presents a three-dimensional computational fluid dynamics (CFD) model to simulate the two-phase flow in a representative unit of the column. The unit consists of an entire corrugation channel and describes well the real liquid flow conditions. The detailed unsteady two-phase 3D CFD calculations on column packed with Flexipak 1Y were implemented within the volume of fluid (VOF) mathematical framework. The CFD model was validated by comparing the calculated thickness of liquid film with the available experimental data. Special attention was given to quantitative analysis of the effects of gravity on the hydrodynamics. Fluctuations in the liquid mass flow rate and the calculated pressure drop loss were found to be qualitatively in agreement with the experimental observations.

关键词: structured packing column, two-phase flow, computational fluid dynamics, three-dimension

Abstract: Characterizing the complex two-phase hydrodynamics in structured packed columns requires a powerful modeling tool. The traditional two-dimensional model exhibits limitations when one attempts to model the detailed two-phase flow inside the columns. The present paper presents a three-dimensional computational fluid dynamics (CFD) model to simulate the two-phase flow in a representative unit of the column. The unit consists of an entire corrugation channel and describes well the real liquid flow conditions. The detailed unsteady two-phase 3D CFD calculations on column packed with Flexipak 1Y were implemented within the volume of fluid (VOF) mathematical framework. The CFD model was validated by comparing the calculated thickness of liquid film with the available experimental data. Special attention was given to quantitative analysis of the effects of gravity on the hydrodynamics. Fluctuations in the liquid mass flow rate and the calculated pressure drop loss were found to be qualitatively in agreement with the experimental observations.

Key words: structured packing column, two-phase flow, computational fluid dynamics, three-dimension

张小斌, 姚蕾, 邱利民, 张学军. Three-dimensional Computational Fluid Dynamics Modeling of Two-phase Flow in a Structured Packing Column[J]. Chinese Journal of Chemical Engineering, 2013, 21(9): 959-966.

ZHANG Xiaobin, YAO Lei, QIU Limin, ZHANG Xuejun. Three-dimensional Computational Fluid Dynamics Modeling of Two-phase Flow in a Structured Packing Column[J]. Chin.J.Chem.Eng., 2013, 21(9): 959-966.

参考文献

1 Spieel, L., Meier, W., “Distillation columns with structured packings in the next decade”, Trans. IChemE, 81, Part A, 39-47 (2003).

2 Petre, C.F., Larachi, F., Iliuta, I., Grandjean, B.P.A., “Pressure drop through structured packings: Breakdown into the contributing mechanisms by CFD modeling”, Chem. Eng. Sci., 58, 163-177 (2003).

3 Zhang, Y.L., Zhu, H.M., Yin, Q.X., “Experimental Study on local mass transfer of structured packing with the method of flow visualization”, Chin. J. Chem. Eng., 19, 870-875 (2011).

4 Gualito, J.J., Cerino, F.J., Cardenas, J.C., Rocha, J.A., “Design method for distillation columns filled with metallic, ceramic or plastic structured packings”, Ind. Eng. Chem. Res., 36, 1747-1757 (1997).

5 Rocha, J.A., Bravo, J.L., James, R.F., “Distillation columns containing structured packings: A comprehensive model for their performance. 1. Hydraulic models”, Ind. Eng. Chem. Res., 32, 641-651 (1993).

6 Rocha, J.A., Bravo, J.L., James, R.F., “Distillation columns containing structured packings: A comprehensive model for their performance. 2. Mass-transfer model”, Ind. Eng. Chem. Res., 35, 1660-1667 (1996).

7 Raynal, L., Lebeaud, A.R., “A multi-scale approach for CFD calculations of gas-liquid flow within large size column equipped with structured packing”, Chem. Eng. Sci., 62, 7196-7204 (2007).

8 Raynal, L., Boyer, C., Ballaguet, J.P., “Liquid holdup and pressure drop determination in structured packing with CFD simulations”, Can. J. Chem. Eng., 82, 871-879 (2004).

9 Baten, J.M.V., Krishna, R., “Liquid-phase mass transfer within KATAPAK-S^@ structures studied using computational fluid dynamics simulations”, Catal. Today, 69, 371-377 (2001).

10 Baten, J.M.V., Krishna, R., “Gas and liquid phase mass transfer within KATAPAK-S^@ structures studied using CFD simulations”, Chem. Eng. Sci., 57, 1531-1536 (2002).

11 Fard, M.H., Zivdar, M., Rahimi, R., Esfahany, M.N., Afacan, A., Nandakumar, K., Chuang, K.T., “CFD simulation of mass transfer efficiency and pressure drop in a structured packed distillation column”, Chem. Eng. Technol., 30 (7), 854-861 (2007).

12 Beata, S., Ireneusz, Z., Andrzej, G., “Liquid flow on structured packing: CFD simulation and experimental study”, Chem. Eng. Technol., 26 (5), 580-584 (2003).

13 Chen, J.B., Liu, C.J., Yuan, X.G., Yu, G.Z., “CFD simulation of flow and mass transfer in structured packing distillation columns”, Chin. J. Chem. Eng., 17 (3), 381-388 (2009).

14 Raynal, L., Harter, I., “Studies of gas-liquid flow through reactors internals using VOF simulations”, Chem. Eng. Sci., 56, 6385-6391 (2001).

15 Bontozoglou,V., Papapolymerou, G., “Laminar film flow down a wavy incline”, Int. J. Multiphase flow., 23 (1), 69-79 (1997).

16 Fluent, Help Document, Ansys Cooperation (2006).

17 Pantzali, M.N., Mouza, A.A., Paras, S.V., “Counter-current gas-liquid flow and incipient flooding in inclined small diameter tubes”, Chem. Eng. Sci., 63, 3966-3978 (2008).

18 Zabaras, G.J., Dukler, A.E., “Countercurrent gas-liquid annular flow, including the flooding state”, AIChE J., 34, 389-396 (1988).

19 Van, P.C., Liquid-vapor Phase-change Phenomena, Hemisphere Publishing Corporation, USA, 105-110 (1992).

20 Zapke, A., KroÈger, D.G., “Countercurrent gas-liquid flow in inclined and vertical ducts (I) Flow patterns, pressure drop characteristics and flooding”, Int. J. Multiphase flow, 26, 1439-1455 (2000).

[1]	Xuejing He, Zhenlin Li, Ji Wang, Hai Yu. Effects of tube cross-sectional shapes on flow pattern, liquid film and heat transfer of n-pentane across tube bundles[J]. 中国化学工程学报, 2023, 60(8): 16-25.
[2]	Lijuan Zhao, Zhe Tan, Xiaoguang Zhang, Qijun Zhang, Wei Wang, Qiang Deng, Jie Ma, De'an Pan. Research on process modeling and simulation of spent lead paste desulfurization enhanced reactor[J]. 中国化学工程学报, 2023, 60(8): 293-303.
[3]	Chengang Yang, Huaizhi Han, Quan Zhu, Xiangyuan Li. Cracking and buoyancy effect on hydrocarbon endothermic and heat transfer characteristics in rectangular mini-channel[J]. 中国化学工程学报, 2023, 56(4): 242-254.
[4]	Shuangfei Zhao, Yingying Nie, Wenyan Zhang, Runze Hu, Lianzhu Sheng, Wei He, Ning Zhu, Yuguang Li, Dong Ji, Kai Guo. Microfluidic field strategy for enhancement and scale up of liquid–liquid homogeneous chemical processes by optimization of 3D spiral baffle structure[J]. 中国化学工程学报, 2023, 56(4): 255-265.
[5]	Ming Chen, Huiyan Jiao, Jun Li, Zhibin Wang, Feng He, Yang Jin. Liquid–liquid two-phase flow in a wire-embedded concentric microchannel: Flow pattern and mass transfer performance[J]. 中国化学工程学报, 2023, 56(4): 281-289.
[6]	Qi Han, Xin-Yuan Zhang, Hai-Bo Wu, Xian-Tai Zhou, Hong-Bing Ji. Different efficiency toward the biomimetic aerobic oxidation of benzyl alcohol in microchannel and bubble column reactors: Hydrodynamic characteristics and gas–liquid mass transfer[J]. 中国化学工程学报, 2023, 55(3): 84-92.
[7]	Songsong Wang, Hong Li, Changyuan Tao, Renlong Liu, Yundong Wang, Zuohua Liu. Study on cavern evolution and performance of three mixers in agitation of yield-pseudoplastic fluids[J]. 中国化学工程学报, 2023, 55(3): 111-122.
[8]	Chunxin Fan, Zini Guo, Jianhong Luo. Study on an improved rotating microchannel separator in the intensification for demulsification and separation process[J]. 中国化学工程学报, 2023, 55(3): 181-191.
[9]	Yongbo Zhou, Yang Jin, Jun Li, Qinyan Wang, Ming Chen. Numerical study on the hydrodynamics behavior of a central insert microchannel[J]. 中国化学工程学报, 2023, 53(1): 361-373.
[10]	Tianpeng LiZhou, Jiajia Luo, Tiefeng Wang. Enhancement of acetylene and ethylene yields in partially decoupled oxidation of ethane by changing the composition of heat carrier[J]. 中国化学工程学报, 2022, 47(7): 71-78.
[11]	Zewen Chen, Yongjun Wu, Jian Wang, Peicheng Luo. Study on the solid–liquid suspension behavior in a tank stirred by the long-short blades impeller[J]. 中国化学工程学报, 2022, 47(7): 79-88.
[12]	Liying Chen, Junheng Guo, Wenpeng Li, Shuchun Zhao, Wei Li, Jinli Zhang. A numerical study of mixing intensification for highly viscous fluids in multistage rotor–stator mixers[J]. 中国化学工程学报, 2022, 47(7): 218-230.
[13]	Youfang Ma, Youfu Ma, Junfu Lyu, Weiye Liu. Experimental study on prediction model of wet gas pressure drop across single-orifice plate in horizontal pipes in the low gas phase Froude number region[J]. 中国化学工程学报, 2022, 46(6): 63-72.
[14]	Zijun Li, Shubo Wang, Sai Yao, Xueke Wang, Weiwei Li, Tong Zhu, Xiaofeng Xie. Experimental and numerical study on improvement performance by wave parallel flow field in a proton exchange membrane fuel cell[J]. 中国化学工程学报, 2022, 45(5): 90-102.
[15]	Yongjun Wu, Pan You, Peicheng Luo. Effect of pitched short blades on the flow characteristics in a stirred tank with long-short blades impeller[J]. 中国化学工程学报, 2022, 45(5): 143-152.

Three-dimensional Computational Fluid Dynamics Modeling of Two-phase Flow in a Structured Packing Column

Three-dimensional Computational Fluid Dynamics Modeling of Two-phase Flow in a Structured Packing Column

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价