Combination of Supercritical Fluid Extraction with Ultrasonic Extraction for Obtaining Sex Hormones and IGF-1 from Antler Velvet

Chinese Journal of Chemical Engineering ›› 2009, Vol. 17 ›› Issue (3): 373-380.

• 催化、动力学与反应工程 • 上一篇下一篇

Combination of Supercritical Fluid Extraction with Ultrasonic Extraction for Obtaining Sex Hormones and IGF-1 from Antler Velvet

周冉, 李淑芬, 张大成

Key Laboratory for Green Chemical Technologies of the Ministry of Education, School of Chemical Engineering and Technology, Tianjin University, Tianjin 300072, China

收稿日期:2008-09-11 修回日期:2009-02-17 出版日期:2009-06-28 发布日期:2009-06-28
通讯作者: LI Shufen,E-mail:shfli@tju.edu.cn
基金资助:
Supported by the Natural Science Foundation of Tianjin (06YFJMJC10500)

Combination of Supercritical Fluid Extraction with Ultrasonic Extraction for Obtaining Sex Hormones and IGF-1 from Antler Velvet

ZHOU Ran, LI Shufen, ZHANG Dacheng

Key Laboratory for Green Chemical Technologies of the Ministry of Education, School of Chemical Engineering and Technology, Tianjin University, Tianjin 300072, China

Received:2008-09-11 Revised:2009-02-17 Online:2009-06-28 Published:2009-06-28
Supported by:
Supported by the Natural Science Foundation of Tianjin (06YFJMJC10500)

摘要/Abstract

摘要： Supercritical CO₂ (SC-CO₂) extraction technology and ultrasonic technology were used to extract two active sex hormones, estradiol and progesterone, and insulin-like growth factor-1 (IGF-1) from antler velvet. The effects of SC-CO₂ extraction condition on the extraction yield and content of sex hormones, the ultrasonic extraction condition on the content of IGF-1 and the SC-CO₂ extraction condition on the activity remaining of IGF-1 were studied. The optimal conditions were obtained. The experimental results showed that, in presence of 75% ethanol as the co-solvent, the mean yield and content of estradiol and progesterone were 87.67 pg·g^-1 and 1224.10 pg·g^-1, 12.38 ng·g^-1 and 354.06 ng·g^-1, respectively, with extraction pressure of 30 MPa, temperature of 35℃, extraction time of 30 min and CO₂ consumption of 15 L·g^-1 at the flow rate of 2.0 L·min^-1. The highest content of IGF-1 was 7425.75 ng·g^-1 antler velvet residue, when the pH10 ammonia-ammonium chloride buffer solution was used as the solvent, the ratio of solvent to sample was 20/1 (volume/mass), the extraction temperature was 0-35℃, and the extraction time was 4×15 min. Under these conditions, 93.68% activity remaining of IGF-1 in the residue was obtained, while little IGF-1 activity exists in traditional residue. The experimental results indicate that the technology of SC-CO₂ with co-solvent is of advantage for getting high content sexual hormones and keeping high activity of IGF-1 in the residue, which can not be achieved by traditional extraction methods.

关键词: antler velvet, supercritical extraction, estradiol, progesterone, insulin-like growth factor-1

Abstract: Supercritical CO₂ (SC-CO₂) extraction technology and ultrasonic technology were used to extract two active sex hormones, estradiol and progesterone, and insulin-like growth factor-1 (IGF-1) from antler velvet. The effects of SC-CO₂ extraction condition on the extraction yield and content of sex hormones, the ultrasonic extraction condition on the content of IGF-1 and the SC-CO₂ extraction condition on the activity remaining of IGF-1 were studied. The optimal conditions were obtained. The experimental results showed that, in presence of 75% ethanol as the co-solvent, the mean yield and content of estradiol and progesterone were 87.67 pg·g^-1 and 1224.10 pg·g^-1, 12.38 ng·g^-1 and 354.06 ng·g^-1, respectively, with extraction pressure of 30 MPa, temperature of 35℃, extraction time of 30 min and CO₂ consumption of 15 L·g^-1 at the flow rate of 2.0 L·min^-1. The highest content of IGF-1 was 7425.75 ng·g^-1 antler velvet residue, when the pH10 ammonia-ammonium chloride buffer solution was used as the solvent, the ratio of solvent to sample was 20/1 (volume/mass), the extraction temperature was 0-35℃, and the extraction time was 4×15 min. Under these conditions, 93.68% activity remaining of IGF-1 in the residue was obtained, while little IGF-1 activity exists in traditional residue. The experimental results indicate that the technology of SC-CO₂ with co-solvent is of advantage for getting high content sexual hormones and keeping high activity of IGF-1 in the residue, which can not be achieved by traditional extraction methods.

Key words: antler velvet, supercritical extraction, estradiol, progesterone, insulin-like growth factor-1

周冉, 李淑芬, 张大成. Combination of Supercritical Fluid Extraction with Ultrasonic Extraction for Obtaining Sex Hormones and IGF-1 from Antler Velvet[J]. Chinese Journal of Chemical Engineering, 2009, 17(3): 373-380.

ZHOU Ran, LI Shufen, ZHANG Dacheng. Combination of Supercritical Fluid Extraction with Ultrasonic Extraction for Obtaining Sex Hormones and IGF-1 from Antler Velvet[J]. Chin.J.Chem.Eng., 2009, 17(3): 373-380.

参考文献

1 Kim, K.H., Kim, K.S., Choi, B.J., Chung, K.H., Chang, Y.C., Lee, S.D., Park, K.K., Kim, H.M., Kim, C.H., “Anti-bone resorption activity of deer antler aqua-acupunture, the pilose antler of Cervus korean TEMMINCK var. mantchuricus Swinhoe(Nokyong) in adjuvant-induced arthritic rats”, J. Ethnopharmacol., 96, 497-506(2005).
2 Li, C.W., Jiang, Z.G., Jiang, G.H., Fang, J.M., “Seasonal changes of reproductive behavior and fecal steroid concentrations in Père David’s deer”, Hormones and Behavior, 40, 518-525(2001).
3 Sunwoo, H.H., Nakano, T., Hudson, R.J., Sim, J.S., “Isolation, characterization and localization of glycosaminoglycans in growing antlers of wapiti(Cervus elaphus)”, Comparative Biochemistry and Physiology Part B:Biochemistry and Molecular Biology, 120, 273-283(1998).
4 Sunwoo, H.H., Nakano, T., Sim, J.S., “Isolation and characterization of proteoglycans from growing antlers of wapiti(Cervus elaphus)”, Comparative Biochemistry and Physiology Part B:Biochemistry and Molecular Biology, 121, 437-442(1998).
5 Ditchkoff, S.S., Spicer, L.J., Masters, R.E., Lochmiller, R.L., “Concentrations of insulin-like growth factor-I in adult male white-tailed deer(Odocoileus virginianus):Associations with serum testosterone, morphometrics and age during and after the breeding season”, Comparative Biochemistry and Physiology Part A:Molecular and Integrative Physiology, 129, 887-895(2001).
6 Barling, P.M., Lai, A.K.W., Nicholson, L.F.B., “Distribution of EGF and its receptor in growing red deer antler”, Cell Biology International, 29, 229-236(2005).
7 Bhavnani, B.R., “Pharmacology of hormonal therapeutic agents”, The Menopause Comprehensive Management, The Parthenon Publishing Group, New York, 229-256(2000).
8 Froesch, E.R., Schmid, C., Schmander, J., Zapf, J., “Actions of insulin-like growth factors”, Ann. Rev. Physiol., 47, 443-467(1985).
9 Rechler, M.M., Nissley, S.P., “The nature and regulation of the receptors of insulin-like growth factors”, Ann. Rev. Physiol., 47, 425-442(1985).
10 Jones, J.I., Clemmons, D.R., “Insulin-like growth factors and their binding proteins:Biological actions”, Endocrinol. Rev., 16, 3-34(1995).
11 Lowe, W.L.Jr., “Biological actions of the insulin-like growth factors”, Insulin-Like Growth Factors:Molecular and Cellular Aspects, CRC Press, Boca Raton FL, 49-85(1991).
12 Daughaday, W.H., Rotwein, P., “Insulin-like growth factors I and II. Peptide, messenger ribonucleic acid and gene structures, serum and tissue concentrations”, Endocrine Reviews, 10, 68-91(1989).
13 Ling, Y., Luo, F.C., Li, Q.X., “Assay of estradiol and testosterone in pilose antler”, Chinese Traditional and Herbal Drugs, 30, 499-501(1999).(in Chinese)
14 Yang, R.M., Zhang, J.H., Cao, H., Zhang, L.Y., Bao, T.N., Zhao, S., Ding, X.H., “Determination of sex hormones in milu antler by HPLC analysis”, Chinese J. Anal. Chem., 29, 618(2001).(in Chinese)
15 Li, C.W., Jiang, Z.G., Zeng, Y., Yan, C.E., Zhang, L.Y., Xia, J.S., Tang, B.T., “Velvet tissue estradiol concentrations in Père david’s deer, sika deer and fallow deer”, Acta Zoologica Sinica, 49, 124-127(2003).
16 Moore, L.G., Jones, D., Lymburn, M.A., Hodgkinson, S.C., Davis, S.R., Suttie, J.M., Sagighi, M., Carne, A., “Isolation and sequencing of deer and sheep insulin-like growth factors I and II”, General and Comparative Endocrinology, 92, 302-310(1991).
17 Mason, T.J., Cordemans, E.D., “Ultrasonic intensification of chemical processing and related operations:A review”, Trans. Inst. Chem. Eng., 74, 511-516(1996).
18 Schinor, E.C., Salvador, M.J., Turatti, I.C.C., Zucchi, O.L.A.D., Dias, D.A., “Comparison of classical and ultrasound-assisted extractions of steroids and triterpenoids from three Chresta spp”, Ultrason. Sonochem., 11, 415-421(2004).
19 Li, H., Chen, B., Yao, S.Z., “Application of ultrasonic technique for extracting chlorogenic acid from Eucommia ulmodies Oliv.(E. ulmodies)”, Ultrason. Sonochem. 12, 295-300(2005).
20 Jacques, R.A., dos Santos Freitas, L., Pérez, V.F., Dariva, C., de Oliveira, A.P., de Oliveira, J.V., Caram o, E.B., “The use of ultrasound in the extraction of Ilex paraguariensis leaves:A comparison with maceration”, Ultrason. Sonochem., 14, 6-12(2007).
21 Rodrigues, S., Pinto, G.A.S., Fernandes, F.A.N., “Optimization of ultrasound extraction of phenolic compounds from coconut(Cocos nucifera) shell powder by response surface methodology”, Ultrason. Sonochem., 15, 95-100(2008).
22 Posyniak, A., Zmudzki, J., Semeniuk, S., “Effects of the matrix and sample preparation on the determination of fluoroquinolone residue in animal tissues”, J. Chromatogr. A., 914, 89-94(2001).
23 Hardcastle, J.L., Paterson, C.J., Compton, R.G., “Biphasic sonoelectroanalysis:Simultaneous extraction from, and determination of vanillin in food flavoring”, Electroanalysis, 13, 899-905(2001).

[1]	Liang Wang, Lu Liu, Zhaohui Zhang, Bin Zhao, Junjing Li, Bingjie Dong, Nian Liu. 17α-Ethinylestradiol removal from water by magnetic ion exchange resin[J]. Chinese Journal of Chemical Engineering, 2018, 26(4): 864-869.
[2]	聂强, 王静康, 王永莉, 鲍颖. 溶剂与杂质对11α-羟基-16α,17α-环氧黄体酮晶习的影响[J]. , 2007, 15(5): 648-653.

Combination of Supercritical Fluid Extraction with Ultrasonic Extraction for Obtaining Sex Hormones and IGF-1 from Antler Velvet

Combination of Supercritical Fluid Extraction with Ultrasonic Extraction for Obtaining Sex Hormones and IGF-1 from Antler Velvet

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 2

编辑推荐

Metrics

本文评价