Evolution of cavity size and energy conversion due to droplet impact on a water surface

doi:10.1016/j.cjche.2023.04.001

中国化学工程学报 ›› 2023, Vol. 62 ›› Issue (10): 261-269.DOI: 10.1016/j.cjche.2023.04.001

• Full Length Article • 上一篇下一篇

Evolution of cavity size and energy conversion due to droplet impact on a water surface

Wan Xu¹, Dekui Yuan², Hongguang Sun³, Tong Guo¹, Fengze Zhao¹, Huimin Ma¹, Changgen Liu¹

1. Department of Mechanics, Tianjin University, Tianjin 300350, China;
2. State Key Laboratory of Hydraulic Engineering Simulation and Safety, Tianjin University, Tianjin 300072, China;
3. State Key Laboratory of Hydrology-Water Resources and Hydraulic Engineering, Hohai University, Nanjing 210098, China

收稿日期:2022-12-13 修回日期:2023-04-03 出版日期:2023-10-28 发布日期:2023-12-23
通讯作者: Dekui Yuan,E-mail:dkyuan@tju.edu.cn
基金资助:
This study has been supported by the National Natural Science Foundation of China (11872271) and the Major Scientific and Technological Projects of Tianjin (18ZXRHSF00270).

Evolution of cavity size and energy conversion due to droplet impact on a water surface

Wan Xu¹, Dekui Yuan², Hongguang Sun³, Tong Guo¹, Fengze Zhao¹, Huimin Ma¹, Changgen Liu¹

1. Department of Mechanics, Tianjin University, Tianjin 300350, China;
2. State Key Laboratory of Hydraulic Engineering Simulation and Safety, Tianjin University, Tianjin 300072, China;
3. State Key Laboratory of Hydrology-Water Resources and Hydraulic Engineering, Hohai University, Nanjing 210098, China

Received:2022-12-13 Revised:2023-04-03 Online:2023-10-28 Published:2023-12-23
Contact: Dekui Yuan,E-mail:dkyuan@tju.edu.cn
Supported by:
This study has been supported by the National Natural Science Foundation of China (11872271) and the Major Scientific and Technological Projects of Tianjin (18ZXRHSF00270).

摘要/Abstract

摘要： The deformation characteristics of the cavity due to droplet impact on a water surface are experimentally investigated. Dimensional analysis shows that the characteristic values of time, depth, and horizontal diameter can be taken as 10^-3 times the ratio of surface tension to the product of viscosity coefficient and gravitational acceleration, the maximum depth, and the maximum horizontal diameter, respectively. The evolutions of the dimensionless cavity sizes for different values of Weber number (We) coincide for 220 < We < 686. A partial-sphere model of cavity is established based on experimental observations. Energy models are then derived, and the energy conversions are calculated to identify the relationship between these conversions and cavity deformation. It is found that the kinetic energy model established under the hypothesis proposed by Leng is no longer applicable when the dimensionless time t^* < 3.5, owing to deviations from the geometric model.

关键词: Droplet impact, Cavity size, Energy conversion

Abstract: The deformation characteristics of the cavity due to droplet impact on a water surface are experimentally investigated. Dimensional analysis shows that the characteristic values of time, depth, and horizontal diameter can be taken as 10^-3 times the ratio of surface tension to the product of viscosity coefficient and gravitational acceleration, the maximum depth, and the maximum horizontal diameter, respectively. The evolutions of the dimensionless cavity sizes for different values of Weber number (We) coincide for 220 < We < 686. A partial-sphere model of cavity is established based on experimental observations. Energy models are then derived, and the energy conversions are calculated to identify the relationship between these conversions and cavity deformation. It is found that the kinetic energy model established under the hypothesis proposed by Leng is no longer applicable when the dimensionless time t^* < 3.5, owing to deviations from the geometric model.

Key words: Droplet impact, Cavity size, Energy conversion

Wan Xu, Dekui Yuan, Hongguang Sun, Tong Guo, Fengze Zhao, Huimin Ma, Changgen Liu. Evolution of cavity size and energy conversion due to droplet impact on a water surface[J]. 中国化学工程学报, 2023, 62(10): 261-269.

Wan Xu, Dekui Yuan, Hongguang Sun, Tong Guo, Fengze Zhao, Huimin Ma, Changgen Liu. Evolution of cavity size and energy conversion due to droplet impact on a water surface[J]. Chinese Journal of Chemical Engineering, 2023, 62(10): 261-269.

参考文献

[1] W.C. Macklin, G.J. Metaxas, Splashing of drops on liquid layers, J. Appl. Phys. 47 (9) (1976) 3963–3970.
[2] L.J. Leng, Splash formation by spherical drops, J. Fluid Mech. 427 (2001) 73–105.
[3] Y.S. Guo, Y.S. Lian, M. Sussman, Investigation of drop impact on dry and wet surfaces with consideration of surrounding air, Phys. Fluids 28 (7) (2016) 073303.
[4] G. Liang, I. Mudawar, Review of mass and momentum interactions during drop impact on a liquid film, Int. J. Heat Mass Transf. 101 (2016) 577–599.
[5] S.M. Chen, V. Bertola, Drop impact on spherical soft surfaces, Phys. Fluids 29 (8) (2017) 082106.
[6] J. Breitenbach, I.V. Roisman, C. Tropea, From drop impact physics to spray cooling models: A critical review, Exp. Fluids 59 (3) (2018) 55.
[7] A.M. Worthington, On the forms assumed by drops of liquids falling vertically on a horizontal plate, Proc. R. Soc. Lond. 25 (171–178) (1877) 261–272.
[8] A.M. Worthington, R.S. Cole, Impact with a liquid surface, studied by the aid of instantaneous photography, Phil. Trans. R. Soc. Lond. A 189 (1897) 137–148.
[9] F. Rodriguez, R. Mesler, Some drops don't splash, J. Colloid Interface Sci. 106 (2) (1985) 347–352.
[10] M. Rein, The transitional regime between coalescing and splashing drops, J. Fluid Mech. 306 (1996) 145–165.
[11] H.E. Edgerton, J.R. Killian, Flash! Seeing the Unseen by Ultra-High-Speed Photography, Hale, Cushman & Flint, Boston, 1939.
[12] D.S. Chapman, P.R. Critchlow, Formation of vortex rings from falling drops, J. Fluid Mech. 29 (1) (1967) 177–185.
[13] Z.M. Zheng, Condition for occurence of circular penetration during impact of a falling droplet with a fluid, Acta Mech. Sin. 22 (3) (1990) 337-340. (in Chinese).
[14] R.W. Cresswell, B.R. Morton, Drop-formed vortex rings—The generation of vorticity, Phys. Fluids 7 (6) (1995) 1363–1370.
[15] R. Rioboo, C. Bauthier, J. Conti, M. Voué, J. De Coninck, Experimental investigation of splash and crown formation during single drop impact on wetted surfaces, Exp. Fluids 35 (6) (2003) 648–652.
[16] T. Okawa, T. Shiraishi, T. Mori, Production of secondary drops during the single water drop impact onto a plane water surface, Exp. Fluids 41 (6) (2006) 965–974.
[17] X.J. Fan, C.J. Wang, F.P. Guo, B. Chen, M.H. Li, Water droplet impact on high-temperature peanut oil surface: The effects of droplet diameter and oil temperature, Int. J. Therm. Sci. 159 (2021) 106601.
[18] K. Dhuper, S. Deep Guleria, P. Kumar, Interface dynamics at the impact of a drop onto a deep pool of immiscible liquid, Chem. Eng. Sci. 237 (2021) 116541.
[19] H.N. Oguz, A. Prosperetti, Bubble entrainment by the impact of drops on liquid surfaces, J. Fluid Mech. 219 (1990) 143-179.
[20] N.P. van Hinsberg, M. Budakli, S. Göhler, E. Berberović, I.V. Roisman, T. Gambaryan-Roisman, C. Tropea, P. Stephan, Dynamics of the cavity and the surface film for impingements of single drops on liquid films of various thicknesses, J. Colloid Interface Sci. 350 (1) (2010) 336–343.
[21] E. Castillo-Orozco, A. Davanlou, P.K. Choudhury, R. Kumar, Droplet impact on deep liquid pools: Rayleigh jet to formation of secondary droplets, Phys. Rev. E 92 (5) (2015) 053022.
[22] H.M. Ma, C.G. Liu, X. Li, -H.Y. Fang, J.J. Dong, Experimental study of deformation characteristics during the process of liquid drop impact liquid surface, J. Exp. Mech. 34 (4) (2019) 600-608 (in Chinese).
[23] T. Guo, D.K. Yuan, F.Z. Zhao, Study of morphological characteristics and gravitational potential energy of crater formed by droplet impact, J. Exp. Fluid Mech. 35 (2021) (6)17–27 (in Chinese).
[24] O.G. Engel, Crater depth in fluid impacts, J. Appl. Phys. 37 (4) (1966) 1798–1808.
[25] H.C. Pumphrey, P.A. Elmore, The entrainment of bubbles by drop impacts, J. Fluid Mech. 220 (1990) 539–567.
[26] A.I. Fedorchenko, A.B. Wang, On some common features of drop impact on liquid surfaces, Phys. Fluids 16 (5) (2004) 1349–1365.
[27] M.J. Xu, C.H. Li, C.P. Wu, X. Chen, S.X. Lu, Regimes during single water droplet impacting on hot ethanol surface, Int. J. Heat Mass Transf. 116 (2018) 817–824.
[28] H.M. Ma, C.G. Liu, X. Li, H.B. Huang, J.J. Dong, Deformation characteristics and energy conversion during droplet impact on a water surface, Phys. Fluids 31 (6) (2019) 062108.
[29] A. Bisighini, G.E. Cossali, C. Tropea, I.V. Roisman, Crater evolution after the impact of a drop onto a semi-infinite liquid target, Phys. Rev. E 82 (3) (2010) 036319.

Evolution of cavity size and energy conversion due to droplet impact on a water surface

Evolution of cavity size and energy conversion due to droplet impact on a water surface

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价