Acarbose Isolation with Gel Type Strong Acid Cation Exchange Resin：Equilibrium, Kinetic and Thermodynamic Studies

doi:10.1016/S1004-9541(13)60583-2

Chinese Journal of Chemical Engineering ›› 2013, Vol. 21 ›› Issue (10): 1106-1113.DOI: 10.1016/S1004-9541(13)60583-2

Acarbose Isolation with Gel Type Strong Acid Cation Exchange Resin：Equilibrium, Kinetic and Thermodynamic Studies

王亚军^1,2, 于蕾^1,2, 郑裕国^1,2, 王远山^1,2, 沈寅初^1,2

1 Institute of Bioengineering, Zhejiang University of Technology, Hangzhou 310014, China;
2 Engineering Research Center of Bioconversion and Biopurification, Ministry of Education, Zhejiang University of Technology, Hangzhou 310014, China

收稿日期:2012-04-22 修回日期:2012-09-20 出版日期:2013-10-28 发布日期:2013-10-29
通讯作者: ZHENG Yuguo
基金资助:
Supported by the National Basic Research Program of China (2011CB710800) and National Special Program for Key Science and Technology of China (2008ZX09204-004).

Acarbose Isolation with Gel Type Strong Acid Cation Exchange Resin：Equilibrium, Kinetic and Thermodynamic Studies

WANG Yajun^1,2, YU Lei^1,2, ZHENG Yuguo^1,2, WANG Yuanshan^1,2, SHEN Yinchu^1,2

1 Institute of Bioengineering, Zhejiang University of Technology, Hangzhou 310014, China;
2 Engineering Research Center of Bioconversion and Biopurification, Ministry of Education, Zhejiang University of Technology, Hangzhou 310014, China

Received:2012-04-22 Revised:2012-09-20 Online:2013-10-28 Published:2013-10-29
Contact: ZHENG Yuguo
Supported by:
Supported by the National Basic Research Program of China (2011CB710800) and National Special Program for Key Science and Technology of China (2008ZX09204-004).

摘要/Abstract

摘要： Acarbose, a potent α-glucosidase inhibitor, is widely used as an oral anti-diabetic drug for the treatment of the type 2, non-insulin-dependent diabetes. In this work, a gel type strong acid cation exchange resin 001×4 was applied to isolate acarbose from fermentation broth. It was demonstrated that cation exchanger 001×4 displayed a large adsorption capacity and quick exchange rate for acarbose. The static adsorption equilibrium data were well fitted to the Langmuir equation. Column adsorption experiments demonstrated that high dynamic adsorption capacity was reached at bed height of 104.4 mm, feed flow rate of 1.0 ml·min^-1 and acarbose concentration of 4.0 mg·ml^-1. Under the optimized conditions, the column chromatography packed with cation exchanger 001×4 recovered 74.3% (by mass) of acarbose from Actinoplanes utahensis ZJB-08196 fermentation broth with purity of 80.1% (by mass), demonstrating great potential in the practical applications in acarbose separation.

关键词: acarbose, separation, cation exchange, chromatography

Abstract: Acarbose, a potent α-glucosidase inhibitor, is widely used as an oral anti-diabetic drug for the treatment of the type 2, non-insulin-dependent diabetes. In this work, a gel type strong acid cation exchange resin 001×4 was applied to isolate acarbose from fermentation broth. It was demonstrated that cation exchanger 001×4 displayed a large adsorption capacity and quick exchange rate for acarbose. The static adsorption equilibrium data were well fitted to the Langmuir equation. Column adsorption experiments demonstrated that high dynamic adsorption capacity was reached at bed height of 104.4 mm, feed flow rate of 1.0 ml·min^-1 and acarbose concentration of 4.0 mg·ml^-1. Under the optimized conditions, the column chromatography packed with cation exchanger 001×4 recovered 74.3% (by mass) of acarbose from Actinoplanes utahensis ZJB-08196 fermentation broth with purity of 80.1% (by mass), demonstrating great potential in the practical applications in acarbose separation.

Key words: acarbose, separation, cation exchange, chromatography

王亚军, 于蕾, 郑裕国, 王远山, 沈寅初. Acarbose Isolation with Gel Type Strong Acid Cation Exchange Resin：Equilibrium, Kinetic and Thermodynamic Studies[J]. Chinese Journal of Chemical Engineering, 2013, 21(10): 1106-1113.

WANG Yajun, YU Lei, ZHENG Yuguo, WANG Yuanshan, SHEN Yinchu. Acarbose Isolation with Gel Type Strong Acid Cation Exchange Resin：Equilibrium, Kinetic and Thermodynamic Studies[J]. Chin.J.Chem.Eng., 2013, 21(10): 1106-1113.

参考文献

1 Jermendy, G., “Can type 2 diabetes mellitus be considered preventable?”, Diabetes Res. Clin. Pract., 68 (S1), S73-S81 (2005).
2 Chiasson, J.L., Josse, R.G., Gomis, R., Hanefeld, M., Karasik, A., Laakso, M., “Acarbose for prevention of type 2 diabetes mellitus: the STOP-NIDDM randomised trial”, Lancet., 359 (9323), 2072-2077 (2002).
3 Hong, C., Kim, K.H., Choi, B.T., Choi, G.S., Choi, Y.R., “Process for preparing acarbose with high purity”, U.S. Pat., 6649755 (2003).
4 Rodriguez, J.F., De Lucas, A., Carmona, M., “Application of ion exchange to purify acarbose from fermentation broths”, Biochem. Eng. J., 40, (1), 130-137 (2008).
5 Lange, P.M., Rauenbusch, E., “Polymers for the purification of acarbose”, U.S. Pat., 4666776 (1987).
6 Lange, P.M., Rauenbusch, E., “Process for the purification of acarbose with polymers”, U.S. Pat., 4767850 (1988).
7 Lawton, C., “A process for the purification of acarbose”, WO 99/07720 (1998).
8 Mihaljevic, K., Azaric, J., Bajic, B., “Acarbose purification process”, U.S. Pat., 6734300 (2004).
9 Rauenbusch, E., “Highly pure acarbose”, U.S. Pat., 4904769 (1990).
10 Wang, Y.J., Liu, L.L., Wang, Y.S., “Actinoplanes utahensis ZJB-08196 fed-batch fermentation at elevated osmolality for enhancing acarbose production”, Bioresour. Technol., 103 (1), 337-342 (2012).
11 Wang, Y.J., Liu, L.L., Feng, Z.H., “Optimization of media composition and culture conditions for acarbose production by Actinoplanes utahensis ZJB-08196”, World J. Microbiol. Biotechnol., 27 (12), 2759-2766 (2011).
12 Langmuir, I., “The constitution and fundamental properties of solids and liquids. Part I. solids”, J. Am. Chem. Soc., 38 (11), 2221-2295 (1916).
13 Ho, Y.S., Mckay, G., “A comparison of chemisorption kinetic models applied to pollutant removal on various sorbents”, Process Saf. Environ. Prot., 76 (B4), 332-340 (1998).
14 Ho, Y.S., McKay, G., “Pseudo-second order model for sorption processes”, Process Biochem., 34 (5), 451-465 (1999).
15 Wang, Y.J., Xue, Y.P., Wang, Y.S., “Analysis and determination of anti-diabetes drug acarbose and its structural analogs”, Curr. Pharm. Anal., 7 (1), 12-20 (2011).
16 Catena, G.C., Bright, F.V., “Thermodynamic study on the effects of β-cyclodextrin inclusion with anilinonaphthalene sulfonates”, Anal. Chem., 61 (8), 905-909 (1989).
17 Brucher, J., Bergstrom, L., “Temperature dependence of linuron sorption to three different agricultural soils”, J. Environ. Qual., 26 (5), 1327-1335 (1997).
18 Hall, K.R., Eagleton, L.C., Acrivos, A., “Pore- and solid-diffusion kinetics in fixed-bed adsorption under constant-pattern conditions”, Ind. Eng. Chem. Fundam., 5 (2), 212-223 (1966).
19 Robinson-Lora, M.A., Brennan, R.A., “Biosorption of manganese onto chitin and associated proteins during the treatment of mine impacted water”, Chem. Eng. J., 162 (2), 565-572 (2010).
20 Hamdaoui, O., Saoudi, F., Chiha, M., “Sorption of malachite green by a novel sorbent, dead leaves of plane tree: Equilibrium and kinetic modeling”, Chem. Eng. J., 143, 73-84 (2008).
21 Uslu, H., “Adsorption equilibria of formic acid by weakly basic adsorbent Amberlite IRA-67: Equilibrium, kinetics, thermodynamic”, Chem. Eng. J., 155, 320-325 (2009).
22 Liu, Y., Liu, Y.J., “Biosorption isotherms, kinetics and thermodynamics”, Sep. Purif. Technol., 61 (3), 229-242 (2008).
23 Wawrzkiewicz, M., Hubicki, Z., “Equilibrium and kinetic studies on the adsorption of acidic dye by the gel anion exchanger”, J. Hazard. Mater., 172, 868-874 (2009).
24 Mack, C.L., Wilhelmi, B., Duncan, J.R., “A kinetic study of the recovery of platinum ions from an artificial aqueous solution by immobilized Saccharomyces cerevisiae biomass”, Miner. Eng., 21 (1), 31-37 (2008).
25 Renault, F., Morin-Crini, N., Gimbert, F., “Cationized starch-based material as a new ion-exchanger adsorbent for the removal of C.I. Acid Blue 25 from aqueous solutions”, Bioresour. Technol., 99 (16), 7573-7586 (2008).
26 Yoon, Y.H., Nelson, J.H., “Breakthrough time and adsorption capacity of respirator cartridges”, Am. Ind. Hyg. Assoc. J., 53 (5), 303-316 (1992).
27 Quek, S.Y., Al-Duri, I., “Application of film-pore diffusion model for the adsorption of metal ions on coir in a fixed-bed column”, Chem. Eng. Process., 46 (5), 477-485 (2007).
28 Sivakumar, P., Palanisamy, P.N., “Adsorptive removal of reactive and direct dyes using non-conventional adsorbent-column studies”, J. Sci. Ind. Res., 68 (10), 894-899 (2009).

[1]	Pan Wang, Mengdei Zhou, Zhuangxin Wei, Lu Liu, Tao Cheng, Xiaohua Tian, Jianming Pan. Preparation of bowl-shaped polydopamine surface imprinted polymer composite adsorbent for specific separation of 2′-deoxyadenosine[J]. 中国化学工程学报, 2023, 60(8): 69-79.
[2]	Wenwen Zhang, Zhigang Xue, Liyun Cui, Haoliang Gao, Di Zhao, Rongfei Zhou, Weihong Xing. Synthesis of an IMF zeolite membrane for the separation of xylene isomer[J]. 中国化学工程学报, 2023, 60(8): 205-211.
[3]	Hammad Saulat, Jianhua Yang, Tao Yan, Waseem Raza, Wensen Song, Gaohong He. Tungsten incorporated mobil-type eleven zeolite membranes: Facile synthesis and tuneable wettability for highly efficient separation of oil/water mixtures[J]. 中国化学工程学报, 2023, 60(8): 242-252.
[4]	Yuan Liu, Hanting Xiong, Jingwen Chen, Shixia Chen, Zhenyu Zhou, Zheling Zeng, Shuguang Deng, Jun Wang. One-step ethylene separation from ternary C₂ hydrocarbon mixture with a robust zirconium metal-organic framework[J]. 中国化学工程学报, 2023, 59(7): 9-15.
[5]	Borui Liu, Tao Zhang, Yi Zheng, Kailong Li, Hui Pan, Hao Ling. A dynamic control structure of liquid-only transfer stream distillation column[J]. 中国化学工程学报, 2023, 59(7): 135-145.
[6]	Yafei Su, Xuke Zhang, Hui Li, Donglai Peng, Yatao Zhang. In-situ incorporation of halloysite nanotubes with 2D zeolitic imidazolate framework-L based membrane for dye/salt separation[J]. 中国化学工程学报, 2023, 58(6): 103-111.
[7]	Shuangtai Liu, Lei He, Qiuxiang Yao, Xi Li, Linyang Wang, Jing Wang, Ming Sun, Xiaoxun Ma. Separation and analysis of six fractions in low temperature coal tar by column chromatography[J]. 中国化学工程学报, 2023, 58(6): 256-265.
[8]	Wende Tian, Jiawei Zhang, Zhe Cui, Haoran Zhang, Bin Liu. Microscopic mechanism study and process optimization of dimethyl carbonate production coupled biomass chemical looping gasification system[J]. 中国化学工程学报, 2023, 58(6): 291-305.
[9]	Hui Yi Leong, Xiao-Qian Fu, Xiang-Yu Liu, Shan-Jing Yao, Dong-Qiang Lin. Characterisation and separation of infectious bursal disease virus-like particles using aqueous two-phase systems[J]. 中国化学工程学报, 2023, 57(5): 72-78.
[10]	Yujia Cui, Zhiqiang Tan, Yanan Wang, Shuxian Shi, Xiaonong Chen. One-step crosslinking preparation of tannic acid particles for the adsorption and separation of cationic dyes[J]. 中国化学工程学报, 2023, 57(5): 309-318.
[11]	Xingzhong Li, Kunlin Yu, Zibo He, Bo Liu, Rongfei Zhou, Weihong Xing. Improved SSZ-13 thin membranes fabricated by seeded-gel approach for efficient CO₂ capture[J]. 中国化学工程学报, 2023, 56(4): 273-280.
[12]	Wufeng Wu, Xilu Hong, Jiang Fan, Yanying Wei, Haihui Wang. Research progress on the substrate for metal–organic framework (MOF) membrane growth for separation[J]. 中国化学工程学报, 2023, 56(4): 299-313.
[13]	Taoyan Mao, Runhui Xiao, Peng Liu, Jiale Chen, Junqiang Luo, Su Luo, Fengwei Xie, Cheng Zheng. Facile fabrication of durable superhydrophobic fabrics by silicon polyurethane membrane for oil/water separation[J]. 中国化学工程学报, 2023, 55(3): 73-83.
[14]	Zhengchi Yin, Xiaoke Wu, Yanwei Yang, Huayu Zhang, Wangtao Li, Ruimin Zhu, Qiancheng Zheng, Zhengbao Wang. Fabrication of ZIF-8 membranes on dual-layer ZnO-PES/PES organic hollow fibers by in-situ crystallization[J]. 中国化学工程学报, 2023, 55(3): 101-110.
[15]	Tutuk Djoko Kusworo, Monica Yulfarida, Andri Cahyo Kumoro, Dani Puji Utomo. Purification of bioethanol fermentation broth using hydrophilic PVA crosslinked PVDF-GO/TiO₂ membrane[J]. 中国化学工程学报, 2023, 55(3): 123-136.

Acarbose Isolation with Gel Type Strong Acid Cation Exchange Resin：Equilibrium, Kinetic and Thermodynamic Studies

Acarbose Isolation with Gel Type Strong Acid Cation Exchange Resin：Equilibrium, Kinetic and Thermodynamic Studies

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价