Variation of toxic pollutants emission during a feeding cycle from an updraft fixed bed gasifier for disposing rural solid waste

doi:10.1016/j.cjche.2017.07.019

Chinese Journal of Chemical Engineering ›› 2018, Vol. 26 ›› Issue (3): 608-613.DOI: 10.1016/j.cjche.2017.07.019

• Energy, Resources and Environmental Technology • 上一篇下一篇

Variation of toxic pollutants emission during a feeding cycle from an updraft fixed bed gasifier for disposing rural solid waste

Ming Lei¹, Jing Hai², Jiang Cheng¹, Jiawei Lu², Jieru Zhang², Tao You²

1 School of Chemistry and Chemical Engineering, South China University of Technology, Guangzhou 510640, China;
2 South China Institute of Environmental Sciences, Ministry of Environmental Protection(MEP), Guangzhou 510655, China

收稿日期:2017-04-16 修回日期:2017-07-24 出版日期:2018-03-28 发布日期:2018-04-18
通讯作者: Jing Hai, Jiang Cheng
基金资助:
Supported by the Science and Technology Planning Project of Guangdong Province, China (2013B090600134), the National Natural Science Foundation of China (51608223) and the Fund for Basic Scientific Research Business of Central Institutes of Environmental Protection (PM-zx 703-201602-050).

Variation of toxic pollutants emission during a feeding cycle from an updraft fixed bed gasifier for disposing rural solid waste

Ming Lei¹, Jing Hai², Jiang Cheng¹, Jiawei Lu², Jieru Zhang², Tao You²

1 School of Chemistry and Chemical Engineering, South China University of Technology, Guangzhou 510640, China;
2 South China Institute of Environmental Sciences, Ministry of Environmental Protection(MEP), Guangzhou 510655, China

Received:2017-04-16 Revised:2017-07-24 Online:2018-03-28 Published:2018-04-18
Contact: Jing Hai, Jiang Cheng
Supported by:
Supported by the Science and Technology Planning Project of Guangdong Province, China (2013B090600134), the National Natural Science Foundation of China (51608223) and the Fund for Basic Scientific Research Business of Central Institutes of Environmental Protection (PM-zx 703-201602-050).

摘要/Abstract

摘要： The variation of toxic pollutants emission during a feeding cycle was examined by field monitoring from a batch feeding updraft fixed bed gasifier for disposing rural domestic solid waste. Results showed that the content of oxygen in flue gas gradually increased, while SO₂ and HCl in flue gas decreased with time after feeding in a whole feeding cycle. Although large amount of CO was produced during the gasifying, low CO content in flue gas could be obtained after the heat treatment with an electric heating device. The distribution characteristics of dioxin congeners in flue gas indicted the re-synthesis of dioxins after flue gas heating, and the increase of oxygen promoted the synthesis of dioxins. The emission content of dioxins could meet the standard (0.1 ng I-TEQ·m^-3, GB18458-2014) of China when the oxygen content was controlled below 8.3%. Hence, for a batch feeding gasifier, low oxygen condition should be offered by reducing air intake at the later stage of feeding cycle in order to decrease the re-synthesis of dioxins after the flue gas heating.

关键词: Updraft fixed bed gasifier, Solid waste, Pollutants, Dioxins, Emission, Variation

Abstract: The variation of toxic pollutants emission during a feeding cycle was examined by field monitoring from a batch feeding updraft fixed bed gasifier for disposing rural domestic solid waste. Results showed that the content of oxygen in flue gas gradually increased, while SO₂ and HCl in flue gas decreased with time after feeding in a whole feeding cycle. Although large amount of CO was produced during the gasifying, low CO content in flue gas could be obtained after the heat treatment with an electric heating device. The distribution characteristics of dioxin congeners in flue gas indicted the re-synthesis of dioxins after flue gas heating, and the increase of oxygen promoted the synthesis of dioxins. The emission content of dioxins could meet the standard (0.1 ng I-TEQ·m^-3, GB18458-2014) of China when the oxygen content was controlled below 8.3%. Hence, for a batch feeding gasifier, low oxygen condition should be offered by reducing air intake at the later stage of feeding cycle in order to decrease the re-synthesis of dioxins after the flue gas heating.

Key words: Updraft fixed bed gasifier, Solid waste, Pollutants, Dioxins, Emission, Variation

Ming Lei, Jing Hai, Jiang Cheng, Jiawei Lu, Jieru Zhang, Tao You. Variation of toxic pollutants emission during a feeding cycle from an updraft fixed bed gasifier for disposing rural solid waste[J]. Chinese Journal of Chemical Engineering, 2018, 26(3): 608-613.

参考文献

[1] C. Zeng, D. Niu, Y. Zhao, A comprehensive overview of rural solid waste management in China, Front. Environ. Sci. Eng. 9(6) (2015) 949-961.

[2] Y. Guan, Y. Zhang, D. Zhao, X. Huang, H. Li, Rural domestic waste management in Zhejiang Province, China:Characteristics, current practices, and an improved strategy, J. Air Waste Manage. Assoc. 65(6) (2015) 721-731.

[3] Z. Han, D. Liu, Y. Lei, J. Wu, S. Li, Characteristics and management of domestic waste in the rural area of Southwest China, Waste Manag. Res. 33(1) (2015) 39-47.

[4] X. Yang, 100 Pyrolysis-Gasification Furnace Disposing Rural Domesitic Waste will be Built in Baoshan City, Yunnan Provice, in China, 2014([2014-06-06]. http://www.baoshan.cn/561/2014/06/06/61@71770.htm. (in Chinese)).

[5] Z. Jiang, 54 Small-Scale Thermal Treatment Furnaces for Disposing Rural Solid Waste had Built in Tengchong City, Yunnan Province, in China, 2014([2014-1-17]. http://www.cn-hw.net/html/china/201401/44064.html. (in Chinese)).

[6] H. Fiedler, Thermal formation of PCDD/PCDF:A survey, Environ. Eng. Sci. 15(1) (1998) 49-58.

[7] G. Mckay, Dioxin characterisation, formation and minimisation during municipal solid waste (MSW) incineration:review, Chem. Eng. J. 86(3) (2002) 343-368.

[8] X.U. Xu, J.H. Yan, K.F. Cen, Formation mechanism of dioxins in MSW incineration, Energy Eng. 24(4) (2004) 42-45.

[9] H.J. Zhang, Y.W. Ni, J.P. Chen, Q. Zhang, Influence of variation in the operating conditions on PCDD/F distribution in a full-scale MSW incinerator, Chemosphere 70(4) (2008) 721-730.

[10] G. Zhang, J. Hai, J. Cheng, Z. Cai, M. Ren, S. Zhang, J. Zhang, Evaluation of PCDD/Fs and metals emission from a circulating fluidized bed incinerator co-combusting sewage sludge with coal, J. Environ. Sci. 25(1) (2013) 231-235.

[11] K. Tuppurainen, I. Halonen, P.A.I. Ruokojarvi, J. Tarhanen, J. Ruuskanen, Formation of PCDDs and PCDFs in municipal waste incineration and its inhibition mechanisms:A review, Chemosphere 36(7) (1998) 1493-1511.

[12] P. Mondal, G.S. Dang, M.O. Garg, Syngas production through gasification and cleanup for downstream applications-Recent developments, Fuel Process. Technol. 92(8) (2011) 1395-1410.

[13] V. Wilk, H. Hofbauer, Conversion of fuel nitrogen in a dual fluidized bed steam gasifier, Fuel 106(9) (2013) 793-801.

[14] Q.Q. Ren, C.S. Zhao, C. Liang, J.Z. Shen, Experimental research on formation behavior of fuel-nitrogen during wheat straw pyrolysis, Proc. Chin. Soc. Electr. Eng. 28(23) (2008) 99-104(in Chinese).

[15] L. Tang, Study on the Properties of Pyrolysis Products and Elements Distribution during Minicipal Solid Waste Pyrolysis, Master Thesis, Chongqing University, 2015(in Chinese).

[16] W. Ma, G. Hoffmann, M. Schirmer, G. Chen, V.S. Rotter, Chlorine characterization and thermal behavior in MSW and RDF, J. Hazard. Mater. 178(1-3) (2010) 489-498.

[17] Q. Xie, J.M. Shen, X.S. Zhang, L.I. Wei, Behavior of chlorine in municipal solid waste during heat treatment, J. China Univ. Min. Technol. 32(6) (2003) 641-645.

[18] J. Dong, Y. Chi, Y. Tang, M. Ni, A. Nzihou, E. Weisshortala, Q. Huang, Effect of operating parameters and moisture content on municipal solid waste pyrolysis and gasification, Energy Fuel 30(5) (2016) 3994-4001.

[19] M.L. Mastellone, L. Zaccariello, U. Arena, Co-gasification of coal, plastic waste and wood in a bubbling fluidized bed reactor, Fuel 89(10) (2010) 2991-3000.

[20] M. Yan, X. Li, T. Chen, S. Lu, J. Yan, Effect of temperature and oxygen on the formation of chlorobenzene as the indicator of PCDD/Fs, J. Environ. Sci. 22(10) (2010) 1624-1637.

[21] C. Ki-In, L. Dong-Hoon, O. Masahiro, K. Sam-Cwan, The prediction of PCDD/DF levels in wet scrubbers associated with waste incinerators, Chemosphere 66(6) (2007) 1131-1137.

[22] H. Hunsinger, S. Kreisz, H. Seifert, PCDD/F behavior in wet scrubbing systems of waste incineration plants, Chemosphere 37(9-12) (1998) 2293-2297.

[23] G. Mckay, Dioxin characterisation, formation and minimisation during municipal solid waste (MSW) incineration:review, Chem. Eng. J. 86(01) (2002) 343-368.

[24] H. Liu, S. Kong, Y. Liu, H. Zeng, Pollution control technologies of dioxins in municipal solid waste incinerator, Procedia Environ Sci 16(4) (2012) 661-668.

[25] Y. Zhang, D. Zhang, J. Gao, J. Zhan, C. Liu, New understanding of the formation of PCDD/Fs from chlorophenol precursors:a mechanistic and kinetic study, J. Phys. Chem. A 118(2) (2014) 449-456.

[26] K. Mohr, C. Nonn, J. Jager, Behaviour of PCDD/F under pyrolysis conditions, Chemosphere 34(5) (1997) 1053-1064.

[27] V.I. Babushok, W. Tsang, Gas-phase mechanism for dioxin formation, Chemosphere 51(10) (2003) 1023-1029.

[28] M.B. Chang, T.F. Huang, The effects of temperature and oxygen content on the PCDD/PCDFs formation in MSW fly ash, Chemosphere 40(2) (2000) 159-164.

[29] G. Zhang, J. Hai, J. Cheng, Characterization and mass balance of dioxin from a largescale municipal solid waste incinerator in China, Waste Manag. 32(6) (2012) 1156-1162.

[30] Z. Hui, A. Meng, Y. Long, Q. Li, Y. Zhang, A review of dioxin-related substances during municipal solid waste incineration, Waste Manag. 36(3) (2014) 106-118.

Variation of toxic pollutants emission during a feeding cycle from an updraft fixed bed gasifier for disposing rural solid waste

Variation of toxic pollutants emission during a feeding cycle from an updraft fixed bed gasifier for disposing rural solid waste

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	Haoshan Duan, Xi Meng, Jian Tang, Junfei Qiao. Prediction of NO_x concentration using modular long short-term memory neural network for municipal solid waste incineration[J]. 中国化学工程学报, 2023, 56(4): 46-57.
[2]	Xin Yong, Hong Chen, Huawang Zhao, Miao Wei, Yingnan Zhao, Yongdan Li. Insight into SO₂ poisoning and regeneration of one-pot synthesized Cu-SSZ-13 catalyst for selective reduction of NO_x by NH₃[J]. 中国化学工程学报, 2022, 46(6): 184-193.
[3]	Huawang Zhao, Xiaomin Wu, Zhiwei Huang, Ziyi Chen, Guohua Jing. A comparative study of the thermal and hydrothermal aging effect on Cu-SSZ-13 for the selective catalytic reduction of NO_x with NH₃[J]. 中国化学工程学报, 2022, 45(5): 68-77.
[4]	Wei Zhou, Xiaoxiao Meng, Liang Xie, Junfeng Li, Yani Ding, Yanlin Su, Jihui Gao, Guangbo Zhao. Simultaneous utilization of electro-generated O₂ and H₂ for H₂O₂ production: An upgrade of the Pd-catalytic electro-Fenton process for pollutants degradation[J]. 中国化学工程学报, 2022, 44(4): 363-368.
[5]	Ling Xu, Ji Li, Wenbin Zeng, Kai Liu, Yibing Ma, Liping Fang, Chenlu Shi. Surfactant-assisted removal of 2,4-dichlorophenol from soil by zero-valent Fe/Cu activated persulfate[J]. 中国化学工程学报, 2022, 44(4): 447-455.
[6]	Vitória M. Almeida, Carla A. Orge, M. Fernando R. Pereira, O. Salomé G.P. Soares. O₃ based advanced oxidation for ibuprofen degradation[J]. 中国化学工程学报, 2022, 42(2): 277-284.
[7]	Mengqian Xie, Fangqin Dai, Yaojie Tu. A numerical study of accelerated moderate or intense low-oxygen dilution (MILD) combustion stability for methane in a lab-scale furnace by off-stoichiometric combustion technology[J]. 中国化学工程学报, 2021, 32(4): 108-118.
[8]	Hakima Kadji, Idris Yahiaoui, Zehira Garti, Abdeltif Amrane, Farida Aissani-Benissad. Kinetic degradation of amoxicillin by using the electro-Fenton process in the presence of a graphite rods from used batteries[J]. 中国化学工程学报, 2021, 32(4): 183-190.
[9]	Hongbing Song, Lei Liu, Bingxiao Feng, Haozhong Wang, Meng Xiao, Hengjun Gai, Yubao Tang, Xiaofei Qu, Tingting Huang. Modified g-C₃N₄ derived from ionic liquid and urea for promoting visible-light photodegradation of organic pollutants[J]. 中国化学工程学报, 2021, 40(12): 293-303.
[10]	Wenhao Niu, Yuanzhi Zheng, Ying Li, Le Du, Wei Liu. Photochemical microfluidic synthesis of vitamin D₃ by improved light sources with photoluminescent substrates[J]. 中国化学工程学报, 2021, 29(1): 204-211.
[11]	Zhengliang Huang, Peng Zhang, Yao Yang, Jingyuan Sun, Jingdai Wang, Yongrong Yang, Chenghao Huang, Zhixiong Huang. Acoustic emission detection of slag performance in coal gasifiers[J]. 中国化学工程学报, 2020, 28(8): 2200-2207.
[12]	M. M. Haddadi, S. H. Hosseini, D. Rashtchian, Martin Olazar. Comparative analysis of different static mixers performance by CFD technique: An innovative mixer[J]. 中国化学工程学报, 2020, 28(3): 672-684.
[13]	E. Amani, A. Daneshgar, A. Hemmatzade. A novel combined baffle-cavity micro-combustor configuration for Micro-Thermo-Photo-Voltaic applications[J]. 中国化学工程学报, 2020, 28(2): 403-413.
[14]	Chandni Joshi, Jeffrey Seay. Building momentum for sustainable behaviors in developing regions using Locally Managed Decentralized Circular Economy principles[J]. 中国化学工程学报, 2019, 27(7): 1566-1571.
[15]	Qili Qiu, Xuguang Jiang, Guojun Lü, Zhiliang Chen, Shengyong Lu, Mingjiang Ni, Jianhua Yan, Xiaobing Deng. Degradation of PCDD/Fs in MSWI fly ash using a microwave-assisted hydrothermal process[J]. 中国化学工程学报, 2019, 27(7): 1708-1715.