Measurements and correlation of liquid-liquid equilibrium data for the ternary (methyl tert-butyl ketone + o, m, p-benzenediol + water) system at (333.2, 343.2 and 353.2) K

doi:10.1016/j.cjche.2018.09.011

中国化学工程学报 ›› 2019, Vol. 27 ›› Issue (4): 905-911.DOI: 10.1016/j.cjche.2018.09.011

• Chemical Engineering Thermodynamics • 上一篇下一篇

Measurements and correlation of liquid-liquid equilibrium data for the ternary (methyl tert-butyl ketone + o, m, p-benzenediol + water) system at (333.2, 343.2 and 353.2) K

Kangning Xiong¹, Shuai Shen¹, Youchang Wang¹, Yun Chen^1,2

1 State Key Laboratory of Pulp and Paper Engineering, Department of Chemistry and Chemical Engineering, South China University of Technology, Guangzhou 510640, China;
2 Department of Chemical & Biomolecular Engineering, North Carolina State University, Raleigh, NC 27695, USA

收稿日期:2018-06-11 修回日期:2018-08-21 出版日期:2019-04-28 发布日期:2019-06-14
通讯作者: Yun Chen
基金资助:
Supported by the State Key Laboratory of Pulp and Paper Engineering in China (201703, 201708).

Measurements and correlation of liquid-liquid equilibrium data for the ternary (methyl tert-butyl ketone + o, m, p-benzenediol + water) system at (333.2, 343.2 and 353.2) K

Kangning Xiong¹, Shuai Shen¹, Youchang Wang¹, Yun Chen^1,2

1 State Key Laboratory of Pulp and Paper Engineering, Department of Chemistry and Chemical Engineering, South China University of Technology, Guangzhou 510640, China;
2 Department of Chemical & Biomolecular Engineering, North Carolina State University, Raleigh, NC 27695, USA

Received:2018-06-11 Revised:2018-08-21 Online:2019-04-28 Published:2019-06-14
Contact: Yun Chen
Supported by:
Supported by the State Key Laboratory of Pulp and Paper Engineering in China (201703, 201708).

摘要/Abstract

摘要： In this work, liquid-liquid equilibria (LLE) data for the ternary system methyl tert-butyl ketone (MTBK) + o, m, p-benzenediol + water were investigated at 333.2 K, 343.2 K and 353.2 K under 101.3 kPa. The performance of MTBK to extract o, m, p-benzenediol from wastewaters was estimated by partition coefficients and separation factors. The Hand and Bachman equations were both applied to check the reliability of the experimental LLE data. Furthermore, the Non-Random Two-Liquid (NRTL) and Universal Quasi Chemical (UNIQUAC) models were applied to correlate the measured LLE data. The results showed a good agreement with the determined ternary LLE data with the root-mean-square error (RMSE) values below 0.71%. MTBK was proved to be a promising extracting agent in extracting benzenediols from effluents.

关键词: Liquid-liquid equilibrium, Methyl tert-butyl ketone, Benzenediol, NRTL model, UNIQUAC model

Abstract: In this work, liquid-liquid equilibria (LLE) data for the ternary system methyl tert-butyl ketone (MTBK) + o, m, p-benzenediol + water were investigated at 333.2 K, 343.2 K and 353.2 K under 101.3 kPa. The performance of MTBK to extract o, m, p-benzenediol from wastewaters was estimated by partition coefficients and separation factors. The Hand and Bachman equations were both applied to check the reliability of the experimental LLE data. Furthermore, the Non-Random Two-Liquid (NRTL) and Universal Quasi Chemical (UNIQUAC) models were applied to correlate the measured LLE data. The results showed a good agreement with the determined ternary LLE data with the root-mean-square error (RMSE) values below 0.71%. MTBK was proved to be a promising extracting agent in extracting benzenediols from effluents.

Key words: Liquid-liquid equilibrium, Methyl tert-butyl ketone, Benzenediol, NRTL model, UNIQUAC model

Kangning Xiong, Shuai Shen, Youchang Wang, Yun Chen. Measurements and correlation of liquid-liquid equilibrium data for the ternary (methyl tert-butyl ketone + o, m, p-benzenediol + water) system at (333.2, 343.2 and 353.2) K[J]. 中国化学工程学报, 2019, 27(4): 905-911.

参考文献

[1] K. Xie, W. Li, W. Zhao, Coal chemical industry and its sustainable development in China, Energy 35(2010) 4349-4355.
[2] Q. Ji, S. Tabassum, S. Hena, C.G. Silva, G. Yu, Z. Zhang, A review on the coal gasification wastewater treatment technologies:past, present and future outlook, J. Clean. Prod. 126(2016) 38-55.
[3] W. Wang, H. Han, J. Zhang, Progress in treatment technologies of coal gasification wastewater, Chem. Eng. Prog. 32(2013) 681-686.
[4] National Environmental Protection Agency, Integrated Wastewater Discharge Standard. GB 8978-1996, 1996.
[5] A. Dabrowski, P. Podkościelny, Z. Hubicki, M. Barczak, Adsorption of phenolic compounds by activated carbon-a critical review, Chemosphere 58(2005) 1049-1070.
[6] M. Otero, M. Zabkova, A.E. Rodrigues, Comparative study of the adsorption of phenol and salicylic acid from aqueous solution onto nonionic polymeric resins, Sep. Purif. Technol. 45(2005) 86-95.
[7] M.T.A. Reis, O.M.F.D. Freitas, M.R.C. Ismael, Recovery of phenol from aqueous solutions using liquid membranes with Cyanex 923, J. Membr. Sci. 305(2007) 313-324.
[8] D. Vione, C. Minero, V. Maurino, Degradation of phenol and benzoic acid in the presence of a TiO₂-based heterogeneous photocatalyst, Appl. Catal. B Environ. 58(2005) 79-88.
[9] Z. Wang, X. Xu, Z. Gong, F. Yang, Removal of COD, phenols and ammonium from Lurgi coal gasification wastewater using A₂O-MBR system, J. Hazard. Mater. 235-236(2012) 78-84.
[10] W. Xu, G. Dai, K. Tang, Equilibrium of liquid-liquid extraction of 2-phenylbutyric acid enantiomers:experiment and model, Chin. J. Chem. Eng. 26(2018) 708-714.
[11] H. Hou, J. Xu, Y. Wang, Solvent extraction of lanthanum and cerium ions from hydrochloric acidic aqueous solutions using partly saponified 2-ethylhexyl phosphonic acid mono-2-ethylhexyl ester, Chin. J. Chem. Eng. 24(2016) 79-85.
[12] Y. Chen, S. Zhou, H. Chen, Y. Wang, L. Li, Extraction of o-, m- and p-cresol from aqueous solution with methyl isopropyl ketone:equilibrium, correlations, and COSMO-RS predictions, J. Chem. Thermodyn. 115(2017) 180-190.
[13] Y. Chen, R. Lv, F. Wang, L. Li, Determination and modeling of liquid-liquid equilibrium for ternary mixtures of methyl isopropyl ketone, cresol isomers and water, Fluid Phase Equilib. 429(2016) 107-112.
[14] S. Zhou, M. Liao, D. Liu, L. Li, Y. Chen, Liquid-liquid equilibrium for the ternary systems methyl tert-butyl ketone + o -, m -, p -cresol + water at (298.2, 313.2, and 323.2) K, J. Chem. Eng. Data 62(2017) 1929-1936.
[15] Y. Chen, H. Wang, R. Lv, L. Li, Phase equilibrium measurement and thermodynamic modeling of the 4-methylpentan-2-one/3-methylphenol, and 4-methylphenol/water ternary systems at 298.2, 313.2, and 323.2 K and 0.1 MPa, J. Chem. Eng. Data 62(2017) 141-147.
[16] R. Lv, Z. Wang, L. Li, Y. Chen, Liquid-liquid equilibria in the ternary systems water+ cresols+ methyl butyl ketone at 298.2 and 313.2 K:experimental data and correlation, Fluid Phase Equilib. 404(2015) 89-95.
[17] S. Zhou, L. Li, Y. Wang, Y. Chen, Measurement, correlation and COSMO-SAC prediction of liquid-liquid equilibrium for the ternary systems, mesityl oxide + o -, m -, p -cresol + water, at 333.2 K and 353.2 K, Fluid Phase Equilib. 440(2017) 45-53.
[18] Y. Chen, H. Wang, R. Lv, L. Li, Liquid-liquid equilibria for methyl isobutyl ketone + cresols + water at 333.15 K, 343.15 K and 353.15 K:experimental results and data correlation, Fluid Phase Equilib. 427(2016) 291-296.
[19] L. Luo, D. Liu, L. Li, Y. Chen, Measurements and thermodynamic modeling of liquid-liquid equilibria in ternary system 2-methoxy-2-methylpropane+p-cresol+water, Chin. J. Chem. Eng. 24(2016) 360-364.
[20] Teh C. Lo, M.H.I. Baird, Solvent Extraction, Encyclopedia of Physical Science and Technology, Third Edition Academic Press 2003, pp. 341-362.
[21] X. Miao, H. Zhang, Liquid-liquid equilibria of the ternary system water + acetic acid + methyl tert-butyl ether, J. Chem. Eng. Data 52(2007) 789-793.
[22] I.C. Hwang, S.J. Park, S.J. In, Liquid-liquid equilibria for ternary mixtures of methyl tert-butyl ether, ethyl tert-butyl ether, water and imidazolium-based ionic liquids at 298.15K, J. Ind. Eng. Chem. 20(2014) 3292-3296.
[23] D.M.T. Newsham, S.B. Ng, Liquid-liquid equilibriums in mixtures of water, propyl alcohol, and butyl alcohol, J. Chem. Eng. Data 17(1972) 205-207.
[24] N.V. Sastry, S.R. Patel, S.S. Soni, Excess molar volumes, excess isentropic compressibilities, excess viscosities, relative permittivity and molar polarization deviations for methyl acetate +, ethyl acetate +, butyl acetate +, isoamyl acetate +, methyl propionate +, ethyl propionate +, ethyl, J. Mol. Liq. 183(2013) 102-112.
[25] Y. Chen, Z. Wang, L. Li, Liquid-liquid equilibria for ternary systems:methyl butyl ketone + phenol + water and methyl butyl ketone + hydroquinone + water at 298.15 K and 323.15 K, J. Chem. Eng. Data 59(2014) 2750-2755.
[26] C. Chang, J.L. Chang, Measurement and correlation of liquid-liquid equilibrium data for water-ethanol-methyl isobutyl ketone, Chem. Eng. 42(2014) 39-60.
[27] H.S. Sang, I.C. Hwang, S.J. Park, Liquid-liquid equilibria at 298.15 K for ternary mixtures of methyl tert -butyl ether + methanol (or ethanol) + imidazolium-based ionic liquids at atmospheric pressure, Fluid Phase Equilib. 342(2013) 82-87.
[28] G. Xu, D. Yang, P. Ning, Measurements and correlation of liquid-liquid equilibrium data for the ternary (3-heptanone + phenol + water) system, J. Chem. Thermodyn. 106(2016) 295-302.
[29] R. Lv, L. Li, H. Wang, Experimental determination and correlation of liquid-liquid equilibria for methyl isopropyl ketone + phenol + water mixtures at 298.15, 313.15, and 323.15 K, J. Chem. Eng. Data 61(2016) 2221-2225.
[30] H.D. Oliveira, M. Aznar, (Liquid + liquid) equilibrium of {water + phenol +(1-butanol, or 2-butanol, or tert-butanol)} systems, J. Chem. Thermodyn. 42(2010) 1379-1385.
[31] Y. Chen, K. Xiong, S. Zhou, Liquid-liquid equilibrium of ternary systems of methyl isobutyl ketone + o-cresol + water at 298.2, 313.2 and 323.2 K, J. Solut. Chem. (2017) 1-10.
[32] Y. Chen, R. Lv, H. Wang, Ternary liquid-liquid equilibria for methyl isopropyl ketone +(resorcinol or hydroquinone) + water systems at different temperatures, Fluid Phase Equilib. 429(2016) 93-97.
[33] C. Yang, Y. Jiang, Liquid-liquid equilibria for the ternary system methyl isobutyl ketone + water + hydroquinone, J. Chem. Eng. Data 51(2006) 2107-2109.
[34] Y. Chen, H. Wang, R. Lv, Liquid-liquid equilibrium for ternary systems, methyl isobutyl ketone+(catechol, resorcinol and hydroquinone)+water at 333.15K, 343.15K and 353.15K, Fluid Phase Equilib. 433(2017) 206-211.
[35] D.B. Hand, Dineric distribution, J. Phys. Chem. 34(1929) 1961-2000.
[36] I. Bachman, Tie lines in ternary liquid systems, Ind. Eng. Chem. Anal. Ed. 14(1940) 38-39.
[37] H. Renon, J.M. Prausnitz, Local compositions in thermodynamic excess functions for liquid mixtures, AIChE J. 14(1968) 135-144.
[38] D.S. Abrams, J.M. Prausnitz, Statistical thermodynamics of liquid mixtures anew expression for the excess Gibbs energy of party or completely miscible systems, AIChE J. 21(1975) 116-128.

Measurements and correlation of liquid-liquid equilibrium data for the ternary (methyl tert-butyl ketone + o, m, p-benzenediol + water) system at (333.2, 343.2 and 353.2) K

Measurements and correlation of liquid-liquid equilibrium data for the ternary (methyl tert-butyl ketone + o, m, p-benzenediol + water) system at (333.2, 343.2 and 353.2) K

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 14

编辑推荐

Metrics

本文评价

[1]	Zhansheng Li, Jiayu Song, Shouhai Zhang, Jinyan Wang, Xigao Jian. Measurement and correlation of liquid-liquid equilibrium for the ternary system (water + 1,2-dichloroethane + sulfolane) at 288.15, 298.15, and 308.15 K[J]. 中国化学工程学报, 2022, 51(11): 109-114.
[2]	Yonglin Li, He'an Luo, Qiuhong Ai, Kuiyi You, Fei Zhao, Wenlong Xiao. Efficient separation of phenols from coal tar with aqueous solution of amines by liquid-liquid extraction[J]. 中国化学工程学报, 2021, 35(7): 180-188.
[3]	Huichao Lv, Dayong Tian. Designing and optimizing a parallel neural network model for predicting the solubility of diosgenin in n-alkanols[J]. 中国化学工程学报, 2021, 29(1): 288-294.
[4]	Yonghui Dou, Huanxin Li, Xiaoqiang Gao, Guoji Liu, Li Xu. Investigation of liquid-liquid equilibrium of the ternary system (water+1,6-diaminohexane+2-methyl-1-propanol or 3-methyl-1-butanol) at different temperatures[J]. 中国化学工程学报, 2020, 28(1): 191-197.
[5]	Yun Chen, Kangning Xiong, Shuai Shen, Huimin Wang, Shaoming Zhou, Libo Li. Salt effect on the liquid-liquid equilibrium of the ternary (water + phenol + methyl isobutyl ketone) system: Experimental data and correlation[J]. Chinese Journal of Chemical Engineering, 2019, 27(1): 168-173.
[6]	Youchang Wang, Shaoming Zhou, Jinhui Tang, Yun Chen, Libo Li. Measurement and correlation of phase equilibrium data of the mixtures consisting of water, resorcinol, mesityl oxide at different temperatures[J]. Chinese Journal of Chemical Engineering, 2018, 26(12): 2573-2580.
[7]	Fatemeh Ahmadi, Mohsen Pirdashti, Abbas Ali Rostami. Density, refractive index and liquid-liquid equilibrium data of polyethylene glycol 3000 + potassium formate + water at different pH values[J]. Chinese Journal of Chemical Engineering, 2018, 26(1): 168-174.
[8]	张晓冬, 胡大鹏, 赵宗昌. Measurement and Prediction of Vapor Pressure for H₂O+CH₃OH/C₂H₅OH+[BMIM][DBP] Ternary Working Fluids[J]. Chinese Journal of Chemical Engineering, 2013, 21(8): 886-893.
[9]	林东杰, 丁忠伟, 刘丽英, 马润宇. A Method to Obtain Gas-PDMS Membrane Interaction Parameters for UNIQUAC Model[J]. Chinese Journal of Chemical Engineering, 2013, 21(5): 485-493.
[10]	李雪梅, 沈冲, 李春喜. Effect of Mono- and Di-ethanolammonium Formate Ionic Liquids on the Volatility of Water, Ethanol, and Methanol[J]. Chinese Journal of Chemical Engineering, 2013, 21(10): 1162-1171.
[11]	Bahram Ghalami-Choobar, Ali Ghanadzadeh, Shahram Kousarimehr. Salt Effect on the Liquid-Liquid Equilibrium of(Water+Propionic Acid+Cyclohexanol)System at T=(298.2, 303.2, 308.2)K[J]. , 2011, 19(4): 565-569.
[12]	龚行楚, 吕阳成, 骆广生. Phase Equilibrium Calculations in Mixtures Containing Caprolactam with a UNIFAC Model[J]. , 2010, 18(2): 286-291.
[13]	谢方友, 朱明乔, 刘建青, 何潮洪. 在脉冲填料柱中萃取硫酸铵溶液中的己内酰胺[J]. , 2002, 10(6): 677-680.
[14]	温浩, HelleS.Elbro. VAPOR-LIQUID EQUILIBRIA OF POLYMER SOLUTION USING UNIQUAC[J]. , 1993, 1(3): 152-159.