Implications from γ-globulin adsorption onto cation exchangers fabricated by sequential alginate grafting and sulfonation

doi:10.1016/j.cjche.2020.06.017

中国化学工程学报 ›› 2021, Vol. 29 ›› Issue (1): 121-125.DOI: 10.1016/j.cjche.2020.06.017

• Separation Science and Engineering • 上一篇下一篇

Implications from γ-globulin adsorption onto cation exchangers fabricated by sequential alginate grafting and sulfonation

Xianxiu Li¹, Yan Sun^1,2, Xiaoyan Dong^1,2

1 Department of Biochemical Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin 300354, China;
2 Key Laboratory of Systems Bioengineering and Frontiers Science Center for Synthetic Biology(Ministry of Education), Tianjin University, Tianjin 300072, China

收稿日期:2020-03-09 修回日期:2020-05-21 出版日期:2021-01-28 发布日期:2021-04-02
通讯作者: Xiaoyan Dong
基金资助:
This work was supported by the National Natural Science Foundation of China (Nos. 21878222 and 21621004).

Implications from γ-globulin adsorption onto cation exchangers fabricated by sequential alginate grafting and sulfonation

Xianxiu Li¹, Yan Sun^1,2, Xiaoyan Dong^1,2

1 Department of Biochemical Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin 300354, China;
2 Key Laboratory of Systems Bioengineering and Frontiers Science Center for Synthetic Biology(Ministry of Education), Tianjin University, Tianjin 300072, China

Received:2020-03-09 Revised:2020-05-21 Online:2021-01-28 Published:2021-04-02
Contact: Xiaoyan Dong
Supported by:
This work was supported by the National Natural Science Foundation of China (Nos. 21878222 and 21621004).

摘要/Abstract

摘要： Our previous work proved that high adsorption capacity and uptake rate of lysozyme were achieved on alginate (Alg)-grafted resin with an ionic capacity (IC) of 240 mmol·L^-1 (Alg-FF-240). Moreover, the salt-tolerant feature of Alg-FF-230 was improved by using sequential alginate grafting and sulfonation strategy. Inspired by the enhanced adsorption performance of lysozyme, we have herein proposed to investigate the static and dynamic adsorption behaviors of γ-globulin on a series of Alg-grafted resins with different grafting densities and sulfonation degrees. The adsorption capacity of γ-globulin decreased with increasing alginate-grafting density (IC) from 160 to 230 mmol·L^-1 at 0 mmol·L^-1 NaCl because of the steric hindrance caused by the alginate-grafting layer. Effects of ionic strength (IS) indicated that the adsorption capacities of the resins with the IC value of 230-370 mmol·L^-1 were much higher than CM Sepharose FF at 50-100 mmol·L^-1 NaCl, and the uptake rate of Alg-FF-230 was about twice as much as that of CM Sepharose FF. This work demonstrated the important effects of alginate-grafting layer and IS in γ-globulin adsorption behavior, which would be helpful in the design of Alg-grafted resins and the selection of proper IS condition for protein purification.

关键词: Alginate, Sulfonation, γ-Globulin, Adsorption capacity, Uptake rate

Abstract: Our previous work proved that high adsorption capacity and uptake rate of lysozyme were achieved on alginate (Alg)-grafted resin with an ionic capacity (IC) of 240 mmol·L^-1 (Alg-FF-240). Moreover, the salt-tolerant feature of Alg-FF-230 was improved by using sequential alginate grafting and sulfonation strategy. Inspired by the enhanced adsorption performance of lysozyme, we have herein proposed to investigate the static and dynamic adsorption behaviors of γ-globulin on a series of Alg-grafted resins with different grafting densities and sulfonation degrees. The adsorption capacity of γ-globulin decreased with increasing alginate-grafting density (IC) from 160 to 230 mmol·L^-1 at 0 mmol·L^-1 NaCl because of the steric hindrance caused by the alginate-grafting layer. Effects of ionic strength (IS) indicated that the adsorption capacities of the resins with the IC value of 230-370 mmol·L^-1 were much higher than CM Sepharose FF at 50-100 mmol·L^-1 NaCl, and the uptake rate of Alg-FF-230 was about twice as much as that of CM Sepharose FF. This work demonstrated the important effects of alginate-grafting layer and IS in γ-globulin adsorption behavior, which would be helpful in the design of Alg-grafted resins and the selection of proper IS condition for protein purification.

Key words: Alginate, Sulfonation, γ-Globulin, Adsorption capacity, Uptake rate

Xianxiu Li, Yan Sun, Xiaoyan Dong. Implications from γ-globulin adsorption onto cation exchangers fabricated by sequential alginate grafting and sulfonation[J]. 中国化学工程学报, 2021, 29(1): 121-125.

Xianxiu Li, Yan Sun, Xiaoyan Dong. Implications from γ-globulin adsorption onto cation exchangers fabricated by sequential alginate grafting and sulfonation[J]. Chinese Journal of Chemical Engineering, 2021, 29(1): 121-125.

参考文献

[1] A. Staby, J.H. Jacobsen, R.G. Hansen, U.K. Bruus, I.H. Jensen, Comparison of chromatographic ion-exchange resins:V. Strong and weak cation-exchange resins, J. Chromatogr. A 1118(2006) 168-179.
[2] Y. Zhao, X. Li, L. Yu, X. Dong, Y. Sun, Lysozyme adsorption to cation exchanger derivatized by sequential modification of poly(ethylenimine)-Sepharose with succinic anhydride and ethanolamine:Effect of pH and ionic strength, Chin. J. Chem. Eng. 28(2019) 440-444.
[3] R. Liu, Q. Shi, Protein retention in dextran-grafted cation exchange chromatography:The influence of pHs, counterions and polymer structure, Chin. J. Chem. Eng. 28(2020) 1904-1910.
[4] B.D. Bowes, A.M. Lenhoff, Protein adsorption and transport in dextranmodified ion-exchange media. Ⅲ. Effects of resin charge density and dextran content on adsorption and intraparticle uptake, J. Chromatogr. A 1218(2011) 7180-7188.
[5] K. Shs, N.J. Wagner, A.M. Lenhoff, Effects of resin architecture and protein size on nanoscale protein distribution in ion-exchange media, Langmuir 34(2017) 673-684.
[6] S. Bai, L. Gong, D. Han, Y. Li, L. Yu, Y. Sun, Protein adsorption onto diethylaminoethyl dextran modified anion exchanger:Effect of ionic strength and column behavior, Chin. J. Chem. Eng. 26(2018) 259-267.
[7] X. Li, Y. Liu, Y. Sun, Alginate-grafted Sepharose FF:A novel polymeric ligand-based cation exchanger for high-capacity protein chromatography, Biochem. Eng. J. 126(2017) 50-57.
[8] L. Yu, S. Tao, X. Dong, Y. Sun, Protein adsorption to poly(ethylenimine)-modified Sepharose FF:I. A critical ionic capacity for drastically enhanced capacity and uptake kinetics, J. Chromatogr. A 1305(2013) 76-84.
[9] S. Wang, X. Li, Y. Sun, Poly(N,N-dimethylaminopropyl acrylamide)-grafted sepharose FF:A new anion exchanger of very high capacity and uptake rate for protein chromatography, J. Chromatogr. A 1597(2019) 187-195.
[10] M. Li, Y. Wu, Y. Liu, Y. Sun, Protein adsorption to poly(allylamine)-modified Sepharose FF:Influences of polymer size and partial charge neutralization, Biochem. Eng. J. 142(2019) 153-161.
[11] A. Xue, L. Yu, Y. Sun, Implications from protein uptake kinetics onto dextran-grafted Sepharose FF coupled with ion exchange and affinity ligands, Chin. J. Chem. Eng. 25(2017) 906-910.
[12] X. Li, Y. Liu, Y. Sun, Sequential alginate grafting and sulfonation significantly improve the performance of alginate-grafted Sepharose FF for protein chromatography, Biochem. Eng. J. 137(2018) 11-17.
[13] Y. Fang, D. Lin, S. Yao, Adsorption of IgG and BSA on two chromatographic resinspoly(ethylenimine)-4FF resin and tetrapeptide-poly(ethylenimine)-4FF resin, J. Chem. Eng. Data 63(2018) 4418-4424.
[14] Y. Hong, N. Liu, W. Wei, L.-L. Yu, G. Ma, Y. Sun, Protein adsorption to poly (ethylenimine)-modified Sepharose FF:Ⅲ. Comparison between different proteins, J. Chromatogr. A 1342(2014) 30-36.
[15] M.C. Stone, G. Carta, Protein adsorption and transport in agarose and dextrangrafted agarose media for ion exchange chromatography, J. Chromatogr. A 1146(2007) 202-215.
[16] T. Liu, D. Lin, Q. Wu, Q. Zhang, C. Wang, S. Yao, A novel polymer-grafted hydrophobic charge-induction chromatographic resin for enhancing protein adsorption capacity, Chem. Eng. J. 304(2016) 251-258.
[17] T. Liu, D. Lin, H. Lu, S. Yao, Preparation and evaluation of dextran-grafted agarose resin for hydrophobic charge-induction chromatography, J. Chromatogr. A 1369(2014) 116-124.
[18] S. Wang, X. Li, Y. Sun, Poly(N,N-dimethylaminopropyl acrylamide)-grafted Sepharose FF:A new anion exchanger of very high capacity and uptake rate for protein chromatography, J. Chromatogr. A 1597(2019) 187-195.
[19] J. Gu, H. Tong, D. Lin, Evaluation of magnetic particles modified with a hydrophobic charge-induction ligand for antibody capture, J. Chromatogr. A 1460(2016) 61-67.
[20] H. Li, D. Lin, M. Zhu, S. Yao, Effects of ligand density and pore size on the adsorption of bovine IgG with DEAE ion-exchange resins, J. Sep. Sci. 35(2015) 2131-2137.
[21] Y. Zhao, X. Dong, L. Yu, Y. Sun, Protein adsorption to poly(ethylenimine)-modified Sepharose FF:VI. Partial charge neutralization drastically increases uptake rate, J. Chromatogr. A 1427(2016) 102-110.
[22] R. Xu, X. Li, X. Dong, Y. Sun, Protein cation exchangers derived by charge reversal from poly(ethylenimine)-Sepharose FF:Comparisons between two derivatization routes, J. Chromatogr. A 1611(2020), 460586.
[23] L. Yu, Y. Sun, Protein adsorption to poly(ethylenimine)-modified Sepharose FF:Ⅱ. Effect of ionic strength, J. Chromatogr. A 1305(2013) 85-93.
[24] P. Arosio, G. Barolo, T. Mueller-Spaeth, H. Wu, M. Morbidelli, Aggregation stability of a monoclonal antibody during downstream processing, Pharm. Res. 28(2011) 1884-1894.
[25] Y. Zhao, L. Yu, X. Dong, Y. Sun, Protein adsorption to poly(ethylenimine)-modified sepharose FF:VⅡ. Complicated effects of pH, J. Chromatogr. A 1580(2018) 72-79.
[26] H. Wang, Y. Sun, S. Zhang, J. Luo, Q. Shi, Fabrication of high-capacity cationexchangers for protein chromatography by atom transfer radical polymerization, Biochem. Eng. J. 113(2016) 19-29.
[27] Y. Zhao, X. Dong, L. Yu, Y. Liu, Y. Sun, Characterization of new polymer-grafted protein cation exchangers developed by partial neutralization of carboxyl groups derivatized by modification of poly(ethylenimine)-Sepharose with succinic anhydride, J. Chromatogr. A 1550(2018) 28-34.

Implications from γ-globulin adsorption onto cation exchangers fabricated by sequential alginate grafting and sulfonation

Implications from γ-globulin adsorption onto cation exchangers fabricated by sequential alginate grafting and sulfonation

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	Bing Liu, Yingjiao Li, Moses Arowo, Guangwen Chu, Yong Luo, Liangliang Zhang, Haikui Zou, Baochang Sun. Sulfonation of 1, 4-diaminoanthraquinone leuco by chlorosulfonic acid: Kinetics and process intensification[J]. 中国化学工程学报, 2023, 58(6): 163-169.
[2]	Jiawei Dong, Yanhui He, Junfen Zhang, Zhansheng Wu. Tuning alginate-bentonite microcapsule size and structure for the regulated release of P. putida Rs-198[J]. 中国化学工程学报, 2022, 48(8): 12-20.
[3]	Jinlong Li, Xiaoqing Wang, Puxu Liu, Xiaohua Liu, Libo Li, Jinping Li. Shaping of metal-organic frameworks through a calcium alginate method towards ethylene/ethane separation[J]. 中国化学工程学报, 2022, 42(2): 17-24.
[4]	Yi Xiong, Liping Huang, Sakil Mahmud, Feng Yang, Huihong Liu. Bio-synthesized palladium nanoparticles using alginate for catalytic degradation of azo-dyes[J]. 中国化学工程学报, 2020, 28(5): 1334-1343.
[5]	Daqi Cao, Jingyi Jin, Qunhui Wang, Xin Song, Xiaodi Hao, Eiji Iritani, Nobuyuki Katagiri. Ultrafiltration recovery of alginate: Membrane fouling mitigation by multivalent metal ions and properties of recycled materials[J]. 中国化学工程学报, 2020, 28(11): 2881-2889.
[6]	Hao Yang, Hong Wu, Fusheng Pan, Meidi Wang, Zhongyi Jiang, Qifan Cheng, Cheng Huang. Water-selective hybrid membranes with improved interfacial compatibility from mussel-inspired dopamine-modified alginate and covalent organic frameworks[J]. 中国化学工程学报, 2020, 28(1): 90-97.
[7]	Suchith Chellappan, Vaishakh Nair, Sajith V., Aparna K. . Synthesis, optimization and characterization of biochar based catalyst from sawdust for simultaneous esterification and transesterification[J]. Chinese Journal of Chemical Engineering, 2018, 26(12): 2654-2663.
[8]	Himanshu Kaul, Yiannis Ventikos, Zhanfeng Cui. A computational analysis of the impact of mass transport and shear on three-dimensional stem cell cultures in perfused micro-bioreactors[J]. Chinese Journal of Chemical Engineering, 2016, 24(1): 163-174.
[9]	Evangeline Christina, Pragasam Viswanathan. Development of a novel nano-biosorbent for the removal of fluoride from water[J]. Chinese Journal of Chemical Engineering, 2015, 23(6): 924-933.
[10]	芮征球, 李全国, 崔群, 王海燕, 陈海军, 姚虎卿. Adsorption Refrigeration Performance of Shaped MIL-101-Water Working Pair[J]. Chinese Journal of Chemical Engineering, 2014, 22(5): 570-575.
[11]	朱娅群, 王志, 张晨昕, 王纪孝, 王世昌. A Novel Membrane Prepared from Sodium Alginate Cross-linked with Sodium Tartrate for CO₂ Capture[J]. Chinese Journal of Chemical Engineering, 2013, 21(10): 1098-1105.
[12]	唐煌, 李强, 王泽龙, 闫道江, 邢建民. Simultaneous Removal of Thiophene and Dibenzothiophene by Immobilized Pseudomonas delafieldii R-8 cells[J]. , 2012, 20(1): 47-51.
[13]	霍亚坤, 丁文明, 黄霞, 徐静年, 赵梦华. Fluoride Removal by Lanthanum Alginate Bead: Adsorbent Characterization and Adsorption Mechanism[J]. , 2011, 19(3): 365-370.
[14]	张迪, 张鹏远, 邹海魁, 初广文, 毋伟, 朱忠武, 邵磊, 陈建峰. Synthesis of Petroleum Sulfonate Surfactant by Different Sulfonating Agent with Application of HIGEE Technology[J]. , 2010, 18(5): 848-855.
[15]	高继贤, 王铁峰, 舒庆, 山尼, 温倩, 王德峥, 王金福. An Adsorption Kinetic Model for Sulfur Dioxide Adsorption by ZL50 Activated Carbon[J]. , 2010, 18(2): 223-230.