Co-pyrolysis of soybean soapstock with iron slag/aluminum scrap, and characterization and analysis of their products

doi:10.1016/j.cjche.2022.01.026

中国化学工程学报 ›› 2023, Vol. 53 ›› Issue (1): 25-36.DOI: 10.1016/j.cjche.2022.01.026

• Full Length Article • 上一篇下一篇

Co-pyrolysis of soybean soapstock with iron slag/aluminum scrap, and characterization and analysis of their products

Xueguang Li, Mengyan Yu, Changfa Zhang, Xiangtong Li, Guangqing Liu, Jianjun Dai, Chunbao Zhou, Yang Liu, Jie Fu, Yingwen Zhang, Bang Yao

State Key Laboratory of Organic-Inorganic Composites, College of Chemical Engineering, Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, China

收稿日期:2021-12-18 修回日期:2022-01-25 出版日期:2023-01-28 发布日期:2023-04-08
通讯作者: Guangqing Liu,E-mail:gqliu@mail.buct.edu.cn;Jianjun Dai,E-mail:jjdai@mail.buct.edu.cn
基金资助:
This work was supported by China-Central and Eastern Europe Universities Joint Education Project (2021128).

Co-pyrolysis of soybean soapstock with iron slag/aluminum scrap, and characterization and analysis of their products

Xueguang Li, Mengyan Yu, Changfa Zhang, Xiangtong Li, Guangqing Liu, Jianjun Dai, Chunbao Zhou, Yang Liu, Jie Fu, Yingwen Zhang, Bang Yao

State Key Laboratory of Organic-Inorganic Composites, College of Chemical Engineering, Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, China

Received:2021-12-18 Revised:2022-01-25 Online:2023-01-28 Published:2023-04-08
Contact: Guangqing Liu,E-mail:gqliu@mail.buct.edu.cn;Jianjun Dai,E-mail:jjdai@mail.buct.edu.cn
Supported by:
This work was supported by China-Central and Eastern Europe Universities Joint Education Project (2021128).

摘要/Abstract

摘要： Soybean soapstock (SS) is one of the main solid wastes produced in the refinery of edible oil processing. In this study, the co-pyrolysis of SS with iron slag (IS) and aluminum scrap (AS) was carried out in a tubular furnace. The gas, liquid and solid products were characterized and the char yield decreased with increasing IS/AS ratio. IS and AS can improve the gas yield, and when the ratio of SS/IS was 1:0.25, the total pyrolysis gas and hydrogen contents were significantly increased. The content of oxygen compounds in pyrolysis oil decreased during co-pyrolysis, while AS promoted the content of polycyclic aromatic hydrocarbons in pyrolysis oil. The co-pyrolysis reaction can be divided into four stages, the mass loss rate reaches the maximum at the third stage (390–575 ℃). The molar ratio of H/C was lower for pyrolysis, indicating good stability of pyrolysis char owing to the high degree of carbonization and aromaticity. The possible co-pyrolysis reaction mechanism was explored.

关键词: Pyrolysis, Soybean soapstock, Iron slag, Aluminum scrap, Adsorption, Catalyst

Abstract: Soybean soapstock (SS) is one of the main solid wastes produced in the refinery of edible oil processing. In this study, the co-pyrolysis of SS with iron slag (IS) and aluminum scrap (AS) was carried out in a tubular furnace. The gas, liquid and solid products were characterized and the char yield decreased with increasing IS/AS ratio. IS and AS can improve the gas yield, and when the ratio of SS/IS was 1:0.25, the total pyrolysis gas and hydrogen contents were significantly increased. The content of oxygen compounds in pyrolysis oil decreased during co-pyrolysis, while AS promoted the content of polycyclic aromatic hydrocarbons in pyrolysis oil. The co-pyrolysis reaction can be divided into four stages, the mass loss rate reaches the maximum at the third stage (390–575 ℃). The molar ratio of H/C was lower for pyrolysis, indicating good stability of pyrolysis char owing to the high degree of carbonization and aromaticity. The possible co-pyrolysis reaction mechanism was explored.

Key words: Pyrolysis, Soybean soapstock, Iron slag, Aluminum scrap, Adsorption, Catalyst

Xueguang Li, Mengyan Yu, Changfa Zhang, Xiangtong Li, Guangqing Liu, Jianjun Dai, Chunbao Zhou, Yang Liu, Jie Fu, Yingwen Zhang, Bang Yao. Co-pyrolysis of soybean soapstock with iron slag/aluminum scrap, and characterization and analysis of their products[J]. 中国化学工程学报, 2023, 53(1): 25-36.

参考文献

[1] Y.P. Wang, L. Jiang, L.L. Dai, Z.T. Yu, Y.H. Liu, R. Ruan, G.M. Fu, Y. Zhou, L.L. Fan, D.L. Duan, Y.F. Zhao, Microwave-assisted catalytic co-pyrolysis of soybean straw and soapstock for bio-oil production using SiC ceramic foam catalyst, J. Anal. Appl. Pyrolysis 133 (2018) 76–81.
[2] Y.P. Wang, L.Y. Ke, Y.J. Peng, Q. Yang, Z.Y. Du, L.L. Dai, N. Zhou, Y.H. Liu, G.M. Fu, R. Ruan, D.H. Xia, L. Jiang, Characteristics of the catalytic fast pyrolysis of vegetable oil soapstock for hydrocarbon-rich fuel, Energy Convers. Manag. 213 (2020) 112860.
[3] H.V. Ly, Q.K. Tran, S.S. Kim, J. Kim, S.S. Choi, C. Oh, Catalytic upgrade for pyrolysis of food waste in a bubbling fluidized-bed reactor, Environ. Pollut. 275 (2021) 116023.
[4] A.B. Fadhil, B.A. Kareem, Co-pyrolysis of mixed date pits and olive stones: Identification of bio-oil and the production of activated carbon from bio-char, J. Anal. Appl. Pyrolysis 158 (2021) 105249.
[5] L.L. Dai, L.L. Fan, Y.H. Liu, R. Ruan, Y.P. Wang, Y. Zhou, Y.F. Zhao, Z.T. Yu, Production of bio-oil and biochar from soapstock via microwave-assisted co-catalytic fast pyrolysis, Bioresour Technol 225 (2017) 1–8.
[6] Q. Tang, Y.Y. Zheng, T. Liu, X.H. Ma, Y.H. Liao, J.F. Wang, Influence of vacuum pressure on the vacuum pyrolysis of plant oil asphalt to pyrolytic biodiesel, Chem. Eng. J. 207-208 (2012) 2–9.
[7] Y.Y. Wang, X.J. Cao, Enzymatic synthesis of fatty acid ethyl esters by utilizing camellia oil soapstocks and diethyl carbonate, Bioresour. Technol. 102 (22) (2011) 10173–10179.
[8] D. Soares, A.F. Pinto, A.G. Gonçalves, D.A. Mitchell, N. Krieger, Biodiesel production from soybean soapstock acid oil by hydrolysis in subcritical water followed by lipase-catalyzed esterification using a fermented solid in a packed-bed reactor, Biochem. Eng. J. 81 (2013) 15–23.
[9] P. Daisuk, A. Shotipruk, Recovery of γ-oryzanol from rice bran oil soapstock derived calcium soap: Consideration of Hansen solubility parameters and preferential extractability in various solvents, LWT 134 (2020) 110238.
[10] F. Guo, Z.L. Xiu, Z.X. Liang, Synthesis of biodiesel from acidified soybean soapstock using a lignin-derived carbonaceous catalyst, Appl. Energy 98 (2012) 47–52.
[11] L.L. Dai, L.L. Fan, D.L. Duan, R. Ruan, Y.P. Wang, Y.H. Liu, Y. Zhou, Y.F. Zhao, Z.T. Yu, Microwave-assisted catalytic fast co-pyrolysis of soapstock and waste tire for bio-oil production, J. Anal. Appl. Pyrolysis 125 (2017) 304–309.
[12] S.K. Verma, V.K. Dwivedi, S.P. Dwivedi, Utilization of aluminium dross for the development of valuable product - A review, Mater. Today Proc. 43 (2021) 547–550.
[13] L. Santamaría, M. López-Aizpún, M. García-Padial, M.A. Vicente, S.A. Korili, A. Gil, Zn-Ti-Al layered double hydroxides synthesized from aluminum saline slag wastes as efficient drug adsorbents, Appl. Clay Sci. 187 (2020) 105486.
[14] T.T. Wen, L.Y. Yang, C.Y. Dang, T. Miki, H. Bai, T. Nagasaka, Effect of basic oxygen furnace slag on succession of the bacterial community and immobilization of various metal ions in acidic contaminated mine soil, J. Hazard. Mater. 388 (2020) 121784.
[15] L.Y. Yang, T.C. Wei, S.W. Li, Y. Lv, T. Miki, L.B. Yang, T. Nagasaka, Immobilization persistence of Cu, Cr, Pb, Zn ions by the addition of steel slag in acidic contaminated mine soil, J Hazard Mater 412 (2021) 125176.
[16] P. Sarfo, A. Das, G. Wyss, C. Young, Recovery of metal values from copper slag and reuse of residual secondary slag, Waste Manag 70 (2017) 272–281.
[17] P. Liu, L. Liu, Z.Z. Zhou, Y.L. Li, H.R. Yuan, Huhetaoli, T.Z. Lei, Co-pyrolysis of pine sawdust with aluminum dross for immobilization of heavy metal and enhancing hydrogen generation, Fuel 305 (2021) 121597.
[18] Q. Song, H.Y. Zhao, J.W. Jia, F. Zhang, Z.P. Wang, W. Lv, L. Yang, W. Zhang, Y. Zhang, X.Q. Shu, Characterization of the products obtained by pyrolysis of oil sludge with steel slag in a continuous pyrolysis-magnetic separation reactor, Fuel 255 (2019) 115711.
[19] F.Q. Guo, S. Liang, X.M. Zhao, X.P. Jia, K.Y. Peng, X.C. Jiang, L. Qian, Catalytic reforming of biomass pyrolysis tar using the low-cost steel slag as catalyst, Energy 189 (2019) 116161.
[20] K.G. Wang, R.C. Brown, S. Homsy, L. Martinez, S.S. Sidhu, Fast pyrolysis of microalgae remnants in a fluidized bed reactor for bio-oil and biochar production, Bioresour Technol 127 (2013) 494–499.
[21] Y. Liu, C.M. Ran, A.A. Siyal, Y.M. Song, Z.H. Jiang, J.J. Dai, P. Chtaeva, J. Fu, W.Y. Ao, Z.Y. Deng, T.H. Zhang, Comparative study for fluidized bed pyrolysis of textile dyeing sludge and municipal sewage sludge, J Hazard Mater 396 (2020) 122619.
[22] H.V. Ly, S.S. Kim, J.H. Choi, H.C. Woo, J. Kim, Fast pyrolysis of Saccharina japonica alga in a fixed-bed reactor for bio-oil production, Energy Convers. Manag. 122 (2016) 526–534.
[23] Y.P. Wang, Q.H. Wu, S. Yang, Q. Yang, J.L. Wu, Z.Y. Ma, L. Jiang, Z.T. Yu, L.L. Dai, Y.H. Liu, R. Ruan, G.M. Fu, B. Zhang, H.B. Zhu, Microwave-assisted catalytic fast pyrolysis coupled with microwave-absorbent of soapstock for bio-oil in a downdraft reactor, Energy Convers. Manag. 185 (2019) 11–20.
[24] N.M.T. Al-Layla, L.A. Saleh, A.B. Fadhil, Liquid bio-fuels and carbon adsorbents production via pyrolysis of non-edible feedstock, J. Anal. Appl. Pyrolysis 156 (2021) 105088.
[25] G. Kabir, A.T. Mohd Din, B.H. Hameed, Pyrolysis of oil palm mesocarp fiber catalyzed with steel slag-derived zeolite for bio-oil production, Bioresour. Technol. 249 (2018) 42–48.
[26] M. Mana, M.S. Ouali, L.C. de Menorval, Removal of basic dyes from aqueous solutions with a treated spent bleaching earth, J Colloid Interface Sci 307 (1) (2007) 9–16.
[27] C. Yuan, Q. Liu, P.J. Li, B. Barati, K. Viswanathan, S. Zhao, S. Wang, B. Cao, Y.M. Hu, Biofuel characteristic of waste clay oil pyrolysis, J. Anal. Appl. Pyrolysis 156 (2021) 105117.
[28] Y.P. Wang, Q.H. Wu, L.L. Dai, Z.H. Zeng, Y.H. Liu, R. Ruan, G.M. Fu, Z.T. Yu, L. Jiang, Co-pyrolysis of wet torrefied bamboo sawdust and soapstock, J. Anal. Appl. Pyrolysis 132 (2018) 211–216.
[29] W.D.C. Udayanga, A. Veksha, A. Giannis, T.T. Lim, Pyrolysis derived char from municipal and industrial sludge: Impact of organic decomposition and inorganic accumulation on the fuel characteristics of char, Waste Manag 83 (2019) 131–141.
[30] Y. Liu, Y.M. Song, T.H. Zhang, Z.H. Jiang, A.A. Siyal, J.J. Dai, J. Fu, C.B. Zhou, L. Wang, X.T. Li, W.Y. Ao, X.X. Jin, D.Y. Teng, J. Fang, Microwave-assisted pyrolysis of oily sludge from offshore oilfield for recovery of high-quality products, J Hazard Mater 420 (2021) 126578.
[31] Y. Liu, C.M. Ran, A.R. Siddiqui, A.A. Siyal, Y.M. Song, J.J. Dai, P. Chtaeva, J. Fu, W.Y. Ao, Z.Y. Deng, Z.H. Jiang, T.H. Zhang, Characterization and analysis of sludge char prepared from bench-scale fluidized bed pyrolysis of sewage sludge, Energy 200 (2020) 117398.
[32] Y. Liu, C.M. Ran, A.R. Siddiqui, X. Mao, Q.H. Kang, J. Fu, Z.Y. Deng, Y.M. Song, Z.H. Jiang, T.H. Zhang, J.J. Dai, Pyrolysis of textile dyeing sludge in fluidized bed and microwave-assisted auger reactor: Comparison and characterization of pyrolysis products, J Hazard Mater 359 (2018) 454–464.
[33] C.M. Ran, Y. Liu, A.R. Siddiqui, A.A. Siyal, X. Mao, Q.H. Kang, J. Fu, W.Y. Ao, J.J. Dai, Pyrolysis of textile dyeing sludge in fluidized bed and microwave-assisted auger reactor: Comparison, migration and distribution of heavy metals, Energy 182 (2019) 337–348.
[34] C.M. Ran, Y. Liu, A.R. Siddiqui, A.A. Siyal, X. Mao, Q.H. Kang, J. Fu, W.Y. Ao, J.J. Dai, Pyrolysis of textile dyeing sludge in fluidized bed: Analysis of products, and migration and distribution of heavy metals, J. Clean. Prod. 241 (2019) 118308.
[35] W. Qian, X.Z. Li, J. Zhou, Y.X. Liu, Z.P. Wu, High synergistic effects of natural-based tea saponin in intumescent flame-retardant coatings for enhancement of flame retardancy and pyrolysis performance, Prog. Org. Coat. 127 (2019) 408–418.
[36] S.W. Zhou, Y.G. Wei, B. Li, H. Wang, Cleaner recycling of iron from waste copper slag by using walnut shell char as green reductant, J. Clean. Prod. 217 (2019) 423–431.
[37] L. Zhao, X.D. Cao, O. Mašek, A. Zimmerman, Heterogeneity of biochar properties as a function of feedstock sources and production temperatures, J. Hazard. Mater. 256-257 (2013) 1–9.
[38] Y. Liu, Y.M. Song, C.M. Ran, A.A. Siyal, P. Chtaeva, J.J. Dai, Z.H. Jiang, Z.Y. Deng, T.H. Zhang, W.Y. Ao, J. Fu, Pyrolysis of furfural residue in a bubbling fluidized bed reactor: Biochar characterization and analysis, Energy 211 (2020) 118966.
[39] C.L. Liu, Y.L. Wang, J.P. Xia, L.L. Zhou, W.X. Zhang, Z.F. Zhang, Synthesis optimization and characterization of a novel zeolite produced from coal fly ash by hydrothermal reaction in alkaline solution, Energy Sources A Recovery Util. Environ. Eff. (2021) 1–12.
[40] H.D. Zhang, Z.P. Gao, W.Y. Ao, J. Li, G.Q. Liu, J. Fu, C.M. Ran, X. Mao, Q.H. Kang, Y. Liu, J.J. Dai, Microwave pyrolysis of textile dyeing sludge in a continuously operated auger reactor: Char characterization and analysis, J Hazard Mater 334 (2017) 112–120.
[41] X.H. Yang, Y.J. Peng, Y.P. Wang, L. Jiang, S.M. Zhang, Q.H. Wu, X.J. Tian, Z.H. Zeng, L.L. Dai, L.Q. Yue, L.Y. Ke, Y.H. Liu, R. Ruan, Conversion of soybean soapstock into hydrocarbon fuel by microwave-assisted catalytic fast pyrolysis using MCM-41/HZSM-5 in a downdraft reactor, Chem. Eng. Process. Process. Intensif. 156 (2020) 108109.
[42] J.J. Zhang, B. Fidalgo, A. Kolios, D.K. Shen, S. Gu, Mechanism of deoxygenation in anisole decomposition over single-metal loaded HZSM-5: Experimental study, Chem. Eng. J. 336 (2018) 211–222.
[43] J.M. Xu, F. Long, J.C. Jiang, F.L. Li, Q.L. Zhai, F. Wang, P. Liu, J. Li, Integrated catalytic conversion of waste triglycerides to liquid hydrocarbons for aviation biofuels, J. Clean. Prod. 222 (2019) 784–792.
[44] R.F. Beims, V. Botton, L. Ender, D.R. Scharf, E.L. Simionatto, H.F. Meier, V.R. Wiggers, Effect of degree of triglyceride unsaturation on aromatics content in bio-oil, Fuel 217 (2018) 175–184.
[45] F.J. Chen, F.X. Zhang, S.L. Yang, H.L. Liu, H. Wang, J.H. Hu, Investigation of pyrolysis kinetics, thermodynamics, product characteristics and reaction mechanism of rubber seed oil, Energy Convers. Manag. 244 (2021) 114535.
[46] R.O. Idem, S.P.R. Katikaneni, N.N. Bakhshi, Thermal cracking of canola oil: Reaction products in the presence and absence of steam, Energy Fuels 10 (6) (1996) 1150–1162.

Co-pyrolysis of soybean soapstock with iron slag/aluminum scrap, and characterization and analysis of their products

Co-pyrolysis of soybean soapstock with iron slag/aluminum scrap, and characterization and analysis of their products

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	Yingli Li, Zhishuncheng Li, Guangfei Qu, Rui Li, Shuaiyu Liang, Junhong Zhou, Wei Ji, Huiming Tang. Mechanism, behaviour and application of iron nitrate modified carbon nanotube composites for the adsorption of arsenic in aqueous solutions[J]. 中国化学工程学报, 2023, 60(8): 26-36.
[2]	Jinlong Liu, Chenye Wang, Xingrui Wang, Chen Zhao, Huiquan Li, Ganyu Zhu, Jianbo Zhang. Reconstruction and recovery of anatase TiO₂ from spent selective catalytic reduction catalyst by NaOH hydrothermal method[J]. 中国化学工程学报, 2023, 60(8): 53-60.
[3]	Jing Huang, Honghui Cai, Qian Zhao, Yunpeng Zhou, Haibo Liu, Jing Wang. Dual-functional pyrene implemented mesoporous silicon material used for the detection and adsorption of metal ions[J]. 中国化学工程学报, 2023, 60(8): 108-117.
[4]	Yifan Jiang, Bingqi Xie, Jisong Zhang. Highly reactive and reusable heterogeneous activated carbons-based palladium catalysts for Suzuki-Miyaura reaction[J]. 中国化学工程学报, 2023, 60(8): 165-172.
[5]	Peipei Ai, Huiqing Jin, Jie Li, Xiaodong Wang, Wei Huang. Ultra-stable Cu-based catalyst for dimethyl oxalate hydrogenation to ethylene glycol[J]. 中国化学工程学报, 2023, 60(8): 186-193.
[6]	Lingli Chen, Yueting Shi, Sijun Xu, Junle Xiong, Fang Gao, Shengtao Zhang, Hongru Li. Enhanced adsorption of target branched compounds including antibiotic norfloxacin frameworks on mild steel surface for efficient protection: An experimental and molecular modelling study[J]. 中国化学工程学报, 2023, 60(8): 212-227.
[7]	Alexander Nti Kani, Evans Dovi, Aaron Albert Aryee, Runping Han, Zhaohui Li, Lingbo Qu. Mechanisms and reusability potentials of zirconium-polyaziridine-engineered tiger nut residue towards anionic pollutants[J]. 中国化学工程学报, 2023, 60(8): 275-292.
[8]	Yuehua Liu, Lili Chen, Shoujun Liu, Song Yang, Ju Shangguan. Role of iron-based catalysts in reducing NO_x emissions from coal combustion[J]. 中国化学工程学报, 2023, 59(7): 1-8.
[9]	Yuan Liu, Hanting Xiong, Jingwen Chen, Shixia Chen, Zhenyu Zhou, Zheling Zeng, Shuguang Deng, Jun Wang. One-step ethylene separation from ternary C₂ hydrocarbon mixture with a robust zirconium metal-organic framework[J]. 中国化学工程学报, 2023, 59(7): 9-15.
[10]	Hui Jiang, Zijian Zhao, Ning Yu, Yi Qin, Zhengwei Luo, Wenhua Geng, Jianliang Zhu. Synthesis, characterization, and performance comparison of boron using adsorbents based on N-methyl-D-glucosamine[J]. 中国化学工程学报, 2023, 59(7): 16-31.
[11]	Fei Li, Xuemei Wang, Pengze Zhang, Qinqin Wang, Mingyuan Zhu, Bin Dai. Nitrogen and phosphorus co-doped activated carbon induces high density Cu⁺ active center for acetylene hydrochlorination[J]. 中国化学工程学报, 2023, 59(7): 193-199.
[12]	Runze Chen, Yuran Chen, Xuemin Liang, Yapeng Kong, Yangyang Fan, Quan Liu, Zhenyu Yang, Feiying Tang, Johnny Muya Chabu, Maru Dessie Walle, Liqiang Wang. Oxidative exfoliation of spent cathode carbon: A two-in-one strategy for its decontamination and high-valued application[J]. 中国化学工程学报, 2023, 59(7): 262-269.
[13]	Wei Wang, Romain Lemaire, Ammar Bensakhria, Denis Luart. Thermogravimetric analysis and kinetic modeling of the co-pyrolysis of a bituminous coal and poplar wood[J]. 中国化学工程学报, 2023, 58(6): 53-68.
[14]	Qunfeng Zhang, Bingcheng Li, Yuan Zhou, Deshuo Zhang, Chunshan Lu, Feng Feng, Jinghui Lv, Qingtao Wang, Xiaonian Li. Regulation of the selective hydrogenation performance of sulfur-doped carbon-supported palladium on chloronitrobenzene[J]. 中国化学工程学报, 2023, 58(6): 69-75.
[15]	Shanghong Ma, Haitao Zhang, Jianbo Qu, Xiuzhong Zhu, Qingfei Hu, Jianyong Wang, Peng Ye, Futao Sai, Shiwei Chen. Preparation of waterborne polyurethane/β-cyclodextrin composite nanosponge by ion condensation method and its application in removing of dyes from wastewater[J]. 中国化学工程学报, 2023, 58(6): 124-136.