The Role of Diatomite Particles in the Activated Sludge System for Treating Coal Gasification Wastewater

摘要/Abstract

摘要： Diatomite is a kind of natural low-cost mineral material.It has a number of unique physical properties and has been widely used as an adsorbent in wastewater treatment.This study was conducted to investigate the aerobic biodegradation of coal gasification wastewater with and without diatomite addition.Experimental results indicated that diatomite added in the activated sludge system could promote the biomass and also enhance the performance of the sludge settling.The average mixed-liquor volatile suspended solids(MLVSS) is increased from 4055 mg·L^-1 to 4518 mg·L^-1 and the average settling volume(SV) are changed only from 45.9% to 47.1%.Diatomite additive could enhance the efficiency of chemical oxygen demand(COD) and total phenols removal from the wastewater.The COD removal increased from 73.3% to near 80% and the total phenols removal increased from 81.4% to 85.8%.The mechanisms of the increase of biomass and pollutants removal may correlates to the improvement of bioavailability and sludge settlement characteristics by diatomite added.Micrograph of the sludge in the diatomite-activated sludge system indicated that the diatomite added could be the carrier of the microbe and also affect the biomass and pollutant removal.

关键词: diatomite, phenols, coal gasification wastewater, activated sludge

Abstract: Diatomite is a kind of natural low-cost mineral material.It has a number of unique physical properties and has been widely used as an adsorbent in wastewater treatment.This study was conducted to investigate the aerobic biodegradation of coal gasification wastewater with and without diatomite addition.Experimental results indicated that diatomite added in the activated sludge system could promote the biomass and also enhance the performance of the sludge settling.The average mixed-liquor volatile suspended solids(MLVSS) is increased from 4055 mg·L^-1 to 4518 mg·L^-1 and the average settling volume(SV) are changed only from 45.9% to 47.1%.Diatomite additive could enhance the efficiency of chemical oxygen demand(COD) and total phenols removal from the wastewater.The COD removal increased from 73.3% to near 80% and the total phenols removal increased from 81.4% to 85.8%.The mechanisms of the increase of biomass and pollutants removal may correlates to the improvement of bioavailability and sludge settlement characteristics by diatomite added.Micrograph of the sludge in the diatomite-activated sludge system indicated that the diatomite added could be the carrier of the microbe and also affect the biomass and pollutant removal.

Key words: diatomite, phenols, coal gasification wastewater, activated sludge

张文启, 饶品华, 张辉, 徐菁利. The Role of Diatomite Particles in the Activated Sludge System for Treating Coal Gasification Wastewater[J]. , 2009, 17(1): 167-170.

ZHANG Wenqi, RAO Pinhua, ZHANG Hui, XU Jingli. The Role of Diatomite Particles in the Activated Sludge System for Treating Coal Gasification Wastewater[J]. , 2009, 17(1): 167-170.

参考文献

1 Suidan, M.T., Strubler, C.E., Kao, S.W., “Treatment of coal gasification wastewater with anaerobic filter technology”, J. WPCF, 55,1263-1270 (1983).
2 Luthy, R.G., Tallon, J.T., “Biological treatment of hygas coal gasification wastewater”, Water Research, 14, 1269-1275 (1980).
3 Yu, H.Q., Gu, G.W., Song, L.P., “Post-treatment of effluent from coke-plant wastewater treatment system in sequencing batch reactors”, J. Env. Eng., 123, 305-308 (1997).
4 Lee, M.W., Park, J.M., “Biological nitrogen removal from coke plant wastewater with external carbon addition”, Water Env. Res., 70,1090-1095 (1998).
5 Sublette, K.L., Snider, E.H., Sylvester, N.D., “A review of the mechanism of powdered activated carbon enhancement of activated sludge treatment”, Water Research, 16, 1075-1082 (1982).
6 Specchia, V., Ruggeri, B., Gianetto , A., “Mechanisms of activated carbon bio-removal”, Chem. Eng. Commun., 68, 99-117 (1988).
7 Marquez, M.C., Costa, C., “Biomass concentration in PACT process”, Water Research, 30, 2079-2085 (1996).
8 Pala, A., Tokat, E., “Color removal from cotton textile industry wastewater in an activated sludge system with various additives”, Water Research, 36, 2920-2925 (2002).
9 Al-Degs, Y., Khraisheh, M.A.M., Tutunji, M.F., “Sorption of lead ions on diatomite and manganese oxides modified diatomite”, Water Research, 35, 3724-3728 (2001).
10 Srinivasan, K.R., Fogler, S.H., “Use of inorgano-organo clays in the removal of priority pollutants from industrial wastewaters”, Clay and Clay Minerals, 38, 227-286 (1990).
11 Cho, B.H., Chino, H., Tsuji, H., Kunito, T., Nagaoka, K., Otsuka, S., Yamashita, L., Matsumoto S., Oyaizu, H., “Laboratory-scale bioremediation of oil contaminated soil of Kuwait with soil amendment materials”, Chemosphere, 35, 1599-1611 (1997).
12 Vieira, M.J., Melo, L.F., “Effect of clay particles on the behaviour of bio-films formed by pseudomonas fluorescens”, Water Sci. Technol.,32, 45-52 (1995).
13 Pereira, M.O., Vieira, M.J., Melo, L.F., “The role of kaolin particles in the performance of a carbamate-based biocide for water bacterial control”, Water Environ. Res., 74, 235-241 (2002).
14 Erdem, E.,Cölge en, G., Donat, R., “The removal of textile dyes by diatomite earth”, J. Colloid Interface Sci., 282, 314-319 (2005).
15 Osmanlioglu, A.E., “Natural diatomite process for removal of radioactivity from liquid waste”, Appl. Radiation and Isotopes, 65, 17-20 (2007).
16 Jang, M., Min, S.H., Kim, T.H., Park, J.K., “Removal of arsenite and arsenate using hydrous ferric oxide incorporated into naturally occurring porous diatomite”, Environ. Sci. Technol., 40, 1636-1643 (2006).
17 Wu, J.L., Yang, Y.S., Lin, J.H., “Advanced tertiary treatment of municipal wastewater using raw and modified diatomite”, J. Hazard. Mater., 127, 196-203 (2005).
18 Zhang, W.Q., Ma, J., Yang, S.D., Zhang, T., Li, Y.F., “Pretreatment of coal gasification wastewater by acidification demulsion”, Chin. J. Chem. Eng., 14, 398-401 (2006).
19 Al-Ghouti, M.A., Khraisheh, M.A.M., Allen, S.J., Ahmad, M.N., “The removal of dyes from textile wastewater: A study of the physical characteristics and adsorption mechanisms of diatomaceous earth”, J. Environ. Manag., 69, 229-238 (2003).
20 Pollock, J., “Treatment of contaminated soils”, WO Pat., 00129 (1997).
21 Zhao, Y., Cao, D., Liu, L., Jin, W., “Municipal wastewaterwater treatment by moving bed-biofilm reactor with diatomaceous earth as carriers”, Water Environ. Res., 78, 392-396 (2006).
22 Jin, W., Zhao, Y.P., Xu, Z.X., Gao, T.Y., “Treatment of municipal wastewater using combined bio-diatomaceous earth”, J. Tongji Univ. Nat. Sci., 33, 1626-1629 (2005).
23 Spain, J.C., Van Veld, P., Monti, C.A., Pritchard, P.H., Cripe, C.R., “Comparison of p-nitro-phenol biodegradation in field and laboratory test systems”, Appl. Environ. Microbiol., 48, 944-950 (1984).
24 Guerin, W.F., Boyd, S.A., “Diffrential bioavailability of soil-sorbed naphthalene to two bacterial species”, Appl. Environ. Microbiol., 58,1142-1152 (1992).
25 Laorl, Y., Strom, P.F., Farmer, W.J., “Bioavailability of enanthrene sorbed to mineral-associated humic acid”, Wat. Res., 33, 1719-1729 (1999).
26 Zhang, W.Q., Ma, J., Zhang, L.Q., Qiu, L.P., “Effects of diatomite additives on coal gasification wastewater treatment”, Modern Chemical Industry, 25, 154-157 (2005). (in Chinese)
27 Widjaja, T., Miyata, T., Nakano, Y., Nishijima, W., Okada, M., “Adsorption capacity of powdered activated carbon for 3,5-dichlorophenol in activated sludge”, Chemosphere, 57, 1219-1224 (2004).

[1]	Lijian Shi, Yaping Zhang, Yujia Tong, Wenlong Ding, Weixing Li. Plant-inspired biomimetic hybrid PVDF membrane co-deposited by tea polyphenols and 3-amino-propyl-triethoxysilane for high-efficiency oil-in-water emulsion separation[J]. 中国化学工程学报, 2023, 53(1): 170-180.
[2]	Hui Huang, Lulu Lei, Juan Bai, Ling Zhang, Donghui Song, Jingqi Zhao, Jiali Li, Yongxin Li. Efficient elimination and detection of phenolic compounds in juice using laccase mimicking nanozymes[J]. 中国化学工程学报, 2021, 29(1): 167-175.
[3]	Hengjun Gai, Shuo Chen, Kaiqiang Lin, Xiaowei Zhang, Chun Wang, Meng Xiao, Tingting Huang, Hongbing Song. Conceptual design of energy-saving stripping process for industrial sour water[J]. 中国化学工程学报, 2020, 28(5): 1277-1284.
[4]	Shaoqing Zhang, Tianming Lv, Yang Mu, Jiqi Zheng, Changgong Meng. High adsorption of Cd (II) by modification of synthetic zeolites Y, A and mordenite with thiourea[J]. 中国化学工程学报, 2020, 28(12): 3117-3125.
[5]	Bijan Bina, Farzaneh Mohammadi, Mohammad Mehdi Amin, Hamid Reza Pourzamani, Zeynab Yavari. Evaluation of the effects of AlkylPhenolic compounds on kinetic coefficients and biomass activity in MBBR by means of respirometric techniques[J]. Chinese Journal of Chemical Engineering, 2018, 26(4): 822-829.
[6]	Carlos Eduardo de Araújo Padilha, Juliana Chris Silva de Azevedo, Francisco Canindé de Sousa Júnior, Sérgio Dantas de Oliveira Júnior, Domingos Fabiano de Santana Souza, Jackson Araújo de Oliveira, Gorete Ribeiro de Macedo, Everaldo Silvino dos Santos. Recovery of polyphenols from camu-camu (Myrciaria dubia H.B.K. McVaugh) depulping residue by cloud point extraction[J]. Chinese Journal of Chemical Engineering, 2018, 26(12): 2471-2476.
[7]	Bijan Bina, Farzaneh Mohammadi, Mohammad Mehdi Amin, Hamid Reza Pourzamani, Zeynab Yavari. Determination of 4-nonylphenol and 4-tert-octylphenol compounds in various types of wastewater and their removal rates in different treatment processes in nine wastewater treatment plants of Iran[J]. Chinese Journal of Chemical Engineering, 2018, 26(1): 183-190.
[8]	Alexandros D. Kotzapetros, Panayotis A. Paraskevas, Athanasios S. Stasinakis. Design of a modern automatic control system for the activated sludge process in wastewater treatment[J]. Chinese Journal of Chemical Engineering, 2015, 23(8): 1340-1349.
[9]	Qin Lu, Haiyan Wu, Haoyan Li, Dianhai Yang. Enhanced biological nutrient removal inmodified carbon source division anaerobic anoxic oxic process with return activated sludge pre-concentration[J]. Chinese Journal of Chemical Engineering, 2015, 23(6): 1027-1034.
[10]	Xianli Shi, Li Deng, Fangfang Sun, Jieyu Liang, Xu Deng. Key factors governing alkaline pretreatment of waste activated sludge[J]. Chinese Journal of Chemical Engineering, 2015, 23(5): 842-846.
[11]	Edward Modiba, Christopher Enweremadu, Hilary Rutto. Production of biodiesel from waste vegetable oil using impregnated diatomite as heterogeneous catalyst[J]. Chinese Journal of Chemical Engineering, 2015, 23(1): 281-289.
[12]	张光明, 万甜, 高峰, 董姗. Impacts of Power Density on Heavy Metal Release During Ultrasonic Sludge Treatment Process[J]. Chinese Journal of Chemical Engineering, 2014, 22(4): 469-473.
[13]	Li Jing, Fumin Zhang, Yijun Zhong, Weidong Zhu . Hydroxylation of Benzene to Phenol by H₂O₂ over an Inorganic-Organic Dual Modified Heteropolyacid[J]. , 2014, 22(11/12): 1220-1225.
[14]	Yinguang Chen, Hui Mu, Xiong Zheng. Chronic Response of Waste Activated Sludge Fermentation to Titanium Dioxide Nanoparticles[J]. , 2014, 22(10): 1162-1167.
[15]	杜高翔, 吕国诚, 何绪文. Apparent Dissolution Kinetics of Diatomite in Alkaline Solution[J]. Chinese Journal of Chemical Engineering, 2013, 21(7): 736-741.