Effect of Return Sludge Pre-concentration on Biological Phosphorus Removal in a Novel Oxidation Ditch

Chinese Journal of Chemical Engineering ›› 2012, Vol. 20 ›› Issue (4): 747-753.

Effect of Return Sludge Pre-concentration on Biological Phosphorus Removal in a Novel Oxidation Ditch

刘巍¹, 杨殿海¹, 徐立¹, 贾川¹, 卢文建¹, BOSIRE Omosa Isaiah², 沈昌明¹

1. State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Sciences and Engineering, Tongji University, Shanghai 200092, China;
2. UNEP-TONGJI Institute of Environment for Sustainable Development, College of Environmental Sciences and Engineering, Tongji University, 200092 Shanghai, China

收稿日期:2011-03-08 修回日期:2011-09-15 出版日期:2012-08-28 发布日期:2012-09-15
通讯作者: YANG Dianhai, E-mail:yangdianhai@tongji.edu.cn
基金资助:
Supported by the Major Science and Technology Program for Water Pollution Control and Treatment (2008ZX07316)

Effect of Return Sludge Pre-concentration on Biological Phosphorus Removal in a Novel Oxidation Ditch

LIU Wei¹, YANG Dianhai¹, XU Li¹, JIA Chuan¹, LU Wenjian¹, BOSIRE Omosa Isaiah², SHEN Changming¹

1. State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Sciences and Engineering, Tongji University, Shanghai 200092, China;
2. UNEP-TONGJI Institute of Environment for Sustainable Development, College of Environmental Sciences and Engineering, Tongji University, 200092 Shanghai, China

Received:2011-03-08 Revised:2011-09-15 Online:2012-08-28 Published:2012-09-15
Supported by:
Supported by the Major Science and Technology Program for Water Pollution Control and Treatment (2008ZX07316)

摘要/Abstract

摘要： A pilot-scale,pre-anoxic-anaerobic oxidation ditch was used in this study to treat municipal wastewater with limited carbon source.A novel return activated sludge(RAS) pre-concentration tank was adopted for improving the phosphorus removal efficiency and the effects of RAS preconcentration ratio were studied.Under the optimal operational condition,the suspended total phosphorus(STP) and the total phosphorus(TP) removal efficiencies were around 58.9% and 63.9% respectively and the effluent PO₄^3--P was lower than 0.8 mg·L^-1.The reason is that with the optimal RAS pre-concentration ratio,nitrate is completely removed with endogenous carbon source and the secondary phosphorus release is strictly restrained in the pre-anoxic tank.Therefore,the anaerobic phosphorus release and the carbon source uptake by phosphorus accumulation organisms(PAOs) in the sludge,which are extremely important to the phosphorus removal process,can be fully satisfied.Furthermore,the oxidation-reduction potential is proved to be suitable for controlling the RAS pre-concentration ratio due to influent fluctuation and varied conditions.The novel modified system is also beneficial for PAO accumulation.

关键词: denitrifying phosphorus removal, nitrate, oxidation ditch, phosphorus, return activated sludge pre-concentration, secondary phosphorus release

Abstract: A pilot-scale,pre-anoxic-anaerobic oxidation ditch was used in this study to treat municipal wastewater with limited carbon source.A novel return activated sludge(RAS) pre-concentration tank was adopted for improving the phosphorus removal efficiency and the effects of RAS preconcentration ratio were studied.Under the optimal operational condition,the suspended total phosphorus(STP) and the total phosphorus(TP) removal efficiencies were around 58.9% and 63.9% respectively and the effluent PO₄^3--P was lower than 0.8 mg·L^-1.The reason is that with the optimal RAS pre-concentration ratio,nitrate is completely removed with endogenous carbon source and the secondary phosphorus release is strictly restrained in the pre-anoxic tank.Therefore,the anaerobic phosphorus release and the carbon source uptake by phosphorus accumulation organisms(PAOs) in the sludge,which are extremely important to the phosphorus removal process,can be fully satisfied.Furthermore,the oxidation-reduction potential is proved to be suitable for controlling the RAS pre-concentration ratio due to influent fluctuation and varied conditions.The novel modified system is also beneficial for PAO accumulation.

Key words: denitrifying phosphorus removal, nitrate, oxidation ditch, phosphorus, return activated sludge pre-concentration, secondary phosphorus release

刘巍, 杨殿海, 徐立, 贾川, 卢文建, BOSIRE Omosa Isaiah, 沈昌明. Effect of Return Sludge Pre-concentration on Biological Phosphorus Removal in a Novel Oxidation Ditch[J]. Chinese Journal of Chemical Engineering, 2012, 20(4): 747-753.

LIU Wei, YANG Dianhai, XU Li, JIA Chuan, LU Wenjian, BOSIRE Omosa Isaiah, SHEN Changming. Effect of Return Sludge Pre-concentration on Biological Phosphorus Removal in a Novel Oxidation Ditch[J]. Chin.J.Chem.Eng., 2012, 20(4): 747-753.

参考文献

1 Kuba,T.,Wachtmeister,A.,Van Loosdrecht,M.C.M.,Keijnen,J.J., "Effect of nitrate on phosphorus release in biological phosphorus removal systems",Water Sci.Technol.,30(6),263-269(1994).
2 Boswell,C.D.,Dick,R.E.,Macaskie,L.E.,"The effect of heavy metals and other environmental conditions on the anaerobic phosphate metabolism of Acinetobacter johnsonii",Microbiology,145,1711-1720(1999).
3 Mulkerrins,D.,Dobson,A.D.W.,Colleran,E.,"Parameters affecting biological phosphate removal from wastewaters",Environ.International.,30(2),249-259(2004).
4 Oehmen,A.,Lemos,P.C.,Carvalho,G.,Yuan,Z.G.,Keller,J., Blackall,L.L.,Reis,M.A.M.,"Advances in enhanced biological phosphorus removal:From micro to macro scale",Water Res.,41 (11),2271-2300(2007).
5 Chuang,S.H.,Ouyang,C.F.,Wang,Y.B.,"Kinetic competition between phosphorus release and denitrification on sludge under anoxic condition",Water Res.,30(12),2961-2968(1996).
6 Peng,Y.Z.,Hou,H.X.,Wang,S.Y.,Cui,Y.W.,Yuan,Z.G.,"Nitrogen and phosphorus removal in pilot scale anaerobic anoxic OD system", J.Environ.Sci.China,20(4),398-403(2008).
7 Zou,H.,Du,G.C.,Ruan,W.Q.,Chen,J."Role of nitrate in biological phosphorus removal in a sequencing batch reactor",World J. Microbiol.Biotechnol.,22(7),701-706(2006).
8 Kazmi,A.A.,Fujita,M.,Furumai,H.,"Modeling effect of remaining nitrate on phosphorus removal in SBR",Water Sci.Technol.,43(3),175-182(2001).
9 Chang,C.H.,Hao,O.J.,"Sequencing batch reactor system for nutrient removal:ORP and pH profiles",J.Chem.Techno.Biotechnol.,67(1),27-38(1996).
10 Hayakawa,N.,Tsuji,J.,Hamamoto,Y.,"Simultaneous nitrogen and phosphate removal by the intermittent cyclic process",Water Sci. Technol.,18(7/8),319-326(1986).
11 Comeau,R.,Hall,K.J.,Hanock,R.E.W.,Oldham,W.K.,"Biochemical models for enhanced biological phosphorus removal",Water Res.,20(12),1511-1521(1986).
12 Chen,X.,Fujiwara,T.,Ohtoshi,K.,Inamori,S.,Nakamachi,K., Tsuno,H.,"Evaluation of a novel oxidation ditch system for biological nitrogen and phosphorus removal from domestic sewage", Water Sci.Technol.,62(8),1745-1754(2010).
13 APHA,AWWA,Standard Methods for the Examination of Water and Wastewater,19th ed.,American Public Health Association/American Water Works Association/Water Environment Federation,Washington DC(1995).
14 Randall,C.W.,Barnard,J.L.,Stensel,H.D.,Design and Retrofit of Wastewater Treatment Plants for Biological Nutrient Removal,Technomic Publishing Co.Inc.,Lanscaster,25-78(1992).
15 Kuba,T.,Van Loosdrecht,M.C.M.,Heijnen,J.J.,"Phosphorus and nitrogen removal with minimal COD requirement by integration of denitrifying dephosphatation and nitrification in a two-sludge system",Water Res.,30(7),1702-1710(1996).
16 Peng,Y.Z.,Ma,Y.,Wang,S.Y.,"Denitrification potential enhancement by addition of external carbon sources in a pre-denitrification process",J.Environ.Sci.China,19(3),284-289(2007).
17 Peng,Z.X.,Peng,Y.Z.,Gui,L.J.,Liu,X.L.,"Competition for single carbon source between denitrification and phosphorus release in sludge under anoxic condition",Chin.J.Chem.Eng.,18(3),472-477 (2010).
18 Mikola,A.,Rautiainen,J.,Vahala,R.."Secondary clarifier conditions conducting to secondary phosphorus release in a BNR plant", Water Sci.Technol.,60(9),2413-2418(2009).
19 Rensink,J.H.,van der Ven,J.,van Pamelen,G.,Fedder,F.,Majoor, E.,"The modified Renphosystem:A high biological nutrient removal system",Water Sci.Technol.,35(10),137-146(1997).
20 Meinhold,J.,Arnold,E.,Issacs,S.,"Effect of nitrite on anoxic phosphate uptake in biological phosphorus removal activated sludge",Water Res.,33(8),1871-1883(1999).
21 Coats,E.R.,Mockos,A.,Loge,F.J.,"Post-anoxic denitrification driven by PHA and glycogen within enhanced biological phosphorus removal",Bioresour.Technol.,102(2),1019-1027(2010).
22 Chen,Y.G.,Chen,Y.S.,Xu,Q.,Zhou,Q.,Gu,G.W.,"Comparison between acclimated and unacclimated biomass affecting anaerobic-aerobic transformations in the biological removal of phosphorus", Process Biochem.,40(2),723-732(2005).
23 Liu,W.,Mino,T.,Matsuo,T.,Nakamura,K.,"Biological phosphorus removal processes-effect of pH on anaerobic substrate metabolism",Water Sci.Technol.,34(1/2),25-32(1996).
24 Hesselmann,R.P.X.,Von Rummell,R.,Resnick,S.M.,Hany,R., Zehnder,A.J.B.,"Anaerobic metabolism of bacteria performing enhanced biological phosphate removal",Water Res.,34(14),3487-3494(2000).
25 Kuba,T.,Van Loosdrecht,M.C.M.."Occurrence of denitrifying phosphorus removal bacteria in modified UCT-type waste water treatment plants",Water Res.,31(4),777-786(1997).

[1]	Xingjuan Liang, Dehua Xu, Zhengjuan Yan, Jingxu Yang, Xinlong Wang, Zhiye Zhang, Jingli Wu, Honggang Zhen. Solid-liquid phase equilibrium for the system ammonium polyphosphate-urea ammonium nitrate-potassium chloride-water at 273.2 K[J]. 中国化学工程学报, 2023, 60(8): 131-142.
[2]	Zhenfu Wang, Jie Gao, Qinghong Shi, Xiaoyan Dong, Yan Sun. Facile purification and immobilization of organophosphorus hydrolase on protein-inorganic hybrid phosphate nanosheets[J]. 中国化学工程学报, 2023, 56(4): 119-125.
[3]	Muhammad Faizan, Yingwei Li, Ruirui Zhang, Xingsheng Wang, Piao Song, Ruixia Liu. Progress of vanadium phosphorous oxide catalyst for n-butane selective oxidation[J]. 中国化学工程学报, 2022, 43(3): 297-315.
[4]	Cemile Şeyma Arzum Yapıcı, Dilan Toprak, Müjgan Yıldız, Sinan Uyanık, Yakup Karaaslan, Deniz Uçar. A combo technology of autotrophic and heterotrophic denitrification processes for groundwater treatment[J]. 中国化学工程学报, 2021, 37(9): 121-127.
[5]	Lei Han, Ying Ouyang, Enhui Xing, Yibin Luo, Zhijian Da. Enhancing hydrothermal stability of framework Al in ZSM-5: From the view on the transformation between P and Al species by solid-state NMR spectroscopy[J]. 中国化学工程学报, 2020, 28(12): 3052-3060.
[6]	Wei Wei, Pengfei Xia, Zaiwen Liu, Min Zuo. A modified active disturbance rejection control for a wastewater treatment process[J]. 中国化学工程学报, 2020, 28(10): 2607-2619.
[7]	Yen Khai Chai, How Chun Lam, Chai Hoon Koo, Woei Jye Lau, Soon Onn Lai, Ahmad Fauzi Ismail. Performance evaluation of polyamide nanofiltration membranes for phosphorus removal process and their stability against strong acid/alkali solution[J]. 中国化学工程学报, 2019, 27(8): 1789-1797.
[8]	Mohammad El Wali, Saeed Rahimpour Golroudbary, Andrzej Kraslawski. Impact of recycling improvement on the life cycle of phosphorus[J]. 中国化学工程学报, 2019, 27(5): 1219-1229.
[9]	Mohammad Bagher Sabeti, Mohammad Amin Hejazi, Afzal Karimi. Enhanced removal of nitrate and phosphate from wastewater by Chlorella vulgaris: Multi-objective optimization and CFD simulation[J]. 中国化学工程学报, 2019, 27(3): 639-648.
[10]	Hongrui Ren, Jibin Song, Qinqin Xu, Jianzhong Yin. Solubility of the silver nitrate in supercritical carbon dioxide with ethanol and ethylene glycol as double cosolvents: Experimental determination and correlation[J]. Chinese Journal of Chemical Engineering, 2019, 27(2): 400-404.
[11]	Zhijuan Niu, Sitao Zhang, Yanhe Han, Mengmeng Qi. Optimization of the N₂ generation selectivity in aqueous nitrate reduction using internal circulation micro-electrolysis[J]. 中国化学工程学报, 2019, 27(12): 3010-3016.
[12]	Meisam Sharifi, Seyed-Mortaza Robatjazi, Minoo Sadri, Jafar Mohammadian Mosaabadi. Immobilization of organophosphorus hydrolase enzyme by covalent attachment on modified cellulose microfibers using different chemical activation strategies: Characterization and stability studies[J]. Chinese Journal of Chemical Engineering, 2019, 27(1): 191-199.
[13]	Meinan Zhen, Benru Song, Xiaomei Liu, Radhika Chandankere, Jingchun Tang. Biochar-mediated regulation of greenhouse gas emission and toxicity reduction in bioremediation of organophosphorus pesticide-contaminated soils[J]. Chinese Journal of Chemical Engineering, 2018, 26(12): 2592-2600.
[14]	Xulong Dong, Jian Li, Qinggui Xiao, Hui Zhang, Tao Qi. Reliable, environmentally friendly method for the recycling of spent Ag/α-Al₂O₃ catalysts using (NH₄)₂Ce(NO₃)₆[J]. Chinese Journal of Chemical Engineering, 2018, 26(10): 2169-2175.
[15]	Akbar Soliemanzadeh, Majid Fekri. Synthesis of clay-supported nanoscale zero-valent iron using green tea extract for the removal of phosphorus from aqueous solutions[J]. , 2017, 25(7): 924-930.

Effect of Return Sludge Pre-concentration on Biological Phosphorus Removal in a Novel Oxidation Ditch

Effect of Return Sludge Pre-concentration on Biological Phosphorus Removal in a Novel Oxidation Ditch

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价