Nanoparticle Migration in a Fully Developed Turbulent Pipe Flow Considering the Particle Coagulation

Chinese Journal of Chemical Engineering ›› 2012, Vol. 20 ›› Issue (4): 679-685.

Nanoparticle Migration in a Fully Developed Turbulent Pipe Flow Considering the Particle Coagulation

林建忠^1,2, 刘淞², 陈达良³

1. China Jiliang University, Hangzhou 310018, China;
2. State Key Laboratory of Fluid Power Transmission and Control, Zhejiang University, Hangzhou 310027, China;
3. Department of Mechanical Engineering, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong, China

收稿日期:2011-04-05 修回日期:2011-11-12 出版日期:2012-08-28 发布日期:2012-09-15
通讯作者: LIN Jianzhong, E-mail:mecjzlin@public.zju.edu.cn
基金资助:
Supported by the Major Program of the National Natural Science Foundation of China (11132008)

Nanoparticle Migration in a Fully Developed Turbulent Pipe Flow Considering the Particle Coagulation

LIN Jianzhong^1,2, LIU Song², CHAN Tatleung³

1. China Jiliang University, Hangzhou 310018, China;
2. State Key Laboratory of Fluid Power Transmission and Control, Zhejiang University, Hangzhou 310027, China;
3. Department of Mechanical Engineering, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong, China

Received:2011-04-05 Revised:2011-11-12 Online:2012-08-28 Published:2012-09-15
Supported by:
Supported by the Major Program of the National Natural Science Foundation of China (11132008)

摘要/Abstract

摘要： Numerical simulations of nanoparticle migration in a fully developed turbulent pipe flow are performed.The evolution of particle number concentration,total particle mass,polydispersity,particle diameter and geometric standard deviation is obtained by using a moment method to approximate the particle general dynamic equation.The effects of Schmidt number and Damköhler number on the evolution of the particle parameters are analyzed.The results show that nanoparticles move to the pipe center.The particle number concentration and total particle mass are distributed non-uniformly along the radial direction.In an initially monodisperse particle field,the particle clusters with various sizes will be produced because of coagulation.As time progresses,the particle cluster diameter grows from an initial value at different rates depending on the radial position.The largest particle clusters are found in the pipe center.The particle cluster number concentration and total particle mass decrease with the increase of Schmidt number in the region near the pipe center,and the particles with lower Schmidt number are of many different sizes,i.e.more polydispersity.The particle cluster diameter and geometric standard deviation increase with the increase of Damkhler number at the same radial position.The migration properties for nanosized particles are different from that for microsized particles.

关键词: nanoparticle, coagulation, turbulent, pipe flow

Abstract: Numerical simulations of nanoparticle migration in a fully developed turbulent pipe flow are performed.The evolution of particle number concentration,total particle mass,polydispersity,particle diameter and geometric standard deviation is obtained by using a moment method to approximate the particle general dynamic equation.The effects of Schmidt number and Damköhler number on the evolution of the particle parameters are analyzed.The results show that nanoparticles move to the pipe center.The particle number concentration and total particle mass are distributed non-uniformly along the radial direction.In an initially monodisperse particle field,the particle clusters with various sizes will be produced because of coagulation.As time progresses,the particle cluster diameter grows from an initial value at different rates depending on the radial position.The largest particle clusters are found in the pipe center.The particle cluster number concentration and total particle mass decrease with the increase of Schmidt number in the region near the pipe center,and the particles with lower Schmidt number are of many different sizes,i.e.more polydispersity.The particle cluster diameter and geometric standard deviation increase with the increase of Damkhler number at the same radial position.The migration properties for nanosized particles are different from that for microsized particles.

Key words: nanoparticle, coagulation, turbulent, pipe flow

林建忠, 刘淞, 陈达良. Nanoparticle Migration in a Fully Developed Turbulent Pipe Flow Considering the Particle Coagulation[J]. Chinese Journal of Chemical Engineering, 2012, 20(4): 679-685.

LIN Jianzhong, LIU Song, CHAN Tatleung. Nanoparticle Migration in a Fully Developed Turbulent Pipe Flow Considering the Particle Coagulation[J]. Chin.J.Chem.Eng., 2012, 20(4): 679-685.

参考文献

1 Kittelson,D.B.,"Engines and nanoparticles:A review",J.Aerosol Sci.,29,575-588(1998).
2 Yu,M.Z.,Lin,J.Z.,Chen,L.H.,Chan,T.L.,"Large eddy simulation of a planar jet flow with nanoparticle coagulation",Acta Mech. Sinica,22(4),293-300(2006).
3 Chan,T.L.,Lin,J.Z.,Zhou,K.,Chan,C.K.,"Simultaneous numerical simulation of nano and fine particle coagulation and dispersion in a round jet",J.Aerosol Sci.,37,1545-1561(2006).
4 Yu,M.Z.,Lin,J.Z.,Chan,T.L.,"Numerical simulation of nanoparticle synthesis in diffusion flame reactor",Powder Technology,181,9-20(2008).
5 Yu,M.Z.,Lin,J.Z.,Chan,T.L.,"Effect of precursor loading on non-spherical TiO₂ nanoparticle synthesis in a diffusion flame reactor",Chem.Eng.Sci.,63,2317-2329(2008).
6 Ding,W.L.,Wen,D.S.,"Particle migration in a flow of nanoparticle suspension",Powder Technol.,149,84-92(2005).
7 Jiang,S.P.,Lee,J.H.,Hwang,K.S.,Choi,S.U.S.,"Particle concentration and tube size dependence of viscosities of Al₂O₃-water nanofluids flowing through micro-and minitubes",Appl.Phys.Lett.,91,243112(2007).
8 Akbarinia,A.,Behzadmehr,A.,"Numerical study of laminar mixed convection of a nanofluid in horizontal curved tubes",Appl.Therm. Eng.,27,1327-1337(2007).
9 Mirmasoumi,S.,Behzadmehr,A.,"Numerical study of laminar mixed convection of a nanofluid in a horizontal tube using two-phase mixture model",Appl.Therm.Eng.,28,717-727(2008).
10 Jwo,C.S.,Teng,T.P.,Wu,D.J.,Chang,H.,Chen,S.L.,"Research on pressure loss of alumina nanofluid flow in a pipe",J.Chinese Soc. Mech.Eng.,30,511-517(2009).(in Chinese)
11 Lin,J.Z.,Lin,P.F.,Chen,H.J.,"Research on the transport and deposition of nanoparticles in a rotating curved pipe",Physi.Fluids,21,122001(2009).
12 Peng,H.,Ding,G.L.,Jiang,W.T.,Hu,H.T.,Gao,Y.F.,"Measurement and correlation of frictional pressure drop of refrigerant-based nanofluid flow boiling inside a horizontal smooth tube",Int.J.Refrig.Revue Int.Du Froid,32,1756-1764(2009).
13 Lin,P.F.,Lin,J.Z.,"Prediction of nanoparticle transport and deposition in bends",Appl.Math.Mech.Eng.Ed.,30,957-968(2009).
14 Lai,W.Y.,Phelan,P.E.,Prasher,R.S.,"Pressure-drop viscosity measurements for gamma-Al₂O₃ nanoparticles in water and PG-water mixtures(nanofluids)",J.Nanosci.Nanotechnol.,10,8026-8034(2010).
15 Qian,M.,Yan,Q.,Ni,X.W.,Zheng,H.R.,"Detection of nanoparticle Brownian motions in a nanofluid using laser speckle velocimetry",Lasers Eng.,20,117-128(2010).
16 Wright,D.L.,Yu,S.C.,Shaocai,Y.,Kasibhatla,P.S.,McGraw,R., Schwartz,S.E.,Saxena,V.K.,Yue,G.K.,"Retrieval of aerosol properties from moments of the particle size distribution for kernels involving the step function:Cloud droplet activation",J.Aerosol Sci.,33,319-337(2002).
17 Settumba,N.,Garrick,S.C.,"Direct numerical simulation of nanoparticle coagulation in a temporal mixing layer via a moment method",J.Aerosol Sci.,34,149-167(2003).
18 Hinze,J.O.,Turbulence,McGraw-Hill,USA(1975).
19 Friedlander,S.K.,Smoke,Dust and Haze:Fundamentals of Aerosol Behavior,Wiley,New York(2000).
20 Pratsinis,S.E.,"Simultaneous nucleation,condensation and coagulation in aerosol reactors",J.Colloid Interface Sci.,124,416-427 (1988).
21 Suh,S.M.,Zachariah,M.R.,Girshick,S.L.,"Numerical modelling of silicon oxide particle formation and transport in a one-dimensional low-pressure chemical vapor deposition reactor",J.Aerosol Sci.,33 (6),943-959(2002).
22 Lam,Y.C.,Chen,X.,Tan,K.W.,Chai,J.C.,Yu,S.C.M.,"Numerical investigation of particle migration if Poiseuille flow of composite system",Composites Science and Technology,64,1001-1010(2004).

[1]	Wenting Fan, Fang Zhao, Ming Chen, Jian Li, Xuhong Guo. An efficient microreactor with continuous serially connected micromixers for the synthesis of superparamagnetic magnetite nanoparticles[J]. 中国化学工程学报, 2023, 59(7): 85-91.
[2]	Chaoyi Yin, Jingyuan Ma, Jian Qiu, Ruifang Liu, Long Ba. Mass-producible low-cost flexible electronic fabrics for azo dye wastewater treatment by electrocoagulation[J]. 中国化学工程学报, 2023, 59(7): 222-230.
[3]	Wenshi Huang, Yang Zhang, Yuxin Wu, Jingyu Wang, Minmin Zhou. Analysis of particle dispersion in a turbulent flow considering particle rotation[J]. 中国化学工程学报, 2023, 58(6): 29-39.
[4]	Masoumeh Sheikh Hosseini Lori, Mohammad Delnavaz, Hoda Khoshvaght. Synthesizing and characterizing the magnetic EDTA/chitosan/CeZnO nanocomposite for simultaneous treating of chromium and phenol in an aqueous solution[J]. 中国化学工程学报, 2023, 58(6): 76-88.
[5]	Jingran Liu, Yue Wu, Jie Tang, Tao Wang, Feng Ni, Qiumin Wu, Xijiao Yang, Ayyaz Ahmad, Naveed Ramzan, Yisheng Xu. Polymeric assembled nanoparticles through kinetic stabilization by confined impingement jets dilution mixer for fluorescence switching imaging[J]. 中国化学工程学报, 2023, 56(4): 89-96.
[6]	Xiaoping Li, Jiaxin Pan, Jinwen Shi, Yanlin Chai, Songwei Hu, Qiaorong Han, Yanming Zhang, Xianwen Li, Dengwei Jing. Nanoparticle-induced drag reduction for polyacrylamide in turbulent flow with high Reynolds numbers[J]. 中国化学工程学报, 2023, 56(4): 290-298.
[7]	Lianlian Zhao, Fufu Di, Xiaonan Wang, Sumbal Farid, Suzhen Ren. Constructing a hollow core-shell structure of RuO₂ wrapped by hierarchical porous carbon shell with Ru NPs loading for supercapacitor[J]. 中国化学工程学报, 2023, 55(3): 93-100.
[8]	Xueqing Chen, Weiqun Gao, Yan Sun, Xiaoyan Dong. Multiple effects of polydopamine nanoparticles on Cu²⁺-mediated Alzheimer's β-amyloid aggregation[J]. 中国化学工程学报, 2023, 54(2): 144-152.
[9]	Lijian Shi, Yaping Zhang, Yujia Tong, Wenlong Ding, Weixing Li. Plant-inspired biomimetic hybrid PVDF membrane co-deposited by tea polyphenols and 3-amino-propyl-triethoxysilane for high-efficiency oil-in-water emulsion separation[J]. 中国化学工程学报, 2023, 53(1): 170-180.
[10]	Baolong Niu, Min Li, Jianhong Jia, Lixuan Ren, Xin Gang, Bin Nie, Yanying Fan, Xiaojie Lian, Wenfeng Li. Preparation and functional study of pH-sensitive amorphous calcium phosphate nanocarriers[J]. 中国化学工程学报, 2022, 48(8): 244-252.
[11]	Yingmeng Zhang, Luting Liu, Qingwei Deng, Wanlin Wu, Yongliang Li, Xiangzhong Ren, Peixin Zhang, Lingna Sun. Hybrid CuO-Co₃O₄ nanosphere/RGO sandwiched composites as anode materials for lithium-ion batteries[J]. 中国化学工程学报, 2022, 47(7): 185-192.
[12]	Dongze Ma, Ye Tian, Tiefei He, Xiaobiao Zhu. Preparation of novel magnetic nanoparticles as draw solutes in forward osmosis desalination[J]. 中国化学工程学报, 2022, 46(6): 223-230.
[13]	Yongjun Wu, Pan You, Peicheng Luo. Effect of pitched short blades on the flow characteristics in a stirred tank with long-short blades impeller[J]. 中国化学工程学报, 2022, 45(5): 143-152.
[14]	Kamel Hendaoui, Malika Trabelsi-Ayadi, Fadhila Ayari. Optimization of continuous electrocoagulation-adsorption combined process for the treatment of a textile effluent[J]. 中国化学工程学报, 2022, 44(4): 310-320.
[15]	Mehdi Miansari, Mehdi Rajabtabar Darvishi, Davood Toghraie, Pouya Barnoon, Mojtaba Shirzad, As'ad Alizadeh. Numerical investigation of grooves effects on the thermal performance of helically grooved shell and coil tube heat exchanger[J]. 中国化学工程学报, 2022, 44(4): 424-434.

Nanoparticle Migration in a Fully Developed Turbulent Pipe Flow Considering the Particle Coagulation

Nanoparticle Migration in a Fully Developed Turbulent Pipe Flow Considering the Particle Coagulation

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价