Analysis of particle dispersion in a turbulent flow considering particle rotation

doi:10.1016/j.cjche.2022.10.002

中国化学工程学报 ›› 2023, Vol. 58 ›› Issue (6): 29-39.DOI: 10.1016/j.cjche.2022.10.002

• Full Length Article • 上一篇下一篇

Analysis of particle dispersion in a turbulent flow considering particle rotation

Wenshi Huang¹, Yang Zhang¹, Yuxin Wu¹, Jingyu Wang¹, Minmin Zhou²

1. Department of Energy and Power Engineering, International Joint Laboratory on Low Carbon Clean Energy Innovation, Tsinghua University, Beijing 100084, China;
2. Department of Chemical Engineering, University of Utah, UT 84108, USA

收稿日期:2022-07-23 修回日期:2022-09-30 出版日期:2023-06-28 发布日期:2023-08-31
通讯作者: Yuxin Wu,E-mail:wuyx09@mail.tsinghua.edu.cn
基金资助:
This work has been supported by National Science and Technology Major Project of China(2019-I-0022-0021), Seed fund of Shanxi Research Institute for Clean Energy, Tsinghua University, and the National Natural Science Foundation of China (51761125011).

Analysis of particle dispersion in a turbulent flow considering particle rotation

Wenshi Huang¹, Yang Zhang¹, Yuxin Wu¹, Jingyu Wang¹, Minmin Zhou²

1. Department of Energy and Power Engineering, International Joint Laboratory on Low Carbon Clean Energy Innovation, Tsinghua University, Beijing 100084, China;
2. Department of Chemical Engineering, University of Utah, UT 84108, USA

Received:2022-07-23 Revised:2022-09-30 Online:2023-06-28 Published:2023-08-31
Contact: Yuxin Wu,E-mail:wuyx09@mail.tsinghua.edu.cn
Supported by:
This work has been supported by National Science and Technology Major Project of China(2019-I-0022-0021), Seed fund of Shanxi Research Institute for Clean Energy, Tsinghua University, and the National Natural Science Foundation of China (51761125011).

摘要/Abstract

摘要： Non-spherical particles exist widely in natural and industrial fluid systems and the motions of non-spherical particles are significantly different from that of spherical particles. In this paper, a simplified model of non-spherical particles considering particle drag correction, lift, and rotation was established. Based on the Eulerian-Lagrangian simulation, the dispersion characteristics of spherical and non-spherical particles with different Stokes numbers in a high-speed turbulent jet were analyzed and compared considering the effect of particle rotation. The results show that, the differences in particle dispersion and radial velocity fluctuation between non-spherical particles and spherical particles in the jet are significant, especially when Stokes number is large. Moreover, the effects of different type of forces on the dispersion of non-spherical particles and spherical particles were compared in detail, which revealed that the change of the Magnus force caused by the increase in the angular velocity of non-spherical particles plays a dominant role in the differences of particle dispersion.

关键词: Dispersion, Particle, Particle-laden flows, Particle rotation, Turbulent flow

Abstract: Non-spherical particles exist widely in natural and industrial fluid systems and the motions of non-spherical particles are significantly different from that of spherical particles. In this paper, a simplified model of non-spherical particles considering particle drag correction, lift, and rotation was established. Based on the Eulerian-Lagrangian simulation, the dispersion characteristics of spherical and non-spherical particles with different Stokes numbers in a high-speed turbulent jet were analyzed and compared considering the effect of particle rotation. The results show that, the differences in particle dispersion and radial velocity fluctuation between non-spherical particles and spherical particles in the jet are significant, especially when Stokes number is large. Moreover, the effects of different type of forces on the dispersion of non-spherical particles and spherical particles were compared in detail, which revealed that the change of the Magnus force caused by the increase in the angular velocity of non-spherical particles plays a dominant role in the differences of particle dispersion.

Key words: Dispersion, Particle, Particle-laden flows, Particle rotation, Turbulent flow

Wenshi Huang, Yang Zhang, Yuxin Wu, Jingyu Wang, Minmin Zhou. Analysis of particle dispersion in a turbulent flow considering particle rotation[J]. 中国化学工程学报, 2023, 58(6): 29-39.

Wenshi Huang, Yang Zhang, Yuxin Wu, Jingyu Wang, Minmin Zhou. Analysis of particle dispersion in a turbulent flow considering particle rotation[J]. Chinese Journal of Chemical Engineering, 2023, 58(6): 29-39.

参考文献

[1] S.R. Gubba, L. Ma, M. Pourkashanian, A. Williams, Influence of particle shape and internal thermal gradients of biomass particles on pulverised coal/biomass co-fired flames, Fuel Process. Technol. 92 (11) (2011) 2185-2195.
[2] T. Li, L. Wang, X.K. Ku, B.M. Güell, T. Løvås, C.R. Shaddix, Experimental and modeling study of the effect of torrefaction on the rapid devolatilization of biomass, Energy Fuels 29 (7) (2015) 4328-4338.
[3] A. Panahi, Y.A. Levendis, N. Vorobiev, M. Schiemann, Direct observations on the combustion characteristics of Miscanthus and Beechwood biomass including fusion and spherodization, Fuel Process. Technol. 166 (2017) 41-49.
[4] Y.X. Wu, P.J. Smith, J.S. Zhang, J.N. Thornock, G.X. Yue, Effects of turbulent mixing and controlling mechanisms in an entrained flow coal gasifier, Energy Fuels 24 (2) (2010) 1170-1175.
[5] H.S. Shen, Y.X. Wu, K.L. Xu, P.J. Smith, H. Zhang, Eulerian LES simulation of coal jet flame with a simplified DQMOM model, Fuel 216 (2018) 475-483.
[6] M. Weidmann, D. Honoré, V. Verbaere, G. Boutin, S. Grathwohl, G. Godard, C. Gobin, R. Kneer, G. Scheffknecht, Experimental characterization of pulverized coal MILD flameless combustion from detailed measurements in a pilot-scale facility, Combust. Flame 168 (2016) 365-377.
[7] P. Li, F. Wang, Y. Tu, Z. Mei, J. Zhang, Y. Zheng, H. Liu, Z. Liu, J. Mi, C. Zheng, Moderate or intense low-oxygen dilution oxy-combustion characteristics of light oil and pulverized coal in a pilot-scale furnace, Energy Fuels 28 (2) (2014) 1524-1535.
[8] M. Simone, E. Biagini, C. Galletti, L. Tognotti, Evaluation of global biomass devolatilization kinetics in a drop tube reactor with CFD aided experiments, Fuel 88 (10) (2009) 1818-1827.
[9] X.Y. Gao, Y.N. Zhang, B.X. Li, X.Y. Yu, Model development for biomass gasification in an entrained flow gasifier using intrinsic reaction rate submodel, Energy Convers. Manag. 108 (2016) 120-131.
[10] X.K. Ku, H.H. Jin, J.Z. Lin, Comparison of gasification performances between raw and torrefied biomasses in an air-blown fluidized-bed gasifier, Chem. Eng. Sci. 168 (2017) 235-249.
[11] A. Haider, O. Levenspiel, Drag coefficient and terminal velocity of spherical and nonspherical particles, Powder Technol. 58 (1) (1989) 63-70.
[12] B. van Wachem, M. Zastawny, F. Zhao, G. Mallouppas, Modelling of gas-solid turbulent channel flow with non-spherical particles with large Stokes numbers, Int. J. Multiph. Flow 68 (2015) 80-92.
[13] W. Zhang, K. Tainaka, S. Ahn, H. Watanabe, T. Kitagawa, Experimental and numerical investigation of effects of particle shape and size distribution on particles' dispersion in a coaxial jet flow, Adv. Powder Technol. 29 (10) (2018) 2322-2330.
[14] G.A. Voth, A. Soldati, Anisotropic particles in turbulence, Annu. Rev. Fluid Mech. 49 (2017) 249-276.
[15] R.I. Backreedy, L.M. Fletcher, J.M. Jones, L. Ma, M. Pourkashanian, A. Williams, Co-firing pulverised coal and biomass: A modeling approach, Proc. Combust. Inst. 30 (2) (2005) 2955-2964.
[16] L. Ma, J.M. Jones, M. Pourkashanian, A. Williams, Modelling the combustion of pulverized biomass in an industrial combustion test furnace, Fuel 86 (12-13) (2007) 1959-1965.
[17] A. Hölzer, M. Sommerfeld, New simple correlation formula for the drag coefficient of non-spherical particles, Powder Technol. 184 (3) (2008) 361-365.
[18] L. Rosendahl, Using a multi-parameter particle shape description to predict the motion of non-spherical particle shapes in swirling flow, Appl. Math. Model. 24 (1) (2000) 11-25.
[19] G.B. Jeffery, The motion of ellipsoidal particles immersed in a viscous fluid, Proc. R. Soc. Lond. A 102 (715) (1922) 161-179.
[20] J. Happel, H. Brenner, Low Reynolds Number Hydrodynamics, Springer, Dordrecht, 1981.
[21] M. Zastawny, G. Mallouppas, F. Zhao, B. van Wachem, Derivation of drag and lift force and torque coefficients for non-spherical particles in flows, Int. J. Multiph. Flow 39 (2012) 227-239.
[22] R. Ouchene, M. Khalij, B. Arcen, A. Tanière, A new set of correlations of drag, lift and torque coefficients for non-spherical particles and large Reynolds numbers, Powder Technol. 303 (2016) 33-43.
[23] N. Guo, T. Li, L.H. Zhao, T. Løvås, Eulerian-Lagrangian simulation of pulverized biomass jet using spheroidal particle approximation, Fuel 239 (2019) 636-651.
[24] P.H. Mortensen, H.I. Andersson, J.J.J. Gillissen, B.J. Boersma, Dynamics of prolate ellipsoidal particles in a turbulent channel flow, Phys. Fluids 20 (9) (2008) 093302.
[25] C. Marchioli, A. Soldati, Rotation statistics of fibers in wall shear turbulence, Acta Mech. 224 (10) (2013) 2311-2329.
[26] N.R. Challabotla, L.H. Zhao, H.I. Andersson, Orientation and rotation of inertial disk particles in wall turbulence, J. Fluid Mech. 766 (2015) R2.
[27] N.R. Challabotla, L.H. Zhao, H.I. Andersson, Shape effects on dynamics of inertia-free spheroids in wall turbulence, Phys. Fluids 27 (6) (2015) 061703.
[28] L. Zhao, N.R. Challabotla, H.I. Andersson, E.A. Variano, Rotation of nonspherical particles in turbulent channel flow, Phys. Rev. Lett. 115 (24) (2015) 244501.
[29] H.S. Morton, J.L. Junkins, J.N. Blanton, Analytical solutions for Euler parameters, Celest. Mech. 10 (3) (1974) 287-301.
[30] K.W. Spring, Euler parameters and the use of quaternion algebra in the manipulation of finite rotations: A review, Mech. Mach. Theory 21 (5) (1986) 365-373.
[31] B. Arcen, R. Ouchene, M. Khalij, A. Tanière, Prolate spheroidal particles' behavior in a vertical wall-bounded turbulent flow, Phys. Fluids 29 (9) (2017) 093301.
[32] R. Mei, An approximate expression for the shear lift force on a spherical particle at finite Reynolds number, Int. J. Multiph. Flow 18 (1) (1992) 145-147.
[33] C.F. You, H.Y. Qi, X.C. Xu, Lift force on rotating sphere at low Reynolds numbers and high rotational speeds, Acta Mech. Sin. 19 (4) (2003) 300-307.
[34] P.Y. Shi, R. Rzehak, Lift forces on solid spherical particles in unbounded flows, Chem. Eng. Sci. 208 (2019) 115145.
[35] H. Zhang, L.X. Zhang, X.Z. An, A.B. Yu, PR-DNS on the momentum and heat transfer of a rotating ellipsoidal particle in a fluid, Powder Technol. 373 (2020) 152-163.
[36] W.S. Huang, Y.X. Wu, L.L. Feng, M. Zhang, Y. Zhang, Dispersion characteristics of typical non-spherical particles in a high-speed round jet, J. Tsinghua Univ. (Sci. & Tech.) 60 (6) (2020) 485-492.
[37] Y. Hardalupas, A.M.K.P. Taylor, J.H. Whitelaw, Velocity and particle-flux characteristics of turbulent particle-laden jets, Proc. R. Soc. Lond. A 426 (1989), 31-78.
[38] T.C.W. Lau, G.J. Nathan, The effect of Stokes number on particle velocity and concentration distributions in a well-characterised, turbulent, co-flowing two-phase jet, J. Fluid Mech. 809 (2016) 72-110.
[39] L.Z. Chen, Z.C. Chen, S.Z. Sun, Z.Q. Li, The impact of the PDA measurement method in forward scatter on the concentration of gas-particle two phase flow, AIP Conf. Proc. 914 (1) (2007) 437-440.
[40] J.Y. Wang, W.S. Huang, Y. Zhang, Y.X. Wu, H. Zhang, G.X. Yue, Particle trajectories in pipe flow considering particle-wall collisions, Phys. Fluids 32 (4) (2020) 043307.
[41] S.A. Morsi, A.J. Alexander, An investigation of particle trajectories in two-phase flow systems, J. Fluid Mech. 55 (2) (1972) 193.
[42] A.D. Gosman, E. Loannides, Aspects of computer simulation of liquid-fueled combustors, J. Energy 7 (6) (1983) 482-490.
[43] J.S. Shuen, L.D. Chen, G.M. Faeth, Evaluation of a stochastic model of particle dispersion in a turbulent round jet, AIChE J. 29 (1) (1983) 167-170.
[44] M. Sommerfeld, Particle dispersion in turbulent flow: The effect of particle size distribution, Part. Part. Syst. Charact. 7 (1-4) (1990) 209-220.
[45] C.J. Call, I.M. Kennedy, Measurements and simulations of particle dispersion in a turbulent flow, Int. J. Multiph. Flow 18 (6) (1992) 891-903.
[46] B.J. Daly, F.H. Harlow, Transport equations in turbulence, Phys. Fluids 13 (11) (1970) 2634-2649.
[47] I. Ayrancı, G. Pinguet, D. Escudié, N. Selçuk, R. Vaillon, F. André, Effect of particle polydispersity on particle concentration measurement by using laser Doppler anemometry, Exp. Therm. Fluid Sci. 31 (8) (2007) 839-847.

Analysis of particle dispersion in a turbulent flow considering particle rotation

Analysis of particle dispersion in a turbulent flow considering particle rotation

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	Chaojie Li, Xianxin Fang, Meiling Sun, Jihai Duan, Weiwen Wang. Study on two-phase cloud dispersion from liquefied CO₂ release[J]. 中国化学工程学报, 2023, 60(8): 37-45.
[2]	Wenting Fan, Fang Zhao, Ming Chen, Jian Li, Xuhong Guo. An efficient microreactor with continuous serially connected micromixers for the synthesis of superparamagnetic magnetite nanoparticles[J]. 中国化学工程学报, 2023, 59(7): 85-91.
[3]	Masoumeh Sheikh Hosseini Lori, Mohammad Delnavaz, Hoda Khoshvaght. Synthesizing and characterizing the magnetic EDTA/chitosan/CeZnO nanocomposite for simultaneous treating of chromium and phenol in an aqueous solution[J]. 中国化学工程学报, 2023, 58(6): 76-88.
[4]	Junhao Wang, Shugang Ma, Peng Chen, Zhipeng Li, Zhengming Gao, J. J. Derksen. Mixing of miscible shear-thinning fluids in a lid-driven cavity[J]. 中国化学工程学报, 2023, 58(6): 112-123.
[5]	Danlei Chen, Yiqing Luo, Xigang Yuan. Cascade refrigeration system synthesis based on hybrid simulated annealing and particle swarm optimization algorithm[J]. 中国化学工程学报, 2023, 58(6): 244-255.
[6]	Hui Yi Leong, Xiao-Qian Fu, Xiang-Yu Liu, Shan-Jing Yao, Dong-Qiang Lin. Characterisation and separation of infectious bursal disease virus-like particles using aqueous two-phase systems[J]. 中国化学工程学报, 2023, 57(5): 72-78.
[7]	Jingran Liu, Yue Wu, Jie Tang, Tao Wang, Feng Ni, Qiumin Wu, Xijiao Yang, Ayyaz Ahmad, Naveed Ramzan, Yisheng Xu. Polymeric assembled nanoparticles through kinetic stabilization by confined impingement jets dilution mixer for fluorescence switching imaging[J]. 中国化学工程学报, 2023, 56(4): 89-96.
[8]	Xiaoping Li, Jiaxin Pan, Jinwen Shi, Yanlin Chai, Songwei Hu, Qiaorong Han, Yanming Zhang, Xianwen Li, Dengwei Jing. Nanoparticle-induced drag reduction for polyacrylamide in turbulent flow with high Reynolds numbers[J]. 中国化学工程学报, 2023, 56(4): 290-298.
[9]	Tian Zhang, Qingshan Huang, Shujun Geng, Aqiang Chen, Yan Liu, Haidong Zhang. Impacts of solid physical properties on the performances of a slurry external airlift loop reactor integrating mixing and separation[J]. 中国化学工程学报, 2023, 55(3): 1-12.
[10]	Lianlian Zhao, Fufu Di, Xiaonan Wang, Sumbal Farid, Suzhen Ren. Constructing a hollow core-shell structure of RuO₂ wrapped by hierarchical porous carbon shell with Ru NPs loading for supercapacitor[J]. 中国化学工程学报, 2023, 55(3): 93-100.
[11]	Feng Jiang, Xiao Li, Guopeng Qi, Xiulun Li. Effects of particle type on the particle fluidization and distribution in a liquid–solid circulating fluidized bed boiler[J]. 中国化学工程学报, 2023, 54(2): 53-66.
[12]	Xueqing Chen, Weiqun Gao, Yan Sun, Xiaoyan Dong. Multiple effects of polydopamine nanoparticles on Cu²⁺-mediated Alzheimer's β-amyloid aggregation[J]. 中国化学工程学报, 2023, 54(2): 144-152.
[13]	Jihui Li, Bingjian Zhang, Yidan Shu. Simulation of gas-solid adsorption process considering particle-size distribution[J]. 中国化学工程学报, 2023, 54(2): 331-342.
[14]	Lijian Shi, Yaping Zhang, Yujia Tong, Wenlong Ding, Weixing Li. Plant-inspired biomimetic hybrid PVDF membrane co-deposited by tea polyphenols and 3-amino-propyl-triethoxysilane for high-efficiency oil-in-water emulsion separation[J]. 中国化学工程学报, 2023, 53(1): 170-180.
[15]	Baolong Niu, Min Li, Jianhong Jia, Lixuan Ren, Xin Gang, Bin Nie, Yanying Fan, Xiaojie Lian, Wenfeng Li. Preparation and functional study of pH-sensitive amorphous calcium phosphate nanocarriers[J]. 中国化学工程学报, 2022, 48(8): 244-252.