Graphene oxide based carbon composite as adsorbent for Hg removal:Preparation, characterization, kinetics and isotherm studies

doi:10.1016/j.cjche.2017.02.006

摘要/Abstract

摘要： The presence of Hg in the aqueous media is known to cause severe health issues in both humans and animals. Many technologies and especially adsorbents have been applied for its removal. In this study, a graphene oxide-carbon composite (GO-CC) as a new adsorbent was prepared by sol gel procedure and characterized using field emission scanning electron microscopy, BET and EDX. The effects of different variables including solution pH, contact time, adsorbent dose and GO ratio in adsorbent matrix on the removal capacity of Hg were studied. The isotherm data correlated well with the Langmuir isotherm model. Further analysis recommended that the Hg²⁺ adsorption process is governed by the intra-particle and external mass transfer, in which the film diffusion was the rate restrictive step. The presented composite has maximum absorption capacity, q_max of 68.8 mg·g^-1, which is comparable with carbon based adsorbent reported in the previous publications.

关键词: Adsorbent, Mercury removal, Sol gel, Carbon composite

Abstract: The presence of Hg in the aqueous media is known to cause severe health issues in both humans and animals. Many technologies and especially adsorbents have been applied for its removal. In this study, a graphene oxide-carbon composite (GO-CC) as a new adsorbent was prepared by sol gel procedure and characterized using field emission scanning electron microscopy, BET and EDX. The effects of different variables including solution pH, contact time, adsorbent dose and GO ratio in adsorbent matrix on the removal capacity of Hg were studied. The isotherm data correlated well with the Langmuir isotherm model. Further analysis recommended that the Hg²⁺ adsorption process is governed by the intra-particle and external mass transfer, in which the film diffusion was the rate restrictive step. The presented composite has maximum absorption capacity, q_max of 68.8 mg·g^-1, which is comparable with carbon based adsorbent reported in the previous publications.

Key words: Adsorbent, Mercury removal, Sol gel, Carbon composite

Tayebeh Esfandiyari, Navid Nasirizadeh, Mohammad Dehghani, Mohammad Hassan Ehrampoosh. Graphene oxide based carbon composite as adsorbent for Hg removal:Preparation, characterization, kinetics and isotherm studies[J]. , 2017, 25(9): 1170-1175.

参考文献

[1] S.T. Song, N. Saman, K. Johari, H. Mat, Removal of Hg(Ⅱ) from aqueous solution by adsorption using raw and chemically modified rice straw as novel adsorbents, Ind. Eng. Chem. Res. 52(2013) 13092-13101.
[2] O.S. Akintola, T.A. Saleh, M.M. Khaled, O.C.S. Al Hamouz, Removal of mercury (Ⅱ) via a novel series of cross-linked polydithiocarbamates, J. Taiwan Inst. Chem. Eng. 60(2016) 602-616.
[3] Z.H. Huang, X. Zheng, W. Lv, M. Wang, Q.H. Yang, F. Kang, Adsorption of lead (Ⅱ) ions from aqueous solution on low-temperature exfoliated graphene nanosheets, Langmuir 27(2011) 7558-7562.
[4] L. Cui, Y. Wang, L. Gao, L. Hu, Q. Wei, B. Du, Removal of Hg(Ⅱ) from aqueous solution by resin loaded magnetic β-cyclodextrin bead and graphene oxide sheet:synthesis, adsorption mechanism and separation properties, J. Colloid Interface Sci. 456(2015) 42-49.
[5] F. Ke, L.G. Qiu, Y.P. Yuan, F.M. Peng, X. Jiang, A.J. Xie, Y.H. Shen, J.F. Zhu, Thiolfunctionalization of metal-organic framework by a facile coordination-based postsynthetic strategy and enhanced removal of Hg²⁺ from water, J. Hazard. Mater. 196(2011) 36-43.
[6] T.B. Ibigbami, F.A. Dawodu, O.J. Akinyeye, Removal of heavy metals from pharmaceutical industrial wastewater effluent by combination of adsorption and chemical precipitation methods, Am. J. Appl. Chem. 4(2016) 24-32.
[7] P.A. Turhanen, J.J. Vepsalainen, S. Peraniemi, Advanced material and approach for metal ions removal from aqueous solutions, Sci. Rep. 5(2015) 1-10.
[8] S. Siva, S. Sudharsanc, R. Sayee Kannan, Synthesis, characterization and ionexchange properties of novel hybrid polymer nanocomposites for selective and effective mercury (Ⅱ) removal, RSC Adv. 5(2015) 79665-79678.
[9] R. Padmavathi, M. Minnoli, D. Sangeetha, Removal of heavy metal ions from waste water using anion exchange polymer membranes, Int. J. Plast. Technol. 18(2014) 88-99.
[10] H.N.M.E. Mahmud, A.K. Obidul Huq, R.B. Yahya, The removal of heavy metal ions from wastewater/aqueous solution using polypyrrole-based adsorbents:A review, RSC Adv. 6(2016) 14778-14791.
[11] R. Fu, Y. Liu, Z. Lou, Z. Wang, S.A. Baig, X. Xu, Adsorptive removal of Pb(Ⅱ) by magnetic activated carbon incorporated with amino groups from aqueous solutions, J. Taiwan Inst. Chem. Eng. 62(2016) 247-258.
[12] K. He, Y. Chen, Z. Tang, Y. Hu, Removal of heavy metal ions from aqueous solution by zeolite synthesized from fly ash, Environ. Sci. Pollut. Res. Int. 23(2016) 2778-2788.
[13] K. Anitha, S. Namsani, J.K. Singh, Removal of heavy metal ions using a functionalized single-walled carbon nanotube:a molecular dynamics study, J. Phys. Chem. A 119(2015) 8349-8358.
[14] A. Sari, M. Tuzen, Removal of mercury (Ⅱ) from aqueous solution using moss (Drepanocladus revolvens) biomass:Equilibrium, thermodynamic and kinetic studies, J. Hazard. Mater. 171(2009) 500-507.
[15] M. Ahmaruzzaman, V.K. Gupta, Rice husk and its ash as low-cost adsorbents in water and wastewater treatment, Ind. Eng. Chem. Res. 50(2011) 13589-13613.
[16] H. Javadian, M. Taghavi, Application of novel Polypyrrole/thiol-functionalized zeolite Beta/MCM-41 type mesoporous silica nanocomposite for adsorption of Hg²⁺ from aqueous solution and industrial wastewater:kinetic, isotherm and thermodynamic studies, Appl. Surf. Sci. 289(2014) 487-494.
[17] M. Otero, C.B. Lopes, J. Coimbra, T.R. Ferreira, C.M. Silva, Z. Lin, J. Rocha, E. Pereira, A.C. Duarte, Priority pollutants (Hg²⁺ and Cd²⁺) removal from water by ETS-4 titanosilicate, Desalination 249(2009) 742-747.
[18] G. Zhao, J. Li, X. Ren, C. Chen, X. Wang, Few-layered graphene oxide nanosheets as superior sorbents for heavy metal ion pollution management, Environ. Sci. Technol. 45(2011) 10454-10462.
[19] H. Guo, T. Jiao, Q. Zhang, W. Guo, Q. Peng, X. Yan, Preparation of graphene oxidebased hydrogels as efficient dye adsorbents for wastewater treatment, Nanoscale Res. Lett. 10(2015) 272-281.
[20] D. Jeon, W.J. Yoo, J.K. Seo, S.H. Shin, K.T. Han, S.G. Kim, J.Y. Park, B. Lee, Fiber-optic pH sensor based on sol-gel film immobilized with neutral red, Opt. Rev. 20(2013) 209-213.
[21] T.M. Budnyak, I.V. Pylypchuk, V.A. Tertykh, E.S. Yanovska, D. Kolodynska, Synthesis and adsorption properties of chitosan-silica nanocomposite prepared by sol-gel method, Nanoscale Res. Lett. 10(2015) 87-96.
[22] J. Wang, Q. Zhou, D. Song, B. Qi, Y. Zhang, Y. Shao, Z. Shao, Chitosan-silica composite aerogels:preparation, characterization and Congo red adsorption, J. Sol-Gel Sci. Technol. 76(2015) 501-509.
[23] J.B. Wu, S.Y. Zang, Y.L. Yi, Sol-gel derived ion imprinted thiocyanato-functionalized silica gel as selective adsorbent of cadmium (Ⅱ), J. Sol-Gel Sci. Technol. 66(2013) 434-442.
[24] B. Viltuznik, A. Lobnik, A. Kosak, The removal of Hg (Ⅱ) ions from aqueous solutions by using thiol-functionalized cobalt ferrite magnetic nanoparticles, J. Sol-Gel Sci. Technol. 74(2015) 199-207.
[25] N. Nasirizadeh, M. Dehghani, M.E. Yazdanshenas, Preparation of hydrophobic and conductive cotton fabrics using multi-wall carbon nanotubes by the sol-gel method, J. Sol-Gel Sci. Technol. 73(2015) 14-21.
[26] H.L. Poh, F. Sanek, A. Ambrosi, G. Zhao, Z. Sofer, M. Pumera, Graphenes prepared by Staudenmaier, Hofmann and Hummers methods with consequent thermal exfoliation exhibit very different electrochemical properties, Nanoscale 4(2012) 3515-3522.
[27] Z. Dong, F. Zhang, D. Wang, X. Liu, J. Jin, Polydopamine-mediated surfacefunctionalization of graphene oxide for heavy metal ions removal, J. Solid State Chem. 224(2015) 88-93.
[28] S. Wu, X. Zhao, Y. Li, Q. Du, J. Sun, Y. Wang, X. Wang, Y. Xia, Z. Wang, L. Xia, Adsorption properties of doxorubicin hydrochloride onto graphene oxide:equilibrium, kinetic and thermodynamic studies, Materials 6(2013) 2026-2042.
[29] H. Shi, W. Li, L. Zhong, C. Xu, Methylene blue adsorption from aqueous solution by magnetic cellulose/graphene oxide composite:equilibrium, kinetics, and thermodynamics, Ind. Eng. Chem. Res. 53(2014) 1108-1118.
[30] M. Puanngam, F. Unob, Preparation and use of chemically modified MCM-41 and silica gel as selective adsorbents for Hg(Ⅱ) ions, J. Hazard. Mater. 154(2008) 578-584.
[31] Y. Zhang, L. Yan, W. Xua, X. Guo, L. Cui, L. Gao, Q. Wei, B. Du, Adsorption of Pb(Ⅱ) and Hg(Ⅱ) from aqueous solution using magnetic CoFe₂O₄-reduced graphene oxide, J. Mol. Liq. 191(2014) 177-182.
[32] R.L. Tseng, F.C. Wu, R.S. Juang, Characteristics and applications of the Lagergren's first-order equation for adsorption kinetics, J. Taiwan Inst. Chem. Eng. 41(2010) 661-669.
[33] R. Leyva-Ramos, L.A. Bernal-Jacome, J. Mendoza-Barron, M.M.G. Hernandez-Orta, Kinetic modeling of pentachlorophenol adsorption onto granular activated carbon, J. Taiwan Inst. Chem. Eng. 40(2009) 622-629.
[34] K. Yaghmaeian, R. Khosravi Mashizi, S. Nasseri, A.H. Mahvi, M. Alimohammadi, S. Nazmara, Removal of inorganic mercury from aquatic environments by multiwalled carbon nanotubes, J. Environ. Health Sci. Eng. 13(2015) 55-60.
[35] A. Somayajul, A.A. Aziz, P. Saravanan, M. Matheswaran, Adsorption of mercury (Ⅱ) ion from aqueous solution using low-cost activated carbon prepared from mango kernel, Asia Pac. J. Chem. Eng. 8(2012) 1-10.
[36] A.S.K. Kumar, S.J. Jiang, W.L. Tseng, Facile synthesis and characterization of thiolfunctionalized graphene oxide as effective adsorbent for Hg(Ⅱ), J. Environ. Chem. Eng. 4(2016) 2052-2065.
[37] B. Henriques, G. Gonçalves, N. Emami, E. Pereira, M. Vila, P.A.A.P. Marques, Optimized graphene oxide foam with enhanced performance and high selectivity for mercury removal from water, J. Hazard. Mater. 301(2016) 453-461.
[38] Q. Fan, Y. Yang, Y. Hao, X. Zhao, Y. Feng, Preparation of three-dimensional PANI/GO for the separation of Hg (Ⅱ) from aqueous solution, J. Mol. Liq. 212(2015) 557-562.
[39] L. Cui, X. Guo, Q. Wei, Y. Wang, L. Gao, L. Yan, T. Yan, B. Du, Removal of mercury and methylene blue from aqueous solution by xanthate functionalized magnetic graphene oxide:sorption kinetic and uptake mechanism, J. Colloid Interface Sci. 439(2015) 112-120.
[40] S.K. Kumar, A.S.J. Jiang, Preparation and characterization of exfoliated graphene oxide-L-cystine as an effective adsorbent of Hg(Ⅱ) adsorption, RSC Adv. 5(2015) 6294-6304.
[41] K. Kadirvelu, J. Goel, C. Rajagopal, Sorption of lead, mercury and cadmium ions in multi-component system using carbon aerogel as adsorbent, J. Hazard. Mater. 153(2008) 502-507.
[42] A.K. Meena, G.K. Mishra, P.K. Rai, C. Rajagopal, P.N. Nagar, Removal of heavy metal ions from aqueous solutions using carbon aerogel as an adsorbent, J. Hazard. Mater. 122(2005) 161-170.
[43] V.K. Gupta, A. Rastogi, Biosorption of hexavalent chromium by raw and acid-treated green alga Oedogonium hatei from aqueous solutions, J. Hazard. Mater. 163(2009) 396-402.