Modified corn-core powder for enhancing sludge dewaterability: Synthesis, characterization and sludge dewatering performance

doi:10.1016/j.cjche.2020.09.022

中国化学工程学报 ›› 2021, Vol. 32 ›› Issue (4): 368-377.DOI: 10.1016/j.cjche.2020.09.022

• Energy, Resources and Environmental Technology • 上一篇下一篇

Modified corn-core powder for enhancing sludge dewaterability: Synthesis, characterization and sludge dewatering performance

Zhiying Guo¹, Liping Ma¹, Quxiu Dai¹, Xinbo Yang², Ran Ao¹, Jie Yang³, Jing Yang⁴, Wengang Li¹

1 Faculty of Environmental Science and Engineering, Kunming University of Science and Technology, Kunming 650500, China;
2 Yunnan Tianlang Energy Saving&Environmental Protection Group Co. Ltd, Kunming 650300, China;
3 College of Resources and Environment, Chengdu University of Information Technology, Chengdu 610225, China;
4 School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710000, China

收稿日期:2020-01-29 修回日期:2020-09-03 出版日期:2021-04-28 发布日期:2021-06-19
通讯作者: Liping Ma
基金资助:
This work was supported by the National Natural Science Foundation of China (No. 21666016); the National Key R&D Program of China (2018YFC1900200); and the Key Laboratory and the Analysis and Testing Foundation of Kunming University of Science and Technology (2017M20162207011, 2019P20183107007).

Modified corn-core powder for enhancing sludge dewaterability: Synthesis, characterization and sludge dewatering performance

Zhiying Guo¹, Liping Ma¹, Quxiu Dai¹, Xinbo Yang², Ran Ao¹, Jie Yang³, Jing Yang⁴, Wengang Li¹

1 Faculty of Environmental Science and Engineering, Kunming University of Science and Technology, Kunming 650500, China;
2 Yunnan Tianlang Energy Saving&Environmental Protection Group Co. Ltd, Kunming 650300, China;
3 College of Resources and Environment, Chengdu University of Information Technology, Chengdu 610225, China;
4 School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710000, China

Received:2020-01-29 Revised:2020-09-03 Online:2021-04-28 Published:2021-06-19
Contact: Liping Ma
Supported by:
This work was supported by the National Natural Science Foundation of China (No. 21666016); the National Key R&D Program of China (2018YFC1900200); and the Key Laboratory and the Analysis and Testing Foundation of Kunming University of Science and Technology (2017M20162207011, 2019P20183107007).

摘要/Abstract

摘要： The high water content of sludge has always posed significant challenges for its treatment. Synthetic flocculants, which are widely used in sewage treatment plants, can cause secondary pollution during their production and use. Thus, natural polymer flocculants made of natural materials have received increased research attention recently. Corn-core, an agricultural waste, was modified through alkalization with sodium hydroxide (NaOH) and etherification with cetyltrimethylammonium bromide (CTMAB) in this study. The L₁₆ (4⁵) orthogonal array was used to study the modification conditions. The moisture content (MC) of treated sludge was reduced by approximately 37% with the addition of modified corn-core powder (MCCP), which was synthesized under optimal conditions. In addition, changes in the functional groups of the material before and after modification were determined by FT-IR. Thermogravimetric analysis indicated that MCCP was steady at room temperature, moreover, BET analysis showed that MCCP had greater surface area. The microstructures of material before and after modification were examined by scanning electron microscopy, revealing that MCCP had a flake-shaped structure and had an increased area of contact area with sludge particles. MCCP is a dehydrating agent that can enhance sludge dewaterability through charge neutralization and re-agglomeration and provide superior economic benefits.

关键词: Municipal sludge, Corn-core powder, Pollution, Polymers, Waste treatment

Abstract: The high water content of sludge has always posed significant challenges for its treatment. Synthetic flocculants, which are widely used in sewage treatment plants, can cause secondary pollution during their production and use. Thus, natural polymer flocculants made of natural materials have received increased research attention recently. Corn-core, an agricultural waste, was modified through alkalization with sodium hydroxide (NaOH) and etherification with cetyltrimethylammonium bromide (CTMAB) in this study. The L₁₆ (4⁵) orthogonal array was used to study the modification conditions. The moisture content (MC) of treated sludge was reduced by approximately 37% with the addition of modified corn-core powder (MCCP), which was synthesized under optimal conditions. In addition, changes in the functional groups of the material before and after modification were determined by FT-IR. Thermogravimetric analysis indicated that MCCP was steady at room temperature, moreover, BET analysis showed that MCCP had greater surface area. The microstructures of material before and after modification were examined by scanning electron microscopy, revealing that MCCP had a flake-shaped structure and had an increased area of contact area with sludge particles. MCCP is a dehydrating agent that can enhance sludge dewaterability through charge neutralization and re-agglomeration and provide superior economic benefits.

Key words: Municipal sludge, Corn-core powder, Pollution, Polymers, Waste treatment

Zhiying Guo, Liping Ma, Quxiu Dai, Xinbo Yang, Ran Ao, Jie Yang, Jing Yang, Wengang Li. Modified corn-core powder for enhancing sludge dewaterability: Synthesis, characterization and sludge dewatering performance[J]. 中国化学工程学报, 2021, 32(4): 368-377.

参考文献

[1] J. Yu, K. Xiao, J. Yang, W. Yu, K. Pei, Y. Zhu, J. Wang, S. Liang, J. Hu, H. Hou, B. Liu, Enhanced sludge dewaterability and pathogen inactivation by synergistic effects of zero-valent iron and ozonation, ACS Sustain. Chem. Eng. 7(2019) 324-331.
[2] H. Li, L. Song, B. Han, H. Song, Improved sludge dewaterability using persulfate activated by humic acid supported nanoscale zero-valent iron:effect on sludge characteristics and reaction mechanisms, Environ. Sci. Wat. Res. Technol. 4(2018) 1480-1488.
[3] M. Hosomi, New challenges on wastewater treatment, Clean Technol. Environ. Policy 18(2016) 627-628.
[4] Y. Liao, X. Zheng, Z. Zhang, B. Xu, Y. Sun, Y. Liu, H. Zheng, Ultrasound-assisted polymerization of P(AM-DMDAAC):Synthesis, characterization and sludge dewatering performance, J. Environ Chem. Eng. (2017) 5439-5447.
[5] E. Kvarnstrom, C. Morel, J.C. Fardeau, J.L. Morel, S. Esa, Changes in the phosphorus availability of a chemically precipitated urban sewage sludge as a result of different dewatering processes, Waste Manage. Res. 18(2000) 249-258.
[6] F. Lin, X. Zhu, Y. Luo, P. Yu, M. Liu, Improvement of activated sludge dewatering properties using green conditioners:Chitosan hydrochloride and lysozyme, RSC Adv. 9(2019) 6936-6945.
[7] Peifang Wang, Guoxiang You, Jun Hou, Xu Chao, Miao Yi, Responses of wastewater biofilms to chronic CeO₂ nanoparticles exposure:Structural, physicochemical and microbial properties and potential mechanism, Water Res. (2018) 208-217.
[8] Y. Liao, H. Zheng, L. Qian, Y. Sun, L. Dai, W. Xue, UV-initiated polymerization of hydrophobically associating cationic polyacrylamide modified by a surfaceactive monomer:A comparative study of synthesis, characterization, and sludge dewatering performance, Ind. Eng. Chem. Res. 53(2014) 11193-11203.
[9] R.H. Khan, M.K. Siddiqi, P. Salahuddin, Protein structure and function, Basic Biochem. 1(2017) 35-52.
[10] J.-P. Wang, S.-J. Yuan, Y. Wang, H.-Q. Yu, Synthesis, characterization and application of a novel starch-based flocculant with high flocculation and dewatering properties, Water Res. 47(2013) 2643-2648.
[11] Y. Luo, Z. Yang, Z. Xu, L. Zhou, G. Zeng, J. Huang, Y. Xiao, L. Wang, Effect of trace amounts of polyacrylamide (PAM) on long-term performance of activated sludge, J. Hazard. Mater. 189(2011) 69-75.
[12] Xiaowen Zhao, Lin Ye, Peng Huang, Synthesis of hydrophobic cationic chitosan flocculant and its sludge dewatering property, J. Macromol. Sci. Part B-Phys. 55(2016) 299-309.
[13] Y. Yuan, H. Sun, S. Jiang, R. Zhang, D. Su, C. Feng, X. Han, Performance and leaching analysis of a novel coal sludge-based backfill material, Clean Technol. Environ. Policy 15(2013) 657-666.
[14] H.S. Erkan, Waste activated sludge disintegration by hydroxyl and sulfate radical-based oxidation:A comparative study, Environ. Sci.-Water Res. Technol. 5(2019) 2027-2040.
[15] Borowski Sebastian, Kucner Marcin, The use of sugar beet pulp stillage for codigestion with sewage sludge and poultry manure, Waste Manage. Res. (2019) 1025-1032.
[16] Y.U. Xiaoyan, S. Zhang, X.U. Hui, Z. Lei, X. Lü, M.A. Degang, Influence of filter cloth on the cathode on the electroosmotic dewatering of activated sludge, Chin. J. Chem. Eng. 18(2010) 562-568.
[17] Y. Wu, P. Zhang, H. Zhang, G. Zeng, J. Liu, J. Ye, W. Fang, X. Gou, Possibility of sludge conditioning and dewatering with rice husk biochar modified by ferric chloride, Bioresour. Technol. 205(2016) 258-263.
[18] E. Corradini, P. Curti, A. Meniqueti, A. Rubira, E. Muniz, Recent advances in foodpacking, pharmaceutical and biomedical applications of zein and zeinbased materials, Int. J. Mol. Sci. 15(2014) 22438-22470.
[19] H. Zhang, G. Mittal, Biodegradable protein-based films from plant resources:A review, Environ. Prog. Sustain. Energy 29(2010) 203-220.
[20] H. Yokota, Alkalization mechanism of cellulose in hydroxypropylcellulose preparation process, J. Appl. Polym. Sci. 32(2003) 3423-3433.
[21] A. Moral, R. Aguado, A. Tijero, Alkalization and cationization of cellulose:Effects on intrinsic viscosity, Fiber Polym. 17(2016) 857-861.
[22] Y. Choi, S. Maken, S. Lee, Characteristics of water-soluble fiber manufactured from carboxymethylcellulose synthesis, Korean J. Chem. Eng. 24(2007) 288-293.
[23] H. Gu, J. He, Y. Huang, Z. Guo, Water soluble carboxymethylcellulose fibers derived from alkalization-etherification of viscose fibers, Fiber Polym. 13(2012) 748-753.
[24] B. Philipp, D. Klemm, A. Stein, Regioselective esterification and etherification of cellulose and cellulose derivates. Pt.3:Synthesis of regioselectively substituted cellulose ethers and summary discussion, Papier 49(1995) 102.
[25] S. Banerjee, Dewatering fibrous sludge with soy protein, Process Biochem. 49(2014) 120-123.
[26] M. Cai, Q. Wang, G. Wells, D.D. Dionysiou, Z. Song, J. MicongJin, S.-H. Hu, R. Ho, Z. Wei Xiao, Improving dewaterability and filterability of waste activated sludge by electrochemical Fenton pretreatment, Chem. Eng. J. (2019) 1385-8947.
[27] R.K. Chakraborti, J.F. Atkinson, J.E. van Benschoten, Characterization of alum floc by image analysis, Environ. Sci. Technol. 34(2000) 3969-3976.
[28] K.M. Lee, M.S. Kim, C. Lee, Oxidative treatment of waste activated sludge by different activated persulfate systems for enhancing sludge dewaterability, Sustain. Environ. Res. 26(2016) 177-183.
[29] D.J. Lee, Y.H. Hsu, Measurement of bound water in sludges-A comparativestudy, Water Environ. Res. 67(1995) 310-317.
[30] Y. Lv, K. Xiao, J. Yang, Y. Zhu, K. Pei, W. Yu, S. Tao, H. Wang, S. Liang, H. Hou, Correlation between oxidation-reduction potential values and sludge dewaterability during pre-oxidation, Water Res. 155(2019) 96-105.
[31] J.W.C. Wong, J. Zhou, M.B. Kurade, K. Murugesan, Influence of ferrous ions on extracellular polymeric substances content and sludge dewaterability during bioleaching, Bioresour. Technol. 179(2015) 78-83.
[32] I.M.C. Lo, C.K. Lai, G. Chen, Salinity effect on mechanical dewatering of sludge with and without chemical conditioning, Environ. Sci. Technol. 35(2001) 4691-4696.
[33] M. Xie, Z. Shi, L.I. Shu-Zhan, Measuring specific resistance to filtration (SRF) of sludge, Environ. Sci. Technol. 29(2006) 15-17.
[34] Ping Chen, Zhangh Tangg, Houcai Liu, Orthogonal experiment investigation on wear resistance of MoSi₂, Rare Met. (English Ed.) 22(2003) 230-234.
[35] J. Han, C. Zhou, Y. Wu, F. Liu, Q. Wu, Self-assembling behavior of cellulose nanoparticles during freeze-drying:Effect of suspension concentration, particle size, crystal structure, and surface charge, Biomacromolecules 14(2013) 1529-1540.
[36] N. Agmon, H.J. Bakker, R.K. Campen, R.H. Henchman, P. Pohl, S. Roke, M. ThMer, A. Hassanali, Protons and hydroxide ions in aqueous systems, Chem. Rev. 116(2016) 7642-7672.
[37] Y. Chen, W. Ye, K. Zhang, Strength of copolymer grouting material based on orthogonal experiment, J. Central South Univ. Technol. 16(2009) 143-148.
[38] A. Pfluger, R. Erickson, G. Vanzin, M. Hahn, J. Callahan, J. Munakata-Marr, L. Figueroa, Energy-generating potential of anaerobically enhanced primary treatment of domestic wastewater using multiple-compartment bioreactors, Environ. Sci.-Water Res. Technol. 6(2020) 117-131.
[39] J. Baeza, J. Freer, Chemical characterization of wood and its components, Wood Cellul. Chem. 2(2000) 275-384.
[40] Q. Lin, H. Peng, S. Zhong, J. Xiang, Synthesis, characterization, and secondary sludge dewatering performance of a novel combined silicon-aluminum-ironstarch flocculant, J. Hazard. Mater. 285(2015) 199-206.
[41] Z. Zhang, H. Zheng, F. Huang, X. Li, S. He, C. Zhao, Template polymerization of a novel cationic polyacrylamide:Sequence distribution, characterization, and flocculation performance, Ind. Eng. Chem. Res. 55(2016) 9819-9828.
[42] X. Zhao, J. Chen, F. Chen, X. Wang, Q. Zhu, Q. Ao, Surface characterization of corn stalk superfine powder studied by FTIR and XRD, Colloid Surf. BBiointerfaces 104(2013) 207-212.
[43] S. Karamdoust, B. Yu, C.V. Bonduelle, Y. Liu, G. Davidson, G. Stojcevic, J. Yang, W.M. Lau, E.R. Gillies, Preparation of antibacterial surfaces by hyperthermal hydrogen induced cross-linking of polymer thin films, J. Mater. Chem. 22(2012) 4881-4889.
[44] J. Ma, J. Li, G. Li, Y. Tian, J. Zhang, J. Wu, J. Zheng, H. Zhuang, T. Pan, One simple synthesis route to whisker-like nanocrystalline boron nitride by the reaction of NaBH4 and NaN3, Mater. Res. Bull. 42(2007) 982-988.
[45] Ş. Süzer, Ö. Birer, XPS investigations on conducting polymers, Turk. J. Chem. 22(1998) 59-65.
[46] W. Chen, H. Zheng, Q. Guan, H. Teng, C. Zhao, C. Zhao, Fabricating a flocculant with controllable cationic microblock structure:Characterization and sludge conditioning behavior evaluation, Ind. Eng. Chem. Res. 55(2016) 2892-2902.
[47] C. Saka, BET, TG-DTG, FT-IR, SEM, iodine number analysis and preparation of activated carbon from acorn shell by chemical activation with ZnCl2, J. Anal. Appl. Pyrol. 95(2012) 21-24.
[48] W.U. Xiaofen, L. Chen, Q.I. Hui, M. Deng, D. Guo, K. Wang, Effect of cobalt-60 gamma-ray irradiation on separation of components from corncob by formic acid, J. Radiat. Res. Radiat. Process. (2018) 51-58.
[49] W. Janewit, W. Nakorn, P. Suneerat, Product yields and characteristics of rice husk, rice straw and corncob during fast pyrolysis in a drop-tube/fixed-bed reactor, Songklanakarin J. Sci. Technol. 30(2008) 393-404.
[50] A. Demirbas, Effects of temperature and particle size on bio-char yield from pyrolysis of agricultural residues, J. Anal. Appl. Pyroly. 72(2004) 243-248.
[51] H.M. Ng, L.T. Sin, T.T. Tee, S.T. Bee, D. Hui, C.Y. Low, A.R. Rahmat, Extraction of cellulose nanocrystals from plant sources for application as reinforcing agent in polymers, Composites Part B 75b (2015) 176-200.
[52] Z. Chen, W. Zhang, D. Wang, T. Ma, R. Bai, D. Yu, Enhancement of waste activated sludge dewaterability using calcium peroxide pre-oxidation and chemical re-flocculation, Water Res. 103(2016) 170-181.
[53] H.T. Yang, H.F. Tu, Y. Lan, Y.M. Xie, The effect of alkaline pretreatment on enzymatic hydrolysis of corncob residue and structural change of lignin, Pap. Sci. Technol. (2015) 66-68.
[54] H. Zheng, J. Ma, C. Zhu, Z. Zhang, L. Liu, Y. Sun, X. Tang, Synthesis of anion polyacrylamide under UV initiation and its application in removing dioctyl phthalate from water through flocculation process, Sep. Purif. Technol. 123(2014) 35-44.
[55] Z. Guo, L. Ma, Q. Dai, J. Yang, R. Ao, L. Wang, Dewatering performance of sewage sludge under pretreatment with modified corn-core powder, Sci. Total Environ. 684(2019) 402-412.
[56] C.D. Geddes, A. Parfenov, D. Roll, I. Gryczynski, J. Malicka, J.R. Lakowicz, Silver fractal-like structures for metal-enhanced fluorescence:Enhanced fluorescence intensities and increased probe photostabilities, J. Fluoresc. 13(2003) 267-276.
[57] F. Colin, S. Gazbar, Distribution of water in sludges in relation to their mechanical dewatering, Water Res. 29(1995).
[58] Q. Dai, L. Ma, N. Ren, P. Ning, Z. Guo, L. Xie, H. Gao, Investigation on extracellular polymeric substances, sludge flocs morphology, bound water release and dewatering performance of sewage sludge under pretreatment with modified phosphogypsum, Water Res. 142(2018) 337-346.
[59] S. Horton, A. Wesley, M.G.V. Mannar, Double-fortified salt reduces anemia, benefit:Cost ratio is modestly favorable, Food Policy 36(2011) 581-587.

Modified corn-core powder for enhancing sludge dewaterability: Synthesis, characterization and sludge dewatering performance

Modified corn-core powder for enhancing sludge dewaterability: Synthesis, characterization and sludge dewatering performance

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	Pan Wang, Mengdei Zhou, Zhuangxin Wei, Lu Liu, Tao Cheng, Xiaohua Tian, Jianming Pan. Preparation of bowl-shaped polydopamine surface imprinted polymer composite adsorbent for specific separation of 2′-deoxyadenosine[J]. 中国化学工程学报, 2023, 60(8): 69-79.
[2]	Eileen Katherine Coronado-Aldana, Cindy Lizeth Ferreira-Salazar, Nubia Yineth Piñeros-Castro, Rubén Vázquez-Medina, Felipe A. Perdomo. Thermodynamic analysis, synthesis, characterization, and evaluation of 1-ethyl-3-methylimidazolium chloride: Study of its effect on pretreated rice husk[J]. 中国化学工程学报, 2023, 60(8): 143-154.
[3]	Sufei Wang, Mengjie Hao, Danyang Xiao, Tianmiao Zhang, Hua Li, Zhongshan Chen. Synthesis of porous carbon nanomaterials and their application in tetracycline removal from aqueous solutions[J]. 中国化学工程学报, 2023, 59(7): 200-209.
[4]	Runze Chen, Yuran Chen, Xuemin Liang, Yapeng Kong, Yangyang Fan, Quan Liu, Zhenyu Yang, Feiying Tang, Johnny Muya Chabu, Maru Dessie Walle, Liqiang Wang. Oxidative exfoliation of spent cathode carbon: A two-in-one strategy for its decontamination and high-valued application[J]. 中国化学工程学报, 2023, 59(7): 262-269.
[5]	Haike Li, Xindong Li, Guozai Ouyang, Lang Li, Zhaohuang Zhong, Meng Cai, Wenhao Li, Wanfu Huang. Tannic acid/Fe³⁺ interlayer for preparation of high-permeability polyetherimide organic solvent nanofiltration membranes for organic solvent separation[J]. 中国化学工程学报, 2023, 57(5): 17-29.
[6]	Hui Yi Leong, Xiao-Qian Fu, Xiang-Yu Liu, Shan-Jing Yao, Dong-Qiang Lin. Characterisation and separation of infectious bursal disease virus-like particles using aqueous two-phase systems[J]. 中国化学工程学报, 2023, 57(5): 72-78.
[7]	Shanshan Mao, Tao Shen, Qing Zhao, Tong Han, Fan Ding, Xin Jin, Manglai Gao. Selective capture of silver ions from aqueous solution by series of azole derivatives-functionalized silica nanosheets[J]. 中国化学工程学报, 2023, 57(5): 319-328.
[8]	Taoyan Mao, Runhui Xiao, Peng Liu, Jiale Chen, Junqiang Luo, Su Luo, Fengwei Xie, Cheng Zheng. Facile fabrication of durable superhydrophobic fabrics by silicon polyurethane membrane for oil/water separation[J]. 中国化学工程学报, 2023, 55(3): 73-83.
[9]	Qingyue Han, Suqing Wang, Wenhan Kong, Bing Ji, Haihui Wang. Composite polymer electrolyte reinforced by graphitic carbon nitride nanosheets for room-temperature all-solid-state lithium batteries[J]. 中国化学工程学报, 2023, 54(2): 257-263.
[10]	Jiacheng Chen, Jincheng Wang, Shuhong Li, Kailing Xiang, Shiqiang Song. Pyridine terminated polyurethane dendrimer/chlorinated butyl rubber nanocomposites with excellent mechanical and damping properties[J]. 中国化学工程学报, 2023, 53(1): 211-221.
[11]	Luyao Guo, Mengru Wang, Ronghe Lin, Jiaxin Ma, Shuanghao Zheng, Xiaoling Mou, Jun Zhang, Zhong-Shuai Wu, Yunjie Ding. Assembly of N- and P-functionalized carbon nanostructures derived from precursor-defined ternary copolymers for high-capacity lithium-ion batteries[J]. 中国化学工程学报, 2023, 53(1): 280-288.
[12]	Lin-Bing Zou, Jue-Ying Gong, Xiao-Jie Ju, Zhuang Liu, Wei Wang, Rui Xie, Liang-Yin Chu. Smart membranes for biomedical applications[J]. 中国化学工程学报, 2022, 49(9): 34-45.
[13]	Zhong Ma, Guofu Liu, Hui Zhang, Yonggang Lu. Investigation of the redox performance of pyrite cinder calcined at different temperature in chemical looping combustion[J]. 中国化学工程学报, 2022, 48(8): 98-105.
[14]	Fenfen You, Qing-Hong Shi. In situ investigation of lysozyme adsorption into polyelectrolyte brushes by quartz crystal microbalance with dissipation[J]. 中国化学工程学报, 2022, 48(8): 106-115.
[15]	Zhibin Ma, Xueli Zhang, Guangjun Lu, Yanxia Guo, Huiping Song, Fangqin Cheng. Hydrothermal synthesis of zeolitic material from circulating fluidized bed combustion fly ash for the highly efficient removal of lead from aqueous solution[J]. 中国化学工程学报, 2022, 47(7): 193-205.