Aromatization of Methanol over La/Zn/HZSM-5 Catalysts

›› 2011, Vol. 19 ›› Issue (3): 439-445.

Aromatization of Methanol over La/Zn/HZSM-5 Catalysts

倪友明¹, 孙爱明¹, 吴小岭¹, 胡江林¹, 李涛^1,2, 李光兴^1,2

1. School of Chemistry&Chemical Engineering, Huazhong University of Science&Technology, Wuhan 430074, China;
2. Hubei Key Laboratory of Materials Chemistry&Service Failure, Huazhong University of Science&Technology, Wuhan 430074, China

收稿日期:2010-12-13 修回日期:2011-03-30 出版日期:2011-06-28 发布日期:2011-06-28
通讯作者: LI Tao, E-mail: taoli@mail.hust.edu.cn;LI Guangxing, E-mail: ligxabc@163.com
基金资助:
Supported by the Fundamental Research Funds for the Central Universities,HUST(Z2009008);the National Natural Science Foundation of China(20973068)

Aromatization of Methanol over La/Zn/HZSM-5 Catalysts

NI Youming¹, SUN Aiming¹, WU Xiaoling¹, HU Jianglin¹, LI Tao^1,2, LI Guangxing^1,2

1. School of Chemistry&Chemical Engineering, Huazhong University of Science&Technology, Wuhan 430074, China;
2. Hubei Key Laboratory of Materials Chemistry&Service Failure, Huazhong University of Science&Technology, Wuhan 430074, China

Received:2010-12-13 Revised:2011-03-30 Online:2011-06-28 Published:2011-06-28
Supported by:
Supported by the Fundamental Research Funds for the Central Universities,HUST(Z2009008);the National Natural Science Foundation of China(20973068)

摘要/Abstract

摘要： Aromatization of methanol over co-impregnated La/Zn/HZSM-5 zeolite catalyst was studied.The selectivity of aromatics and BTX(benzene,toluene,and xylene)reached 64.0% and 56.6%,respectively,using La/Zn/HZSM-5 at 437℃,0.1 MPa and methanol WHSV(weight hourly space velocity)=0.8 h^-1.Catalytic results showed that the La species was a very good promoter,increased selectivity of aromatics,and prolonged the catalyst lifetime on stream.The effects of the SiO₂/Al₂O₃ ratio in zeolite,Zn and La loading,WHSV,reaction temperature, water content in the feed and H₂ pretreatment of catalysts on the catalytic performance were studied in detail. Characterizations of the catalysts by thermogravimetric analysis(TGA),NH₃-TPD(temperature programmed desorption),SEM(scanning electron micrograph),N₂ adsorption-desorption,XRD(X-ray diffraction) and XRF (X-ray fluorescence),were carried out to understand the structure and discuss the aromatization performance of La/Zn/HZSM-5 zeolite catalyst.

关键词: methanol, aromatization, La, Zn, ZSM-5

Abstract: Aromatization of methanol over co-impregnated La/Zn/HZSM-5 zeolite catalyst was studied.The selectivity of aromatics and BTX(benzene,toluene,and xylene)reached 64.0% and 56.6%,respectively,using La/Zn/HZSM-5 at 437℃,0.1 MPa and methanol WHSV(weight hourly space velocity)=0.8 h^-1.Catalytic results showed that the La species was a very good promoter,increased selectivity of aromatics,and prolonged the catalyst lifetime on stream.The effects of the SiO₂/Al₂O₃ ratio in zeolite,Zn and La loading,WHSV,reaction temperature, water content in the feed and H₂ pretreatment of catalysts on the catalytic performance were studied in detail. Characterizations of the catalysts by thermogravimetric analysis(TGA),NH₃-TPD(temperature programmed desorption),SEM(scanning electron micrograph),N₂ adsorption-desorption,XRD(X-ray diffraction) and XRF (X-ray fluorescence),were carried out to understand the structure and discuss the aromatization performance of La/Zn/HZSM-5 zeolite catalyst.

Key words: methanol, aromatization, La, Zn, ZSM-5

倪友明, 孙爱明, 吴小岭, 胡江林, 李涛, 李光兴. Aromatization of Methanol over La/Zn/HZSM-5 Catalysts[J]. , 2011, 19(3): 439-445.

NI Youming, SUN Aiming, WU Xiaoling, HU Jianglin, LI Tao, LI Guangxing. Aromatization of Methanol over La/Zn/HZSM-5 Catalysts[J]. , 2011, 19(3): 439-445.

参考文献

1 Fahim, M.A., Alsahhaf, T.A., Elkilani, A., Fundamentals of Petroleum Refining, Elsevier, Amsterdam, 95-152(2010).
2 Olah, G.A., Goeppert, A., Prakash, G.K.S., Beyond Oil and Gas: The Methanol Economy, Wiley VCH, Weinheim, 27(2006).
3 Choi, M., Na, K., Kim, J., Sakamoto, Y., Terasaki, O., Ryoo, R., “Stable single-unit-cell nanosheets of zeolite MFI as active and long-lived catalysts”, Nature, 461(7261), 246-249(2009).
4 Kim, J., Choi, M., Ryoo. R., “Effect of mesoporosity against the deactivation of MFI zeolite catalyst during the methanol-to-hydrocarbon conversion process”, J. Catal., 269(1), 219-228(2010).
5 Bj rgen, M., Joensen, F., Holm, M.S., Olsbye, U., Lillerud, K.P., Svelle, S., “Methanol to gasoline over zeolite H-ZSM-5: Improved catalyst performance by treatment with NaOH”, Appl. Catal. A, 345(1), 43-50(2008).
6 Chang, C.D., Kuo, J.C.W., Lang, W.H., Jacob, S.M., Wise, J.J., Silvestri, A.J., “Process studies on the conversion of methanol to gasoline”, Ind. Eng. Chem. Process Des. Dev., 17(3), 255-260(1978).
7 Chang, C.D., Silvestri, A.J., “The conversion of methanol and other O-compounds to hydrocarbons over zeolite catalysts”, J. Catal., 47(2), 249-259(1977).
8 Inoue, Y., Nakashiro, K., Ono, Y., “Selective conversion of methanol into aromatic hydrocarbons over silver-exchanged ZSM-5 zeolites”, Micropor. Mater., 4(5), 379-383(1995).
9 Tian, T., Qian, W.Z., Sun, Y.J., Cui, Y., Lu, Y.Y., Wei, F., “Aromatization of methanol on Ag/ZSM-5 catalyst”, Modern Chem. Ind., 29(1), 55-58(2009).(in Chinese)
10 Zaidi, H.A., Pant, K.K., “Catalytic conversion of methanol to gasoline range hydrocarbons”, Catal. Today, 96(3), 155-160(2004).
11 Zaidi, H.A., Pant, K.K., “Activity of oxalic acid treated ZnO/CuO/HZSM-5 catalyst for the transformation of methanol to gasoline range hydrocarbons”, Ind. Eng. Chem. Res., 47(9), 2970-2975(2008).
12 Barthos, R., Bánsági, T., Zakar, T.S., Solymosi, F., “Aromatization of methanol and methylation of benzene over Mo₂C/ZSM-5 catalysts”, J. Catal., 247(2), 368-378(2007).
13 Freeman, D., Wells, R.P.K., Hutchings, G.J., “Conversion of methanol to hydrocarbons over Ga₂O₃/H-ZSM-5 and Ga₂O₃/WO₃ catalysts”, J. Catal., 205(2), 358-365(2002).
14 Choudhary, V.R., Kinage, A.K., “Methanol-to-aromatics conversion over H-gallosilicate(MFI): influence of Si/Ga ratio, degree of H + exchange, pretreatment conditions, and poisoning of strong acid sites”, Zeolites, 15(8), 732-738(1995).
15 Ono, Y., Adachi, H., Senoda, Y., “Selective conversion of methanol into aromatic hydrocarbons over zinc-exchanged ZSM-5 zeolites”, J. Chem. Soc. Faraday Trans. 1, 84(4), 1091-1099(1988).
16 Zheng, L.H., Xuan, D., Guo, J.J., Lou, H., Zheng, X.M., “Non-oxidative aromatization of CH₄-C₄H₈ over La-promoted Zn/HZSM-5 catalysts”, J. Nat. Gas Chem., 15(1), 52-57(2006).
17 Zhao, X.B., Guo, X.W., Wang, X.S., “Effect of hydrothermal treatment temperature on FCC gasoline upgrading properties of the modified nanoscale ZSM-5 catalyst”, Fuel Process. Technol., 88(3), 237-241(2007).
18 Zhao, X.B., Guo, X.W., Wang, X.S., “Characterization of modified nanoscale ZSM-5 catalyst and its application in FCC gasoline upgrading process”, Energy Fuels, 20(4), 1388-1391(2006).
19 Ni, Y.M., Peng, W.Y., Sun, A.M., Mo, W.L., Hu, J.L., Li, T., Li. G.X., “High selective and stable performance of catalytic aromatization of alcohols and ethers over La/Zn/HZSM-5 catalysts”, J. Ind. Eng. Chem., 16(4), 503-505(2010).
20 Miyamoto, T., Katada, N., Kim, J.H., Niwa, M., “Acidic property of MFI-type gallosilicate determined by temperature-programmed desorption of ammonia”, J. Phys. Chem. B, 102(35), 6738-6745(1998).
21 St cker, M., “Methanol-to-hydrocarbons: Catalytic materials and their behavior”, Microporous Mesopor. Mater., 29(1-2), 3-48(1999).
22 Zhao, Y.X., Wei, F., Yu, Y., “Inhibition of coke formation in cracking of 2-methylpentane on USHY by addition of steam”, Chin. J. Chem. Eng., 16(5) 726-732(2008).
23 Wang, J.W., Jin, G.Q., Zhang, Z.X., Wang. X.K., “Aromatization of propane over La/HZSM-5 catalyst”, J. Chin. Rare Earths Soc., 19(2), 103-106(2001).(in Chinese)
24 Nowak, I., Quartararo, J., Derouane, E.G., Védrine, J.C., “Effect of H₂-O₂ pre-treatments on the state of gallium in Ga/H-ZSM-5 propane aromatization catalysts”, Appl. Catal. A, 251(1), 107-120(2003).
25 Zhang, L.D., Gao, J.H., Hu, J.X., Li, W.H., Wang, J.G., “Lanthanum oxides-improved catalytic performance of ZSM-5 in toluene alkylation with methanol”, Catal. Lett., 130(3-4), 355-361(2009).

[1]	Baoyu Liu, Feng Xiong, Jianwen Zhang, Manna Wang, Yi Huang, Yanxiong Fang, Jinxiang Dong. Enhanced ortho-selective t–butylation of phenol over sulfonic acid functionalized mesopore MTW zeolites[J]. 中国化学工程学报, 2023, 60(8): 1-7.
[2]	Pan Wang, Mengdei Zhou, Zhuangxin Wei, Lu Liu, Tao Cheng, Xiaohua Tian, Jianming Pan. Preparation of bowl-shaped polydopamine surface imprinted polymer composite adsorbent for specific separation of 2′-deoxyadenosine[J]. 中国化学工程学报, 2023, 60(8): 69-79.
[3]	Yifan Jiang, Bingqi Xie, Jisong Zhang. Highly reactive and reusable heterogeneous activated carbons-based palladium catalysts for Suzuki-Miyaura reaction[J]. 中国化学工程学报, 2023, 60(8): 165-172.
[4]	Jiahao Xing, Huaizhi Han, Ruitian Yu, Wen Luo. Numerical simulation of flow and heat transfer of n-decane in sub-millimeter spiral tube at supercritical pressure[J]. 中国化学工程学报, 2023, 60(8): 173-185.
[5]	Xiaolin Pan, Mengyuan Gao, Yun Wang, Yanping He, Tian Si, Yanlin Sun. Poly(lactic acid)-aspirin microspheres prepared via the traditional and improved solvent evaporation methods and its application performances[J]. 中国化学工程学报, 2023, 60(8): 194-204.
[6]	Xiaolin Guo, Zhaoyang Zhang, Pengfei Xing, Shuai Wang, Yibing Guo, Yanxin Zhuang. Kinetic mechanism of copper extraction from methylchlorosilane slurry residue using hydrogen peroxide as oxidant[J]. 中国化学工程学报, 2023, 60(8): 228-234.
[7]	Huiqi Wang, Jianpo Ren, Shihao Zhang, Jiayu Dai, Yue Niu, Ketao Shi, Qiuxiang Yin, Ling Zhou. Measurement and correlation of solubility of 9-fluorenone in 11 pure organic solvents from T = 283.15 to 323.15 K[J]. 中国化学工程学报, 2023, 60(8): 235-241.
[8]	Hammad Saulat, Jianhua Yang, Tao Yan, Waseem Raza, Wensen Song, Gaohong He. Tungsten incorporated mobil-type eleven zeolite membranes: Facile synthesis and tuneable wettability for highly efficient separation of oil/water mixtures[J]. 中国化学工程学报, 2023, 60(8): 242-252.
[9]	Jindong Dai, Chi Zhai, Jiali Ai, Guangren Yu, Haichao Lv, Wei Sun, Yongzhong Liu. A cellular automata framework for porous electrode reconstruction and reaction-diffusion simulation[J]. 中国化学工程学报, 2023, 60(8): 262-274.
[10]	Lijuan Zhao, Zhe Tan, Xiaoguang Zhang, Qijun Zhang, Wei Wang, Qiang Deng, Jie Ma, De'an Pan. Research on process modeling and simulation of spent lead paste desulfurization enhanced reactor[J]. 中国化学工程学报, 2023, 60(8): 293-303.
[11]	Anjun Liu, Jie Chen, Meng Guo, Chengmin Chen, Meihong Yang, Chao Yang. The internal circulations on internal mass transfer rate of a single drop in nonlinear uniaxial extensional flow[J]. 中国化学工程学报, 2023, 59(7): 51-60.
[12]	Yingxi Gao, Jiayi Shi, Jie Wang, Fan Zhang, Shichao Tian, Zhiyong Zhou, Zhongqi Ren. Enrichment of nervonic acid in Acer truncatum Bunge oil by combination of two-stage molecular distillation, one-stage urea complexation and five-stage solvent crystallization[J]. 中国化学工程学报, 2023, 59(7): 61-71.
[13]	Xiaoli Li, Minghua Liu, Kang Wang, Zhiqiang Liu, Guihai Li. Data cleaning method for the process of acid production with flue gas based on improved random forest[J]. 中国化学工程学报, 2023, 59(7): 72-84.
[14]	Haixiang Liu, Jun Zhang, Chunlei Dong, Gang Zhu, Guanben Du, Shuduan Deng. Synthesis, performance and structure characterization of glyoxal-monomethylolurea-melamine (G-MMU-M) co-condensed resin[J]. 中国化学工程学报, 2023, 59(7): 92-104.
[15]	Wen Yu, Yiyang Bo, Yiling Luo, Xiyan Huang, Rixiang Zhang, Jiaheng Zhang. Enhancing effect of choline chloride-based deep eutectic solvents with polyols on the aqueous solubility of curcumin-insight from experiment and theoretical calculation[J]. 中国化学工程学报, 2023, 59(7): 160-168.

Aromatization of Methanol over La/Zn/HZSM-5 Catalysts

Aromatization of Methanol over La/Zn/HZSM-5 Catalysts

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价