Effect of pore size on CH4/N2 separation using activated carbon

doi:10.1016/j.cjche.2019.12.018

中国化学工程学报 ›› 2020, Vol. 28 ›› Issue (4): 1062-1068.DOI: 10.1016/j.cjche.2019.12.018

• Separation Science and Engineering • 上一篇下一篇

Effect of pore size on CH₄/N₂ separation using activated carbon

Gaofei Chen¹, Yaxiong An², Yuanhui Shen², Yayan Wang², Zhongli Tang², Bo Lu³, Donghui Zhang²

1 Key Laboratory of Cryogenics, Technical Institute of Physics and Chemistry, Chinese Academy of Sciences, Beijing 100190, China;
2 The Research Center of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin 300072, China;
3 State Key Laboratory of Coal and CBM Co-mining, Jincheng 048000, China

收稿日期:2019-09-29 修回日期:2019-12-17 出版日期:2020-04-28 发布日期:2020-07-27
通讯作者: Donghui Zhang
基金资助:
This work is part of the project supported by the Shanxi Coal-bed Methane Joint Research Fund (No. 2015012004).

Effect of pore size on CH₄/N₂ separation using activated carbon

Gaofei Chen¹, Yaxiong An², Yuanhui Shen², Yayan Wang², Zhongli Tang², Bo Lu³, Donghui Zhang²

1 Key Laboratory of Cryogenics, Technical Institute of Physics and Chemistry, Chinese Academy of Sciences, Beijing 100190, China;
2 The Research Center of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University, Tianjin 300072, China;
3 State Key Laboratory of Coal and CBM Co-mining, Jincheng 048000, China

Received:2019-09-29 Revised:2019-12-17 Online:2020-04-28 Published:2020-07-27
Contact: Donghui Zhang
Supported by:
This work is part of the project supported by the Shanxi Coal-bed Methane Joint Research Fund (No. 2015012004).

摘要/Abstract

摘要： In this paper, a model of activated carbon was established by molecular simulation and the separation performance of N₂ and CH₄ on activated carbon was studied. In order to evaluate the adsorption selectivity and diffusion selectivity of N₂ and CH₄, Grand Canonical Monte Carlo and molecular dynamic methods were used to obtain equilibrium adsorption isotherms and mean square displacements of N₂ and CH₄ on activated carbon with different pore sizes. Research results showed that the difference in adsorption isosteric heat of N₂ and CH₄ at the pore size of 0.46 nm is the largest, which is 5.759 and 7.03 kcal·mol^-1 (1 cal=4.184 J), respectively. Activated carbon with pore size of 0.46 nm has the best N₂ and CH₄ adsorption selectivity, while its diffusion selectivity is not obvious.

关键词: Activated carbon, Coalbed methane, GCMC, MD, Molecular simulation

Abstract: In this paper, a model of activated carbon was established by molecular simulation and the separation performance of N₂ and CH₄ on activated carbon was studied. In order to evaluate the adsorption selectivity and diffusion selectivity of N₂ and CH₄, Grand Canonical Monte Carlo and molecular dynamic methods were used to obtain equilibrium adsorption isotherms and mean square displacements of N₂ and CH₄ on activated carbon with different pore sizes. Research results showed that the difference in adsorption isosteric heat of N₂ and CH₄ at the pore size of 0.46 nm is the largest, which is 5.759 and 7.03 kcal·mol^-1 (1 cal=4.184 J), respectively. Activated carbon with pore size of 0.46 nm has the best N₂ and CH₄ adsorption selectivity, while its diffusion selectivity is not obvious.

Key words: Activated carbon, Coalbed methane, GCMC, MD, Molecular simulation

Gaofei Chen, Yaxiong An, Yuanhui Shen, Yayan Wang, Zhongli Tang, Bo Lu, Donghui Zhang. Effect of pore size on CH₄/N₂ separation using activated carbon[J]. 中国化学工程学报, 2020, 28(4): 1062-1068.

Gaofei Chen, Yaxiong An, Yuanhui Shen, Yayan Wang, Zhongli Tang, Bo Lu, Donghui Zhang. Effect of pore size on CH₄/N₂ separation using activated carbon[J]. Chinese Journal of Chemical Engineering, 2020, 28(4): 1062-1068.

参考文献

[1] R.M. Flores, Coalbed methane:From hazard to resource, Int. J. Coal Geol. 35(1998) 3-26.
[2] J.L. Clayton, Geochemistry of coalbed gas-A review, Int. J. Coal Geol. 35(1998) 159-173.
[3] R.M. Bustin, C.R. Clarkson, Geological controls on coalbed methane reservoir capacity and gas content, Int. J. Coal Geol. 38(1998) 3-26.
[4] M. Cecopierigomez, J. Palaciosalquisira, J. Dominguez, On the limits of gas separation in CO₂/CH₄, N₂/CH₄ and CO₂/N₂ binary mixtures using polyimide membranes, J Membrane Sci 293(1-2) (2007) 53-65.
[5] X.Y. Chen, H. Vinh-Thang, A.A. Ramirez, D. Rodrigue, S. Kaliaguine, Membrane gas separation technologies for biogas upgrading, RSC Adv. 5(31) (2015) 24399-24448.
[6] K.A. Lokhandwala, I. Pinnau, Z. He, K.D. Amo, A.R. Dacosta, J.G. Wijmans, R.W. Baker, Membrane separation of nitrogen from natural gas:A case study from membrane synthesis to commercial deployment, J Membrane Sci 346(2) (2010) 270-279.
[7] H. Yang, C. Yin, B. Jiang, D. Zhang, Optimization and analysis of a VPSA process for N₂/CH₄ separation, Sep. Purif. Technol. 134(2014) 232-240.
[8] W. Sun, Y. Shen, D. Zhang, H. Yang, H. Ma, A systematic simulation and proposed optimization of the pressure swing adsorption process for N₂/CH₄ separation under external disturbances, Ind. Eng. Chem. Res. 54(30) (2015) 7489-7501.
[9] Y. Zhou, Q. Fu, Y. Shen, W. Sun, D. Zhang, D. Li, H. Yan, Upgrade of low-concentration oxygen-bearing coal bed methane by a vacuum pressure swing adsorption process:performance study and safety analysis, Enger & fuels 30(2) (2016) 1496-1509.
[10] A. Abdullah, I. Idris, I.K. Shamsudin, M.R. Othman, Methane enrichment from high carbon dioxide content natural gas by pressure swing adsorption, J Nat Gas Sci Eng 69(2019)102929.
[11] M. Spitoni, M. Pierantozzi, G. Comodi, F. Polonara, A. Arteconi, Theoretical evaluation and optimization of a cryogenic technology for carbon dioxide separation and methane liquefaction from biogas, J Nat Gas Sci Eng 62(2019) 132-143.
[12] D.M. Ruthven, S. Farooq, K.S. Knaebel, Pressure swing adsorption, VCH Publishers, Inc., America, 1994.
[13] B. Yuan, X. Wu, Y. Chen, J. Huang, H. Luo, S. Deng, Adsorption of CO₂, CH₄ and N₂ on ordered mesoporous carbon:Approach for greenhouse gases capture and biogas upgrading, Environ Sci Technol 47(10) (2013) 5474-5480.
[14] H. Yi, F. Li, P. Ning, X. Tang, J. Peng, Y. Li, H. Deng, Adsorption separation of CO₂, CH₄ and N₂ on microwave activated carbon, Chem. Eng. J. 215-216(2013) 635-642.
[15] Z. Yang, D. Wang, Z. Meng, Y. Li, Adsorption separation of CH₄/N₂ on modified coalbased carbon molecular sieve, Sep. Purif. Technol. 218(2019) 130-137.
[16] D.D. Do, H.D. Do, Adsorption of supercritical fluids in non-porous and porous carbons:Analysis of adsorbed phase volume and density, Carbon 41(9) (2003) 1777-1791.
[17] G.P. Lithoxoos, A. Labropoulos, L.D. Peristeras, N. Kanellopoulos, J. Samios, I.G. Economou, Adsorption of N₂, CH₄, CO and CO₂ gases in single walled carbon nanotubes:A combined experimental and Monte Carlo molecular simulation study, J. Supercrit. Fluids 55(2) (2010) 510-523.
[18] Q. Fu, H. Tanaka, M.T. Miyahara, Y. Qin, Y. Shen, D. Zhang, CHF₃-CHClF₂ binary competitive adsorption equilibria in graphitic slit pores:Monte Carlo simulations and breakthrough curve experiments, Ind. Eng. Chem. Res. 57(18) (2018) 6440-6450.
[19] B. Zhang, J. Kang, T. Kang, Monte Carlo simulations of methane adsorption on kaolinite as a function of pore size, J Nat Gas Sci Eng 49(2018) 410-416.
[20] Q. Wang, L. Huang, Molecular insight into competitive adsorption of methane and carbon dioxide in montmorillonite:Effect of clay structure and water content, Fuel 239(2019) 32-43.
[21] B. Demir, M.G. Ahunbay, CO₂/CH₄ separation in ion-exchanged zeolite-like metal organic frameworks with sodalite topology (sod-ZMOFs), J. Phys. Chem. C 117(30) (2013) 15647-15658.
[22] Y. An, Q. Fu, D. Zhang, Y. Wang, Z. Tang, Performance evaluation of activated carbon with different pore sizes and functional groups for VOC adsorption by molecular simulation, Chemosphere 227(2019) 9-16.
[23] Y. Liu, J. Wilcox, Effects of surface heterogeneity on the adsorption of CO₂ in microporous carbons, Environ Sci Technol 46(3) (2012) 1940-1947.
[24] A.V. Shevade, S. Jiang, K.E. Gubbins, Molecular simulation study of water-methanol mixtures in activated carbon pores, J. Chem. Phys. 113(16) (2000) 6933-6942.
[25] B. Delley, Fast calculation of electrostatics in crystals and large molecules, J. Phys. Chem. 100(15) (1996) 6107-6110.
[26] B. Delley, DMol3 DFT studies:From molecules and molecular environments to surfaces and solids, Comp. Mater. Sci. 17(2-4) (2000) 122-126.
[27] D. Lim, A.S. Negreira, J. Wilcox, DFT studies on the interaction of defective graphene-supported Fe and Al nanoparticles, J. Phys. Chem. C 115(18) (2011) 8961-8970.
[28] J.P. Perdew, K. Burke, M. Ernzerhof, Generalized gradient approximation made simple, Phys. Rev. Lett. 77(18) (1996) 3865-3868.
[29] B. Wang, J. Nisar, R. Ahuja, Molecular simulation for gas adsorption at NiO (100) surface, Acs Appl. Mater. Inter. 4(10) (2012) 5691-5697.
[30] S. Grimme, J. Antony, S. Ehrlich, H. Krieg, A consistent and accurateab initio parametrization of density functional dispersion correction (DFT-D) for the 94 elements H-Pu, J. Chem. Phys. 132(15) (2010), 154104.
[31] H. Sun, P. Ren, J.R. Fried, The COMPASS force field:Parameterization and validation for phosphazenes, Comput. Theor. Polym. Sci. 8(1-2) (1998) 229-246.
[32] H. Sun, COMPASS:An ab initio force-field optimized for condensed-phase ApplicationssOverview with details on alkane and benzene compounds, J. Phys. Chem. B 102(1998) 7338-7364.
[33] S.W. Bunte, H. Sun, Molecular modeling of energetic materials:The parameterization and validation of nitrate esters in the COMPASS force field, J. Phys. Chem. B 104(11) (2000) 2477-2489.
[34] A. Gupta, S. Chempath, M.J. Sanborn, L.A. Clark, R.Q. Snurr, Object-oriented programming paradigms for molecular modeling, Mol. Simulat. 29(1) (2003) 29-46.
[35] D. Frenkel, B. Smit, Understanding Molecular Simulation from Algorithms to Applications, Academic Press, 1996.
[36] R. Babarao, J. Jiang, Diffusion and separation of CO₂ and CH₄ in Silicalite, C168 Schwarzite, and IRMOF-1:A comparative study from molecular dynamics simulation, Langmuir 24(10) (2008) 5474-5484.
[37] S. Keskin, J. Liu, R.B. Rankin, J.K. Johnson, D.S. Sholl, Progress, opportunities, and challenges for applying atomically detailed modeling to molecular adsorption and transport in metal-organic framework materials, Ind. Eng. Chem. Res. 48(5) (2009) 2355-2371.
[38] D. Dubbeldam, S. Calero, D.E. Ellis, R.Q. Snurr, RASPA:Molecular simulation software for adsorption and diffusion in flexible nanoporous materials, Mol. Simulat. 42(2) (2016) 81-101.
[39] P.A. Gauden, A.P. Terzyk, S. Furmaniak, J. Włoch, P. Kowalczyk, W. Zieliński, MD simulation of organics adsorption from aqueous solution in carbon slit-like pores. Foundations of the pore blocking effect, Journal of Physics. Condensed Matter:An Institute of Physics Journal 26(5) (2014), 55008.
[40] Y. Park, D. Moon, Y. Kim, H. Ahn, C. Lee, Adsorption isotherms of CO₂, CO, N₂, CH₄, Ar and H₂ on activated carbon and zeolite LiX up to 1.0 MPa, Adsorption 20(4) (2014) 631-647.
[41] D. Do Duong, Absorption Analysis Equilibria and Kinetics, Imperial College Press, London, 1998.
[42] R. Reich, W.T. Ziegler, K.A. Rogers, Adsorption of methane, ethane, and ethylene gases and their binary and ternary mixtures and carbon dioxide on activated carbon at 212-301 K and pressures to 35 atmospheres, Industrial & Engineering Chemistry Process Design and Development 19(3) (1980) 336-344.

Effect of pore size on CH₄/N₂ separation using activated carbon

Effect of pore size on CH₄/N₂ separation using activated carbon

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	Yifan Jiang, Bingqi Xie, Jisong Zhang. Highly reactive and reusable heterogeneous activated carbons-based palladium catalysts for Suzuki-Miyaura reaction[J]. 中国化学工程学报, 2023, 60(8): 165-172.
[2]	Huan-Huan Yin, Yin-Lei Han, Xiao Yan, Yi-Xin Guan. Proanthocyanidins prevent tau protein aggregation and disintegrate tau filaments[J]. 中国化学工程学报, 2023, 57(5): 63-71.
[3]	Qiaoqiao Liu, Guihong Lin, Jian Zhou, Liangliang Huang, Chang Liu. Hydrogen-bond mediated and concentrate-dependent NaHCO₃ crystal morphology in NaHCO₃–Na₂CO₃ aqueous solution: Experiments and computer simulations[J]. 中国化学工程学报, 2023, 55(3): 49-58.
[4]	Baodong Zhao, Yinglei Wang, Fulei Gao, Yajing Liu, Weixiao Liu, Feng Ding. Understanding the alkyl effect of geminal dinitropropyl ester energetic plasticizers on hydroxyl terminated polybutadiene (HTPB): Simultaneous tuning on low temperature behavior and processability[J]. 中国化学工程学报, 2023, 54(2): 364-371.
[5]	Huan Xiang, Huiping Zhang, Pengfei Liu, Ying Yan. Adsorption dynamics of ethane from air in structured fixed beds with different microfibrous composites[J]. 中国化学工程学报, 2023, 53(1): 14-24.
[6]	Peng Yang, Shengzhe Jia, Yan Wang, Zongqiu Li, Songgu Wu, Jingkang Wang, Junbo Gong. Dissolution behavior, thermodynamic and kinetic analysis of malonamide by experimental measurement and molecular simulation[J]. 中国化学工程学报, 2023, 53(1): 260-269.
[7]	Yadong Li, Yuanhui Shen, Zhaoyang Niu, Junpeng Tian, Donghui Zhang, Zhongli Tang, Wenbin Li. Process analysis of temperature swing adsorption and temperature vacuum swing adsorption in VOCs recovery from activated carbon[J]. 中国化学工程学报, 2023, 53(1): 346-360.
[8]	Xing Su, Ning Qiao, Bao-Chang Sun. A route for the study on mass transfer enhancement by adding particles in liquid phase[J]. 中国化学工程学报, 2022, 48(8): 158-165.
[9]	Wenjian Zhu, Xuhua Shen, Rui Ou, Manoj Murugesan, Aihua Yuan, Jianfeng Liu, Xiaocai Hu, Zhen Yang, Ming Shen, Fu Yang. Superhigh selective capture of volatile organic compounds exploiting cigarette butts-derived engineering carbonaceous adsorbent[J]. 中国化学工程学报, 2022, 46(6): 194-206.
[10]	Hojatollah Moradi, Hedayat Azizpour, Hossein Bahmanyar, Mohammad Emamian. Molecular dynamic simulation of carbon dioxide, methane, and nitrogen adsorption on Faujasite zeolite[J]. 中国化学工程学报, 2022, 43(3): 70-76.
[11]	Tongan Yan, Minman Tong, Qingyuan Yang, Dahuan Liu, Yandong Guo, Chongli Zhong. Large-scale simulations of CO₂ diffusion in metal-organic frameworks with open Cu sites[J]. 中国化学工程学报, 2022, 42(2): 1-9.
[12]	Puxu Liu, Yong Wang, Yang Chen, Xiaoqing Wang, Jiangfeng Yang, Libo Li, Jinping Li. Stable titanium metal-organic framework with strong binding affinity for ethane removal[J]. 中国化学工程学报, 2022, 42(2): 35-41.
[13]	Tongan Yan, Dahuan Liu, Qingyuan Yang, Chongli Zhong. Screening and design of COF-based mixed-matrix membrane for CH₄/N₂ separation[J]. 中国化学工程学报, 2022, 42(2): 170-177.
[14]	Zenan Wang, Xin Zheng, Yan Wang, Heng Lin, Hui Zhang. Evaluation of phenanthrene removal from soil washing effluent by activated carbon adsorption using response surface methodology[J]. 中国化学工程学报, 2022, 42(2): 399-405.
[15]	Jule Ma, Peiwen Xiao, Pingmei Wang, Xue Han, Jianhui Luo, Ruifang Shi, Xuan Wang, Xianyu Song, Shuangliang Zhao. Molecular dynamics simulation study on π-π stacking of Gemini surfactants in oil/water systems[J]. 中国化学工程学报, 2022, 50(10): 335-346.