Influence of Nonionic Surfactant Addition on Drag Reduction of Water Based Nanofluid in a Small Diameter Pipe

doi:10.1016/S1004-9541(13)60447-4

Chinese Journal of Chemical Engineering ›› 2013, Vol. 21 ›› Issue (1): 104-108.DOI: 10.1016/S1004-9541(13)60447-4

• 研究简报 • 上一篇

Influence of Nonionic Surfactant Addition on Drag Reduction of Water Based Nanofluid in a Small Diameter Pipe

Micha? Drzazga, Andrzej Gierczycki, Grzegorz Dzido, Marcin Lemanowicz

Silesian University of Technology, Faculty of Chemistry, Department of Chemical and Process Engineering, Gliwice, Poland

收稿日期:2011-12-23 修回日期:2012-10-20 出版日期:2013-02-28 发布日期:2013-02-04
通讯作者: Michał Drzazga
基金资助:
Supported by the State Committee for Scientific Research (Poland) (NN209764040). Michal Drzazga received the Scholarship under the Project DoktoRIS-Scholarship Program for Innovative Silesia Co-financed by the European Union under the European Social Fund.

Influence of Nonionic Surfactant Addition on Drag Reduction of Water Based Nanofluid in a Small Diameter Pipe

Micha? Drzazga, Andrzej Gierczycki, Grzegorz Dzido, Marcin Lemanowicz

Silesian University of Technology, Faculty of Chemistry, Department of Chemical and Process Engineering, Gliwice, Poland

Received:2011-12-23 Revised:2012-10-20 Online:2013-02-28 Published:2013-02-04
Supported by:
Supported by the State Committee for Scientific Research (Poland) (NN209764040). Michal Drzazga received the Scholarship under the Project DoktoRIS-Scholarship Program for Innovative Silesia Co-financed by the European Union under the European Social Fund.

摘要/Abstract

摘要： The goal of this research was to determine the impact of nonionic surfactants on drag reduction effect in water and metal oxide nanofluid. Two nonionic surfactants (Rokacet O7 and Rokanol K7) and copper(II) oxide water-based nanofluid were examined. Friction factors in a 4 mm diameter pipe for the Reynolds number between 8000 and 50000 were determined. Results showed that addition of nonionic surfactants caused the decrease of friction factor in water and nanofluid. The drag reduction effect was similar in both cases. Presence of nanoparticles in the system has no great influence on drag reduction effect.

关键词: nanofluid, nonionic surfactant, drag reduction

Abstract: The goal of this research was to determine the impact of nonionic surfactants on drag reduction effect in water and metal oxide nanofluid. Two nonionic surfactants (Rokacet O7 and Rokanol K7) and copper(II) oxide water-based nanofluid were examined. Friction factors in a 4 mm diameter pipe for the Reynolds number between 8000 and 50000 were determined. Results showed that addition of nonionic surfactants caused the decrease of friction factor in water and nanofluid. The drag reduction effect was similar in both cases. Presence of nanoparticles in the system has no great influence on drag reduction effect.

Key words: nanofluid, nonionic surfactant, drag reduction

Michał Drzazga, Andrzej Gierczycki, Grzegorz Dzido, Marcin Lemanowicz . Influence of Nonionic Surfactant Addition on Drag Reduction of Water Based Nanofluid in a Small Diameter Pipe[J]. Chinese Journal of Chemical Engineering, 2013, 21(1): 104-108.

Michał Drzazga, Andrzej Gierczycki, Grzegorz Dzido, Marcin Lemanowicz. Influence of Nonionic Surfactant Addition on Drag Reduction of Water Based Nanofluid in a Small Diameter Pipe[J]. Chin.J.Chem.Eng., 2013, 21(1): 104-108.

参考文献

1 Wang, X., Xu, X., Choi, S.U.S., “Thermal conductivity of nanoparticle-Fluid mixture”, J. Thermophys. Heat Transfer., 13, 474-480 (1999).

2 Eastmann, J.A., Choi, S.U.S., Li, S., Yu, W., Thompson, L.J., “Anomalously increased effective thermal conductivities of ethylene glycol-based nanofluid containing copper nanoparticles”, App. Phys. Lett., 78, 718-720 (2001).

3 Choi, S.U.S., Zhang, Z.G., Yu, W., Lockwood, F.E., Grulke, E.A., “Anomalous thermal conductivity enhancement in nano-tube suspension”, Appl. Phys. Lett., 79, 2252-2254 (2001).

4 Xie, H., Wang, J., Xi, T., Liu, Y., “Thermal conductivity enhancement of suspensions containing nanosized alumina particles”, J. Appl. Phys., 91, 4568-4572 (2002).

5 Xie, H., Wang, J., Xi, T., Liu, Y., “Thermal conductivity of suspensions containing nanosized SiC particles”, Int. J. Thermophys., 23, 571-579 (2002).

6 Marsher, S.M.S., Leong, K.C., Yang, C., “Enhanced thermal conductivity of TiO₂-water based nanofluids”, Int. J. Therm. Sci., 44, 367-373 (2005).

7 Prasher, R., Bhattacharya, P., Phelan, P. E., “Thermal conductivity of nanoscale colloidal solutions (nanofluids)”, Phys. Rev. Lett., 94, 025901 (2005).

8 Xuan, Y., Li, Q., “Investigation on convective heat transfer and flow features of nanofluids”, J. Heat Transfer, 125, 151-155 (2003).

9 Wen, D., Ding, Y., “Experimental investigation into convective heat transfer of nanofluids at the entrance region under laminar flow conditions”, Int. J. Heat Mass Tran., 47, 5181-5188 (2004).

10 Das, S.K., Putra, N., Roetzel, W., “Pool boiling characteristics of nano-fluids”, Int. J. Heat Mass Tranfer, 46, 851-862 (2003).

11 Garg, J., Poudel, B., Chiesa, M., Gordon, J.B., Ma, J.J., Wang, J.B., Ren, Z.F., Kang, Y.T., Ohtani, H., Nanda, J., McKinley, G.H., Chen, G., “Enhanced thermal conductivity and viscosity of copper nanoparticles in ethylene glycol nanofluid”, J. Appl. Phys., 103, 74301 (2008).

12 Peng, H., Ding, G., Jiang, W., Hu, H., Gao, Y., “Measurement and correlation of frictional pressure drop of refrigerant-based nanofluid flow boiling inside a horizontal smooth tube”, Int. J. Refrig., 32, 1756-1764 (2009).

13 Liao, L., Liu, Z.H., “Forced convective flow drag and heat transfer characteristics of carbon nanotube suspensions in a horizontal small tube”, Heat Mass Transfer, 45, 1129-1136 (2009).

14 Fotukian, S.M., Nasr, E.M., “Experimental study of turbulent convective heat transfer and pressure drop of dilute CuO/water nanofluid inside a circular tube”, Int. Commun. Heat Mass, 37, 214-219 (2010).

15 Prasher, R., Song, D., Wang, J., Phelan, P., “Measurements of nanofluid viscosity and its implications for thermal applications”, Appl. Phys. Lett., 89, 133108 (2006).

16 Chen, H., Ding, Y., Tan, C., “Rheological behaviour of nanofluids”, New J. Phys., 9, 367 (2007).

17 Teipel, U., Förter-Barth, U., “Rheology of nano-scale aluminum suspensions”, Propell. Explos. Pyrot., 26, 268-272 (2001).

18 Davis, V.A., Ericson, L.M., Parra-Vasquez, A.N.G., Fan, H., Wang, Y., Prieto, V., Longoria, J.A., Ramesh, S., Saini, R.K., Kittrell, C., Billups, W.E., Wade, A.W., Hauge, R.H., Smalley, R.E., Pasquali, M., “Phase behavior and rheology of SWNTs in superacids”, Macromolecules, 37, 154-160 (2004).

19 Kwak, K., Kim, C., “Viscosity and thermal conductivity of copper oxide nanofluid dispersed in ethylene glycol”, Korea-Australia Rheol. J., 17, 35-40 (2005).

20 Kole, M., Dey, T.K., “Viscosity of alumina nanoparticles dispersed in car engine coolant”, Exp. Therm. Fluid Sci., 34, 677-683 (2010).

21 Li, X., Zhu, D., Wang, X., “Experimental investigation on viscosity of Cu-H₂O nanofluid”, J. Wuhan Univ. Technol., 24, 48-52 (2009).

22 Yu, M., Lin, J., Xiong, H., “Quadrature method of moments for nanoparticle coagulation and diffusion in the planar impinging jet flow”, Chin. J. Chem. Eng., 15, 828-836 (2007).

23 Lin, J., Lin, P., Yu, M., Chen, H., “Nanoparticle transport and coagulation in bends of circular cross section via a new moment method”, Chin. J. Chem. Eng., 18, 1-9 (2010).

24 Toms, B.A., “Some observations on the flow of linear polymer solutions through straight tubes at large Reynolds number”, In: Proc. 1st Int. Congr. Rheology, Burgers, J.M., ed., North Holland, Amsterdam, vol. 2, 135-141 (1949).

25 Toms, B.A., “On the early experiments on drag reduction by polymers”, Phys. Fluids, 20, S3-S5 (1977).

26 Yu, Z., Lin, J., Shao, X., Zhang, W., “Stability and drag reduction in transient channel flow of fibre suspensions”, Chin. J. Chem. Eng., 12, 319-323 (2004).

27 Savings, J.G., “A stress-controlled drag reduction phenomenon”, Rheol. Acta, 6, 323-330 (1967).

28 Cates, M.E., Candau, S.J., “Statics and dynamics of worm-like surfactant micelles”, J. Phys. Condens. Matter., 2, 6869-6892 (1990).

29 Ohlendorf, D., Interthal, W., Hoffmann, H., “Surfactant systems for drag reduction: Physico-chemical properties and rheological behaviour”, Rheol. Acta, 25, 468-486 (1986).

30 Usui, H., Itoh, T., Saeki, T., “On pipe diameter effects in surfactant drag-reducing pipe flows”, Rheol. Acta, 37, 122-128 (1998).

31 Gasljevic, K., Aguilar, G., Matthys, E.F., “On two distinct types of drag-reducing fluids, diameter scaling, and turbulent profiles”, J. Non-Newton. Fluid, 96, 405-425 (2001).

32 Liu, Z.H., Liao, L., “Forced convective flow and heat transfer characteristics of aqueous drag-reducing fluid with carbon nanotubes added”, Int. J. Therm. Sci., 49, 2331-2338 (2010).

33 Haruki, N., Inaba, H., Horibe, A., Tanaka, S., “Viscosity measurements of ethylene glycol solution with flow drag reduction additives”, Heat Transfer-Asian Res., 35, 553-567 (2006).

34 Cho, S.H., Tae, S.B., Zaheeruddin, M., “Effect of fluid velocity, temperature, and concentration of non-ionic surfactants on drag reduction”, Energ. Conves. Manage., 48, 913-918 (2007).

35 Tamano, S., Itoh, M., Kato, K., Yokota, K., “Turbulent drag reduction in nonionic surfactant solutions”, Phys. Fluids, 22, 055102 (2010).

36 Zakin, J.L., Myska, J., Chara, Z., “New limiting drag reduction and velocity profile for non-polymeric additives systems”, AIChE J., 42, 3544-3546 (1996).

37 Namburu, P.K., Kulkarni, D.P., Misra, D., Das, D.K., “Viscosity of copper oxide nanoparticles dispersed in ethylene glycol and water mixture”, Exp. Therm. Fluid Sci., 32, 397-402 (2007).

[1]	Xiaoping Li, Jiaxin Pan, Jinwen Shi, Yanlin Chai, Songwei Hu, Qiaorong Han, Yanming Zhang, Xianwen Li, Dengwei Jing. Nanoparticle-induced drag reduction for polyacrylamide in turbulent flow with high Reynolds numbers[J]. 中国化学工程学报, 2023, 56(4): 290-298.
[2]	Shabnam Ghahremanian, Abbas Abbassi, Zohreh Mansoori, Davood Toghraie. Effect of copper nanoparticles on thermal behavior of two-phase argon-copper nanofluid flow in rough nanochannels with focusing on the interface properties and heat transfer using molecular dynamics simulation[J]. 中国化学工程学报, 2022, 42(2): 344-350.
[3]	Yu-Liang Sun, Davood Toghraie, Omid Ali Akbari, Farzad Pourfattah, As'ad Alizadeh, Navid Ghajari, Mehran Aghajani. Thermal performance and entropy generation for nanofluid jet injection on a ribbed microchannel with oscillating heat flux: Investigation of the first and second laws of thermodynamics[J]. 中国化学工程学报, 2022, 42(2): 450-464.
[4]	Amin Shahsavar, Majid Jafari, Pouyan Talebizadehsardari, Davood Toghraie. Hydrothermal and entropy generation specifications of a hybrid ferronanofluid in microchannel heat sink embedded in CPUs[J]. 中国化学工程学报, 2021, 32(4): 27-38.
[5]	Mehdi Bahiraei, Ali Monavari. Impact of nanoparticle shape on thermohydraulic performance of a nanofluid in an enhanced microchannel heat sink for utilization in cooling of electronic components[J]. 中国化学工程学报, 2021, 40(12): 36-47.
[6]	Najeebullah Lashari, Tarek Ganat. Emerging applications of nanomaterials in chemical enhanced oil recovery: Progress and perspective[J]. 中国化学工程学报, 2020, 28(8): 1995-2009.
[7]	Milad Gholami, Mohammad Reza Nazari, Mohammad Hossien Talebi, Farzad Pourfattah, Omid Ali Akbari, Davood Toghraie. Natural convection heat transfer enhancement of different nanofluids by adding dimple fins on a vertical channel wall[J]. 中国化学工程学报, 2020, 28(3): 643-659.
[8]	Mohsen Izadi, Masoud Javanahram, Seyed Mohsen Hashem Zadeh, Dengwei Jing. Hydrodynamic and heat transfer properties of magnetic fluid in porous medium considering nanoparticle shapes and magnetic field-dependent viscosity[J]. 中国化学工程学报, 2020, 28(2): 329-339.
[9]	Sajad Mir, Omid Ali Akbari, Davood Toghraie, Ghanbarali Sheikhzadeh, Ali Marzban, Saeid Mir, Pouyan Talebizadehsardari. A comprehensive study of two-phase flow and heat transfer of water/Ag nanofluid in an elliptical curved minichannel[J]. 中国化学工程学报, 2020, 28(2): 383-402.
[10]	Amin Shahsavar, Sajad Entezari, Davood Toghraie, Pouya Barnoon. Effects of the porous medium and water-silver biological nanofluid on the performance of a newly designed heat sink by using first and second laws of thermodynamics[J]. 中国化学工程学报, 2020, 28(11): 2928-2937.
[11]	Nadia Esfandiari, Reza Zareinezhad, Zahra Habibi. The investigation and optimization of drag reduction in turbulent flow of Newtonian fluid passing through horizontal pipelines using functionalized magnetic nanophotocatalysts and lecithin[J]. 中国化学工程学报, 2020, 28(1): 63-75.
[12]	M. A. Asidin, E. Suali, T. Jusnukin, F. A. Lahin. Review on the applications and developments of drag reducing polymer in turbulent pipe flow[J]. 中国化学工程学报, 2019, 27(8): 1921-1932.
[13]	Xiaoyu Hu, Diannan Lu. Intensification of chemical separation engineering by nanostructured channels and nanofluidics: From theories to applications[J]. 中国化学工程学报, 2019, 27(6): 1439-1448.
[14]	A.A. Alfaryjat, A. Dobrovicescu, D. Stanciu. Influence of heat flux and Reynolds number on the entropy generation for different types of nanofluids in a hexagon microchannel heat sink[J]. Chinese Journal of Chemical Engineering, 2019, 27(3): 501-513.
[15]	Yousef Kazemzadeh, Sanaz Shojaei, Masoud Riazi, Mohammad Sharifi. Review on application of nanoparticles for EOR purposes: A critical review of the opportunities and challenges[J]. Chinese Journal of Chemical Engineering, 2019, 27(2): 237-246.

Influence of Nonionic Surfactant Addition on Drag Reduction of Water Based Nanofluid in a Small Diameter Pipe

Influence of Nonionic Surfactant Addition on Drag Reduction of Water Based Nanofluid in a Small Diameter Pipe

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价