Effect of Ferric Chloride on the Properties of Biological Sludge in Co-precipitation Phosphorus Removal Process

doi:10.1016/S1004-9541(13)60511-X

Chinese Journal of Chemical Engineering ›› 2013, Vol. 21 ›› Issue (5): 564-568.DOI: 10.1016/S1004-9541(13)60511-X

• 能源、资源与环境技术 • 上一篇下一篇

Effect of Ferric Chloride on the Properties of Biological Sludge in Co-precipitation Phosphorus Removal Process

张志斌¹, 李艺¹, 魏垒垒^1,2, 吕育锋¹, 王猛¹, 高宝玉³

1 School of Environmental and Municipal Engineering, Shandong Jianzhu University, Jinan 250101, China;
2 Everbright Water(Jinan) Limited, Jinan 250032, China;
3 School of Environmental Science and Engineering, Shandong University, Jinan 250000, China

收稿日期:2012-05-11 修回日期:2012-12-25 出版日期:2013-05-28 发布日期:2013-05-31
通讯作者: ZHANG Zhibin
基金资助:
Supported by the Major National Water Sci-Tech Projects of China (2009ZX07210-009) and the Department of Environmental Protection of Shandong Province (2006032, 2060403).

Effect of Ferric Chloride on the Properties of Biological Sludge in Co-precipitation Phosphorus Removal Process

ZHANG Zhibin¹, LI Yi¹, WEI Leilei^1,2, LÜ Yufeng¹, WANG Meng¹, GAO Baoyu³

1 School of Environmental and Municipal Engineering, Shandong Jianzhu University, Jinan 250101, China;
2 Everbright Water(Jinan) Limited, Jinan 250032, China;
3 School of Environmental Science and Engineering, Shandong University, Jinan 250000, China

Received:2012-05-11 Revised:2012-12-25 Online:2013-05-28 Published:2013-05-31
Supported by:
Supported by the Major National Water Sci-Tech Projects of China (2009ZX07210-009) and the Department of Environmental Protection of Shandong Province (2006032, 2060403).

摘要/Abstract

摘要： This paper studied the effect of ferric chloride on waste sludge digestion, dewatering and sedimentation under the optimized doses in co-precipitation phosphorus removal process. The experimental results showed that the concentration of mixed liquid suspended solid (MLSS) was 2436 mg稬^-1 and 2385 mg稬^-1 in co-precipitation phosphorus removal process (CPR) and biological phosphorous removal process (BPR), respectively. The sludge reduction ratio for each process was 22.6% and 24.6% in aerobic digestion, and 27.6% and 29.9% in anaerobic digestion, respectively. Due to the addition of chemical to the end of aeration tank, the sludge content of CPR was slightly higher than that of BPR, but the sludge reduction rate for both processes had no distinct difference. The sludge volume index (SVI) and sludge specific resistance of BPR were 126 ml穏^-1 and 11.7?10¹² m穔g^-1, respectively, while those of CPR were only 98 ml穏^-1 and 7.1?10¹² m穔g^-1, indicating that CPR chemical could improve sludge settling and dewatering.

关键词: biological phosphorous removal process, chemical co-precipitation phosphorus removal process, ferric chloride, municipal wastewater, sludge

Abstract: This paper studied the effect of ferric chloride on waste sludge digestion, dewatering and sedimentation under the optimized doses in co-precipitation phosphorus removal process. The experimental results showed that the concentration of mixed liquid suspended solid (MLSS) was 2436 mg稬^-1 and 2385 mg稬^-1 in co-precipitation phosphorus removal process (CPR) and biological phosphorous removal process (BPR), respectively. The sludge reduction ratio for each process was 22.6% and 24.6% in aerobic digestion, and 27.6% and 29.9% in anaerobic digestion, respectively. Due to the addition of chemical to the end of aeration tank, the sludge content of CPR was slightly higher than that of BPR, but the sludge reduction rate for both processes had no distinct difference. The sludge volume index (SVI) and sludge specific resistance of BPR were 126 ml穏^-1 and 11.7?10¹² m穔g^-1, respectively, while those of CPR were only 98 ml穏^-1 and 7.1?10¹² m穔g^-1, indicating that CPR chemical could improve sludge settling and dewatering.

Key words: biological phosphorous removal process, chemical co-precipitation phosphorus removal process, ferric chloride, municipal wastewater, sludge

张志斌, 李艺, 魏垒垒, 吕育锋, 王猛, 高宝玉. Effect of Ferric Chloride on the Properties of Biological Sludge in Co-precipitation Phosphorus Removal Process[J]. Chinese Journal of Chemical Engineering, 2013, 21(5): 564-568.

ZHANG Zhibin, LI Yi, WEI Leilei, LÜ Yufeng, WANG Meng, GAO Baoyu. Effect of Ferric Chloride on the Properties of Biological Sludge in Co-precipitation Phosphorus Removal Process[J]. Chin.J.Chem.Eng., 2013, 21(5): 564-568.

参考文献

1 Chen, X., Huang, X.R., Wang, X.Z., Sun, D.Z., "Phosphate adsorption by ZnAlLa layered double hydroxides from excess sludge filtrate", CIESC Journal, 61 (4),955-9621 (2010). (in Chinese)

2 Liu, H., Sun, Y.F., Jia, X.S., Zhou, K.Q., Liu, J.P., "Identification of fermentation and non-fermentation denitrifying phosphorous removing bacteria (DPB) and their metabolic mechanism", CIESC Journal, 61 (9),2454-2462 (2010). (in Chinese)

3 Broughton, A., Pratt, S., Shilton, A., "Enhanced biological phosphorus removal for high-strength wastewater with a low COD: P ratio", Bioresource Technol., 99 (5),1236-1241 (2008).

4 Carlos, M.L., Christine, M.H., Damir, B., Huub, J.G., Mark, C.M., "Factors affecting the microbial populations at full-scale enhanced biological phosphorus removal (EBPR) wastewater treatment plants in the Netherlands", Water Res., 42 (10-11),2349-2360 (2008).

5 Chen, Y.G., Randall, A.A., McCue, T., "The efficiency of enhanced biological phosphorus removal from real wastewater affected by different ratios of acetic to propionic acid", Water Res., 38 (1),27-36 (2004).

6 Monclús, H., Sipma, J., Ferrero, G., Comas, J., Rodriguez-Roda, I., "Optimization of biological nutrient removal in a pilot plant UCT-MBR treating municipal wastewater during start-up", Desalination., 250 (2),592-597 (2010).

7 Ahn, K.H., Song, K.G., Choa, E., Cho, J., Yun, H., Lee, S., "Enhanced biological phosphorus and nitrogen removal using a sequencing anoxic/anaerobic membrane bioreactor (SAM) process", Desalination., 175 (1-3),345-352 (2003).

8 Patel, A., Zhu, J., Nakhla, G., "Simultaneous carbon, nitrogen and phosphorous removal from municipal wastewater in a circulating fluidized bed bioreactor", Chemosphere, 65 (7),1103-1112 (2006).

9 Huang, L.H., Zhang, Z.B., Bian, X.J., Ma, L.M., "Full-scale test on inverted A₂/O process", China Water & Wastewater, 13,12-15 (2004).

10 Deng, L.W., Zheng, P., Chen, Z.A., "Improvement in post-treatment of digested swine wastewater", Bioresource Technol., 99 (8),3136-3145 (2008).

11 Feo, G.D., Gisi, S.D., Galasso, M., "Definition of a practical multi-criteria procedure for selecting the best coagulant in a chemically assisted primary sedimentation process for the treatment of urban wastewater", Desalination, 230 (1-3),229-238 (2008).

12 Inês, S.F., Carlos, A.V., Freitas, A., "Conceptual design of industrial wastewater treatment processes: primary treatment", Computers & Chemical Engineering, 24 (2-7),1725-1730 (2000).

13 Kim, T.H., Park, C., Lee, J., Shin, E.B., Kim, S.Y., "Pilot scale treatment of textile wastewater by combined process (fluidized biofilm process-chemical coagulation-electrochemical oxidation)", Water Res., 36 (16),3979-3988 (2002).

14 Xing, L.J., Wang, X.H., "Characteristics of phosphorus removal from wastewater by biofilm sequencing batch reactor (SBR)", Biochem. Eng. J., 16 (3),279-285 (2003).

15 Wang, H.J., Wang, H.Z., "Mitigation of lake eutrophication: Loosen nitrogen control and focus on phosphorus abatement", Progress in Natural Science, 19 (10),1445-1451(2009).

16 Katz, I., Dosoretz, C.G., "Desalination of domestic wastewater effluents: phosphate removal as pretreatment", Desalination, 222 (1-3),230-242 (2008).

17 Wei, L., Yang, D.H., Xu, L., Jia, C., "Effect of return sludge pre-concentration on biological phosphorus removal in a novel oxidation ditch", Chin. J. Chem. Eng., 20 (4),747-753 (2012).

18 Wang, X.J., Xia, S.Q., Chen, L., Zhao, J.F., "Nutrients removal from municipal wastewater by chemical precipitation in a moving bed biofilm reactor", Process Biochem., 41 (4),824-828 (2006).

19 Cui, Y.W., Wang, S.Y., Li, J., "On-line monitoring for phosphorus removal process and bacterial community in sequencing batch reactor", Chin. J. Chem. Eng., 17 (3),484-492 (2009)

20 Zhang, Z.B., Bian, X.Y., Wang, W.C., "Research on optimizing dosage in the chemical-aid phosphorus removal process", Journal of Shandong Architecture University, 22,513-516 (2007).

21 Wei, F.S., Water and Wastewater Analysis Manual III, China Environment Science Publisher, Beijing (2002). (in Chinese)

22 Zhang, Z.B., Zhao, J.F., Xia, S.Q., Liu, C.Q., "Particle size distribution and removal by a chemical-biological flocculation process", J. Environ. Sci. China, 19 (5),559-563 (2007). Zheng, X.C., Li, Y.X., Nitrogen Removal and Phosphorous Removal from Wastewater VII, China Building Industry Publishers, Beijing (1998). (in Chinese)

[1]	Yuhan Zhu, Jia Wei, Jun Li. Decontamination of Cr(VI) from water using sewage sludge-derived biochar: Role of environmentally persistent free radicals[J]. 中国化学工程学报, 2023, 56(4): 97-103.
[2]	Zuhong Lin, Fushuai Xu, Lili Wang, Liyang Hu, Lingfu Zhu, Jie Tan, Zhifeng Li, Tingting Zhang. Characterization of oil component and solid particle of oily sludge treated by surfactant-assisted ultrasonication[J]. 中国化学工程学报, 2021, 34(6): 53-60.
[3]	Zhiying Guo, Liping Ma, Quxiu Dai, Xinbo Yang, Ran Ao, Jie Yang, Jing Yang, Wengang Li. Modified corn-core powder for enhancing sludge dewaterability: Synthesis, characterization and sludge dewatering performance[J]. 中国化学工程学报, 2021, 32(4): 368-377.
[4]	Nanhang Dong, Ruiqiang Huo, Ming Liu, Lisheng Deng, Zhengbing Deng, Guozhang Chang, Zhen Huang, Hongyu Huang. Chemical looping gasification of sewage sludge using copper slag modified by NiO as an oxygen carrier[J]. 中国化学工程学报, 2021, 29(1): 335-343.
[5]	Lingfu Zhu, Zuhong Lin, Jie Tan, Liyang Hu, Tingting Zhang. Application of hydrophobic ionic liquid [Bmmim][PF₆] in solvent extraction for oily sludge[J]. 中国化学工程学报, 2020, 28(9): 2294-2300.
[6]	Beverly S. Chittoo, Clint Sutherland. Column breakthrough studies for the removal and recovery of phosphate by lime-iron sludge: Modeling and optimization using artificial neural network and adaptive neuro-fuzzy inference system[J]. 中国化学工程学报, 2020, 28(7): 1847-1859.
[7]	Sajjad Haydar, Mehwish Anis, Misbah Afaq. Performance evaluation of hybrid constructed wetlands for the treatment of municipal wastewater in developing countries[J]. 中国化学工程学报, 2020, 28(6): 1717-1724.
[8]	Zhouchao Weng, Ekkachai Kanchanatip, Dwi Hantoko, Mi Yan, Hongcai Su, Sicheng Zhang, Guobin Wang. Improving supercritical water gasification of sludge by oil palm empty fruit bunch addition: Promotion of syngas production and heavy metal stabilization[J]. 中国化学工程学报, 2020, 28(1): 293-298.
[9]	Honggui Han, Xiaolong Wu, Luming Ge, Junfei Qiao. A sludge volume index (SVI) model based on the multivariate local quadratic polynomial regression method[J]. Chinese Journal of Chemical Engineering, 2018, 26(5): 1071-1077.
[10]	Jingyong Liu, Chao Liu, Guang Sun, Wuming Xie, Xiao'e Dang, Jiahong Kuo, Kenlin Chang, Jian Sun, Shuiyu Sun, Musa Buyukada, Fatih Evrendilek. Thermodynamic behaviors of Cu in interaction with chlorine, sulfur, phosphorus and minerals during sewage sludge co-incineration[J]. Chinese Journal of Chemical Engineering, 2018, 26(5): 1160-1170.
[11]	Syieluing Wong, Nurul Atiqah Najlaa Yac'cob, Norzita Ngadi, Onn Hassan, Ibrahim M. Inuwa. From pollutant to solution of wastewater pollution: Synthesis of activated carbon from textile sludge for dye adsorption[J]. Chinese Journal of Chemical Engineering, 2018, 26(4): 870-878.
[12]	Liyan Liu, Hao Yan, Wei Tan, Guorui Zhu. Influence of Na⁺, K⁺, Mg²⁺, Ca²⁺, and Fe³⁺ on filterability and settleability of drilling sludge[J]. , 2017, 25(5): 658-664.
[13]	Alexandros D. Kotzapetros, Panayotis A. Paraskevas, Athanasios S. Stasinakis. Design of a modern automatic control system for the activated sludge process in wastewater treatment[J]. Chinese Journal of Chemical Engineering, 2015, 23(8): 1340-1349.
[14]	Qin Lu, Haiyan Wu, Haoyan Li, Dianhai Yang. Enhanced biological nutrient removal inmodified carbon source division anaerobic anoxic oxic process with return activated sludge pre-concentration[J]. Chinese Journal of Chemical Engineering, 2015, 23(6): 1027-1034.
[15]	Xianli Shi, Li Deng, Fangfang Sun, Jieyu Liang, Xu Deng. Key factors governing alkaline pretreatment of waste activated sludge[J]. Chinese Journal of Chemical Engineering, 2015, 23(5): 842-846.

Effect of Ferric Chloride on the Properties of Biological Sludge in Co-precipitation Phosphorus Removal Process

Effect of Ferric Chloride on the Properties of Biological Sludge in Co-precipitation Phosphorus Removal Process

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价