2-Hydroxy-1, 4-napthoquinone solubilization, thermodynamics and adsorption kinetics with surfactant

doi:10.1016/j.cjche.2020.09.064

摘要/Abstract

摘要： 2-Hydroxy-1, 4-napthoquinone (lawsone) natural red-orange dye was extracted from fresh henna (Lawsonia inermis) leaves in an alkaline media. The lawsone-surfactant solubilization constants (K_LS) were calculated for the first time by using cationic cetyltrimethylammonium bromide (CTAB) and anionic sodium dodecyl sulphate (SDS). The standard free energy, concentration of solubilized lawsone and number of lawsone molecules solubilized into micelles were calculated and discussed. Surface excess, minimum surface area per molecule, surface pressure, free energy (adsorption and aggregation) and equilibrium constants of different states were determined from tensiometry. Different metal ions (Ag⁺, Co²⁺, Cu²⁺, Ni²⁺, Fe³⁺, Zn²⁺ and Al³⁺) were used to determine the complex forming ability with lawsone. Out of these, Ag+ ions have strong binding capacity with lawsone. The adsorption of lawsone on the surface of glass with silver ions in presence of CTAB was also observed at pH ≥ 9.0. The pseudo-first, secondorder kinetic equation, intraparticles diffusion and Elovich models were used to determine the kinetics of lawsone adsorption onto the surface of glass and a probable mechanism has been discussed. Lawsone adsorption followed second-order kinetic equation (k₂=0.019 g·mg^-1·min^-1).

关键词: Adsorption, Aggregation, Lawsone, Surfactant, Solubilization, Kinetics

Abstract: 2-Hydroxy-1, 4-napthoquinone (lawsone) natural red-orange dye was extracted from fresh henna (Lawsonia inermis) leaves in an alkaline media. The lawsone-surfactant solubilization constants (K_LS) were calculated for the first time by using cationic cetyltrimethylammonium bromide (CTAB) and anionic sodium dodecyl sulphate (SDS). The standard free energy, concentration of solubilized lawsone and number of lawsone molecules solubilized into micelles were calculated and discussed. Surface excess, minimum surface area per molecule, surface pressure, free energy (adsorption and aggregation) and equilibrium constants of different states were determined from tensiometry. Different metal ions (Ag⁺, Co²⁺, Cu²⁺, Ni²⁺, Fe³⁺, Zn²⁺ and Al³⁺) were used to determine the complex forming ability with lawsone. Out of these, Ag+ ions have strong binding capacity with lawsone. The adsorption of lawsone on the surface of glass with silver ions in presence of CTAB was also observed at pH ≥ 9.0. The pseudo-first, secondorder kinetic equation, intraparticles diffusion and Elovich models were used to determine the kinetics of lawsone adsorption onto the surface of glass and a probable mechanism has been discussed. Lawsone adsorption followed second-order kinetic equation (k₂=0.019 g·mg^-1·min^-1).

Key words: Adsorption, Aggregation, Lawsone, Surfactant, Solubilization, Kinetics

Zoya Zaheer, Ekram Yousif Danish, Samia A. Kosa. 2-Hydroxy-1, 4-napthoquinone solubilization, thermodynamics and adsorption kinetics with surfactant[J]. 中国化学工程学报, 2021, 32(4): 212-223.

Zoya Zaheer, Ekram Yousif Danish, Samia A. Kosa. 2-Hydroxy-1, 4-napthoquinone solubilization, thermodynamics and adsorption kinetics with surfactant[J]. Chinese Journal of Chemical Engineering, 2021, 32(4): 212-223.

参考文献

[1] G. Chaudhary, S. Goyal, P. Poonia, Lawsonia inermis linnaeus:A phytopharmacological review, Int. J. Pharm. Sci. Drug Res. 2(1) (2010) 91-98.
[2] M. Dabiri, Z.N. Tisseh, A. Bazgir, Synthesis of fluorescent hydroxyl naphthalene-1,4-dione derivatives by a three-component reaction in water, Dyes Pigm. 89(1) (2011) 63-69.
[3] S. Salunke-Gawali, E. Pereira, U.A. Dar, S. Bhand, Metal complexes of hydroxynaphthoquinones:Lawsone, bis-lawsone, lapachol, plumbagin and juglone, J. Mol. Struct. 1148(2017) 435-458.
[4] G. Valle-Bourrouet, V.M. Ugalde-Saldivar, M. Gomez, L.A. Ortiz-Frade, I. Gonzalez, C. Frontana, Magnetic interactions as a stabilizing factor of semiquinone species of lawsone by metal complexation, Electrochim. Acta 55(28) (2010) 9042-9050.
[5] F.L.S. Bustamante, M.M.P. Silva, W.A. Alves, C.B. Pinheiro, J.A.L.C. Resende, M. Lanznaster, Isomerism and nuclearity control in bis(lawsonato)zinc(II) complexes, Polyhedron 42(1) (2012) 43-49.
[6] Y.M. Hijji, B. Barare, Y. Zhang, Lawsone (2-hydroxy-1,4-naphthoquinone) as a sensitive cyanide and acetate sensor, Sens. Actuators B Chem. 169(1) (2012) 106-112.
[7] M. Sonawane, K. Tayade, S.K. Sahoo, C.P. Sawant, A. Kuwar, A new lawsone azodye for optical sensing of Fe³⁺ and Cu²⁺ and their DFT study, J. Coord. Chem. 69(18) (2016) 2785-2792.
[8] R. Jelly, S.W. Lewis, C. Lennard, K.F. Lim, J. Almog, Lawsone:A novel reagent for the detection of latent fingermarks on paper surfaces, Chem. Comm. (30) (2008) 3513-3515.
[9] J. Almog, Y. Cohen, M. Azoury, T.-R. Hahn, Genipin-A novel fingerprint reagent with colorimetric and fluorogenic activity, J. Forensic Sci. 49(6) (2004) 1-3.
[10] Y. Nemoto, H. Funahashi, The interaction between acid dye and nonionic surfactant, J. Colloid. Interf. Sci. 62(1) (1977) 95-100.
[11] E. Barni, P. Savarino, G. Viscardi, Dye-surfactant interactions and their applications, Acc. Chem. Res. 24(4) (1991) 98-103.
[12] B. Simoncie, M. Kert, A study of anionic dye-cationic surfactant interactions in mixtures of cationic and non-ionic surfactants, Dyes Pigm. 54(3) (2002) 221-224.
[13] B. Simoncic, M. Kert, Influence of the chemical structure of dyes and surfactants on their interactions in binary and ternary mixture, Dyes Pigm. 76(1) (2008) 104-112.
[14] S. Chandravanshi, S.K. Upadhyay, Natural dye -surfactant interaction; ther-modynamic and surface parameters, Colora. Technol. 128(4) (2012) 300-305.
[15] S. Baliarsingh, A.K. Panda, J. Jena, T. Das, N.B. Das, Exploring sustainable technique on natural dye extraction from native plants for textile:identification of colourants, colourimetric analysis of dyed yarns and their antimicrobial evaluation, J. Clean. Prod. 37(2012) 257-264.
[16] S. Baliarsingh, J. Jena, T. Das, N.B. Das, Role of cationic and anionic surfactants in textile dyeing with natural dyes extracted from waste plant materials and their potential antimicrobial properties, Ind. Crops Prod. 50(2013) 618-624.
[17] R. Sharma, A. Kamal, R.K. Mahajan, Detailed study of interactions between eosin yellow and gemini pyridinium surfactants, RSC Adv. 6(2016) 71692-71704.
[18] M. Yusuf, M. Shahid, M.I. Khan, S.A. Khan, M.A. Khan, F. Mohammad, Dyeing studies with henna and madder:a research on effect of tin (II) chloride mordant, J. Saudi Chem. Soc. 19(1) (2015) 64-72.
[19] Z. Aksu, S. Ertugrul, G. Donmez, Methylene blue biosorption by rhizopus arrhizus:effect of SDS (sodium dodecylsulfate) surfactant on biosorption properties, Chem. Eng. J. 158(3) (2010) 474-481.
[20] J. Sangeetha, J. Philip, Synthesis, characterization and antimicrobial property of Fe₃O₄-Cys-HNQ nanocomplex, with L-cysteine molecule as a linker, RSC Adv. 3(21) (2013) 8047-8057.
[21] S.S. Khadtare, A.P. Ware, S. Salunke-Gawali, S.R. Jadkar, S.S. Pingale, H.M. Pathan, Dye sensitized solar cell with lawsone dye using ZnO photoanode:experimental and TD-DFT study, RSC Adv. 5(2015) 17647-17652.
[22] S. Sreeja, B. Pesala, Plasmonic enhancement of betanin-lawsone co-sensitized solar cells via tailored bimodal size distribution of silver nanoparticles, Sci. Rep. 10(2020) 8240.
[23] X. Li, W.C.H. Choy, H. Lu, W.E.I. Sha, A.H.P. Ho, Efficiency enhancement of organic solar cells by using shape-dependent broadband plasmonic absorption in metallic nanoparticles, Adv. Funct. Mater. 23(21) (2013) 2728-2735.
[24] M. Barani, M. Mirzaei, M. Torkzadeh-Mahani, M.H. Nematollahi, Lawsoneloaded niosome and its antitumor activity in MCF-7 breast cancer cell line:A nano-herbal treatment for cancer, DARU J. Pharm. Sci. 26(1) (2018) 11-17.
[25] G.S. Gupta, G. Prasad, V.N. Singh, Removal of chrome dye from aqueous solutions by mixed adsorbents:Fly ash and coal, Water Res. 24(1) (1990) 45-50.
[26] S.-H. Kim, P.-P. Choi, Enhanced congo red dye removal from aqueous solutions using iron nanoparticles:Adsorption, kinetics, and equilibrium studies, Dalton Trans. 46(44) (2017) 15470-15479.
[27] K.Y. Foo, B.H. Hameed, Insights into the modeling of adsorption isotherm systems, Chem. Eng. J. 156(1) (2010) 2-10.
[28] A. Tor, Y. Cengeloglu, Removal of congo red from aqueous solution by adsorption onto acid activated red mud, J. Hazard. Mater. B 138(2) (2006) 409-415.
[29] V.K. Gupta, A. Mittal, V. Gajbe, J, Mittal, Removal and recovery of the hazardous azo dye acid orange 7 through adsorption over waste materials:Bottom ash and de-oiled soya, Ind. Eng. Chem. Res. 45(4) (2006) 1446-1453.
[30] M. Ozacar, I.A. Sengil, A kinetic study of metal complex dye sorption onto pine sawdust, Process Biochem. 40(2) (2005) 565-572.
[31] M. Ghaedi, M.N. Biyareh, S.N. Kokhdan, S. Shamsaldini, R. Sahraei, A. Daneshfar, S. Shahriyar, Comparison of the efficiency of palladium and silver nanoparticles loaded on activated carbon and zinc oxide nanorods loaded on activated carbon as new adsorbents for removal of congo red from aqueous solution:Kinetic andisotherm study, Mater. Sci. Eng.C 32(4) (2012) 725-734.
[32] Z. Zaheer, Eco-friendly walnut shell powder based facile fabrication of biogenic Ag-nanodisks, and their interaction with bovine serum albumin, J. Photochem. Photobiolo. B:Biol. 193(2019) 8-17.
[33] S.A. Kosa, Z. Zaheer, Betanin assisted synthesis of betanin@silver nanoparticles and their enhanced adsorption and biological activities, Food Chem. 298(2019) (12 pages) 125014.
[34] Z. Zaheer, A. Al-Asfar, E.S. Aazam, Adsorption of methyl red on biogenic Ag@Fe nanocomposities adsorbent:Isotherms, kinetics and mechanistic approach, J. Mol. Liq. 283(2019) 287-298.
[35] A. Al-Asfar, Z. Zaheer, E.S. Aazam, Eco-friendly green synthesis of Ag@Fe bimetallic nanoparticles:Antioxidant, antimicrobial and photocatalytic degradation of bromothymol blue, J. Photochem. Photobiolo., B:Biol. 185(2018) 143-152.
[36] U.S. Siddiqui, J. Aslam, W.H. Ansari, Kabir-ud-Din, Micellization and aggregation behavior of a series of cationic gemini surfactants (m-s-m type) on their interaction with a biodegradable sugar-based surfactant (octyl-_-Dglucopyranoside), Colloids Surf. A:Physicochem. Eng. Asp. 421(2013) 164-172.
[37] R.B. Patwardhan, P.K. Dhakephalkar, B.A. Chopade, D.D. Dhavale, R.R. Bhonde, Purification and characterization of an active principle, lawsone, responsible for the plasmid curing activity of Plumbago zeylanica root extracts, Front. Microbiol. 9(2018) 2618.
[38] M.A.R. Bhuiyan, A. Islam, A. Ali, M.N. Islam, Color and chemical constitution of natural dye henna (Lawsonia inermis L) and its application in the coloration of textiles, J. Clean. Prod. 167(2017) 14-22.
[39] M. Bielska, A. Sobczynska, K. Prochaska, Dye-surfactant interaction in aqueous solutions, Dyes Pigm. 80(2) (2009) 201-205.
[40] H.A. Benesi, J.H. Hildebrand, A spectrophotometric investigation of the interaction of iodine with aqromatic hydrocarbons, J. Am. Chem. Soc. 71(8) (1949) 2703-2707.
[41] P.H. Connett, K.E. Wetterhahn, In vitro reaction of the carcinogen chromatewith cellular thiols and carboxylic acids, J. Am. Chem. Soc. 107(914) (1985) 4282-4288.
[42] K.K. Karukstis, D.A. Savi, C.T. Loftus, N.D. D'Angelo, Spectroscopic studies of the interaction of methyl orange with cationic alkyltrimethylammonium bromide surfactants, J. Colloid Interface Sci. 203(1998) 157-163.
[43] M.C. Carey, D.M. Small, Micellar properties of dihydroxy and trihydroxy bile salts:Effects of counterion and temperature, J. Coll. Inter. Sci. 31(3) (1969) 382-396.
[44] C.A. Bunton, G. Savelli, Organic reactivity in aqueous micelles and similar assemblies, Adv. Phys. Org. Chem. 22(1986) 213-309.
[45] S. Tascioglu, Micellar solutions as reaction media, Tetrahedron 52(34) (1996) 11113-11152.
[46] C.A. Bunton, Reactivity in aqueous association colloids. Descriptive utility of the pseudophase model, J. Mol. Liq. 72(1-3) (1997) 231-249.
[47] A.M. Awan, S.S. Shah, Hydrophobic interaction of amphiphilic hemicyanine dye with cationic surfactant and anionic surfactant micelles, Colloids Surf. A:Physicochem. Eng. Asp. 122(1997) 97-101.
[48] H.M.P. De Oliveiro, M.H. Gehten, Characterization of mixed micelles of sodium dodecylsulfate and tetraoxyethylene dodecyl ether in aqueous solutions, Langmuir 18(10) (2002) 3792-3796.
[49] R. Cierpiszewski, M. Hebrant, J. Szymanowski, C. Tondre, Copper(II) complexation kinetics with hydroxyoximes in CTAB micelles. Effect of extractant hydrophobicity and additives, J. Chem. Soc., Faraday Trans. 92(1996) 249-255.
[50] C. Tondre, M. Hebrant, Micellar and microemulsion systems to perform heterogeneous reactions, biphasic extraction and solute transport, J. Mol. Liq. 72(1-3) (1997) 279-294.
[51] C. Tondre, M. Boumezioud, Microemulsions as model systems to study the kinetics and mechanism of reactions occurring in the extraction of metal ions by lipophilic extractants:complexation of nickel(II) by 8-hydroxyquinoline and Kelex 100, J. Phys. Chem. 93(2) (1989) 846-854.
[52] B. Amro, K. James, T. Turner, A quantitative study of dyeing with lawsone, J. Soc. Cosmet. Chem. 45(1993) 159-165.
[53] N. Gurjar, K. Daniel, S. Sharma, V. Daniel, Acid base indicator property of lawsonia inerimes leaves, J. Biomed. Pharm. Res. 3(3) (2014) 64-66.
[54] S.F. Burlatsky, V.V. Atrazhev, D.V. Dmitriev, V.I. Sultanov, E.N. Timokhina, E.A. Ugolkova, S. Tulyani, A. Vincitore, Surface tension model for surfactant solutions at the critical micelle concentration, J. Colloid Interf. Sci. 393(2013) 151-160.
[55] M. Akram, S. Anwar, F. Ansari, I.A. Bhat Kabir-ud-Din, Bio-physicochemical analysis of ethylene oxide-linked diester-functionalized green cationic gemini surfactants, RSC Adv. 6(2016) 21697-21705.
[56] Z. Khan, M.A. Malik, S.A. Al-Thabaiti, O. Bashir, T.A. Khan, Natural dye bolaform sugar-based surfactant:Self aggregation and mixed micellization with ionic surfactants, Dyes Pigm. 131(2016) 168-176.
[57] M.J. Rosen, J.T. Kunjappu, Surfactants and Interfacial Phenomena, fourth ed., John Wiley & Sons, New Jersey, USA, 2012.
[58] M.S. Bakshi, G. Kaur, Mixed micelles of series of monomeric and dimeric cationic, zwitterionic, and unequal twin-tail cationic surfactants with sugar surfactants:a fluorescence study, J. Colloid Interf. Sci. 289(2) (2005) 551-559.
[59] S. Ghosh, S. Mondal, S. Das, R. Biswas, Spectroscopic investigation of interaction between crystal violet and various surfactants (cationic, anionic, nonionic and gemini) in aqueous media, Fluid Phase Equilibr. 332(2012) 1-6.
[60] S.K. Mehta, K.K. Bhasin, A. Kumar, S. Dham, Micellar behavior of dodecyldimethylethyl ammonium bromide and dodecyltrimethylammonium chloride in aqueous media in the presence of diclofenac sodium, Coll. Surf. A:Physicochem. Eng. Asp. 278(2006) 17-25.
[61] S.A. Al-Thabaiti, E.S. Aazam, O. Bashir, Z. Khan, Aggregation of congo red with surfactants and Ag nanoparticles in an aqueous solution, Spectrochim. Acta Part A:Mol. Biomol. Spectrosc. 156(2016) 28-35.
[62] V.K. Gupta, B. Gupta, A. Rastogic, S. Agarwald, A. Nayaka, Comparative investigation on adsorption performances of mesoporous activated carbon prepared from waste rubber tire and activated carbon for a hazardous azo dyeAcid Blue 113, J. Hazard. Mater. 186(1) (2011) 891-901.
[63] W.J. Weber, J.C. Morris, Kinetics of adsorption on carbon from solution, J. Sanit. Eng. Div. Am. Soc. Civ. Eng. 89(2) (1963) 31-59.
[64] M. Ghaedi, S. Hajjati, Z. Mahmudi, I. Tyagi, S. Agarwal, A. Maity, V.K. Gupta, Modeling of competitive ultrasonic assisted removal of the dyes-methylene blue and safranin-O using Fe₃O₄ nanoparticles, Chem. Eng. J. 268(2015) 28-37.
[65] S.Y. Elovich, O.G. Larinov, Theory of adsorption from solutions of non electrolytes on solid (I) equation adsorption from solutions and the analysis of its simplest form, (II) verification of the equation of adsorption isotherm from solutions, Izv. Akad. Nauk SSSR, Otd. Khim. Nauk. 2(1962) 209-216.