Deviation of Carbon Dioxide-Water Gas-Liquid Balance from Thermodynamic Equilibrium in Turbulence Ⅰ: Experiment and Correlation

doi:10.1016/S1004-9541(13)60540-6

Chinese Journal of Chemical Engineering ›› 2013, Vol. 21 ›› Issue (7): 770-775.DOI: 10.1016/S1004-9541(13)60540-6

Deviation of Carbon Dioxide-Water Gas-Liquid Balance from Thermodynamic Equilibrium in Turbulence Ⅰ: Experiment and Correlation

张珍禛¹, 钱智², 徐联滨¹, 吴彩艳¹, 郭锴¹

1 Research Center of the Ministry of Education for High Gravity Engineering and Technology, Beijing University of Chemical Technology, Beijing 100029, China;
2 University of Chinese Academy of Sciences, Beijing 100049, China

收稿日期:2012-07-21 修回日期:2013-04-30 出版日期:2013-07-28 发布日期:2013-08-24
通讯作者: GUO Kai
基金资助:
Supported by the National Natural Science Foundation of China (21106176), President Fund of GUCAS (Y15101JY00), China Postdoctoral Science Foundation (2012T50155) and National Basic Research Program of China (2009CB219903).

Deviation of Carbon Dioxide-Water Gas-Liquid Balance from Thermodynamic Equilibrium in Turbulence Ⅰ: Experiment and Correlation

ZHANG Zhenzhen¹, QIAN Zhi², XU Lianbin¹, WU Caiyan¹, GUO Kai ¹

1 Research Center of the Ministry of Education for High Gravity Engineering and Technology, Beijing University of Chemical Technology, Beijing 100029, China;
2 University of Chinese Academy of Sciences, Beijing 100049, China

Received:2012-07-21 Revised:2013-04-30 Online:2013-07-28 Published:2013-08-24
Supported by:
Supported by the National Natural Science Foundation of China (21106176), President Fund of GUCAS (Y15101JY00), China Postdoctoral Science Foundation (2012T50155) and National Basic Research Program of China (2009CB219903).

摘要/Abstract

摘要： The carbon dioxide-water system was used to investigate the flowing gas-liquid metastable state. The experiment was carried out in a constant volume vessel with a horizontal circulation pipe and a peristaltic pump forced CO₂ saturated water to flow. The temperature and pressure were recorded. The results showed that some CO₂ escaped from the water in the flow process and the pressure increased, indicating that the gas-liquid equilibrium was broken. The amount of escaped CO₂ varied with flow speed and reached a limit in a few minutes, entitled dynamic equilibrium. Temperature and liquid movement played the same important role in breaking the phase equilibrium. Under the experimental conditions, the ratio of the excessive carbon dioxide in the gas phase to its thermodynamic equilibrium amount in the liquid could achieve 15%.

关键词: carbon dioxide, turbulence, desorption, dynamic gas-liquid phase equilibrium

Abstract: The carbon dioxide-water system was used to investigate the flowing gas-liquid metastable state. The experiment was carried out in a constant volume vessel with a horizontal circulation pipe and a peristaltic pump forced CO₂ saturated water to flow. The temperature and pressure were recorded. The results showed that some CO₂ escaped from the water in the flow process and the pressure increased, indicating that the gas-liquid equilibrium was broken. The amount of escaped CO₂ varied with flow speed and reached a limit in a few minutes, entitled dynamic equilibrium. Temperature and liquid movement played the same important role in breaking the phase equilibrium. Under the experimental conditions, the ratio of the excessive carbon dioxide in the gas phase to its thermodynamic equilibrium amount in the liquid could achieve 15%.

Key words: carbon dioxide, turbulence, desorption, dynamic gas-liquid phase equilibrium

张珍禛, 钱智, 徐联滨, 吴彩艳, 郭锴. Deviation of Carbon Dioxide-Water Gas-Liquid Balance from Thermodynamic Equilibrium in Turbulence Ⅰ: Experiment and Correlation[J]. Chinese Journal of Chemical Engineering, 2013, 21(7): 770-775.

ZHANG Zhenzhen, QIAN Zhi, XU Lianbin, WU Caiyan, GUO Kai . Deviation of Carbon Dioxide-Water Gas-Liquid Balance from Thermodynamic Equilibrium in Turbulence Ⅰ: Experiment and Correlation[J]. Chin.J.Chem.Eng., 2013, 21(7): 770-775.

参考文献

1 Towler, G., Sinnott, R.K., Chemical Engineering Design: Principles Practice and Economics of Plant and Process Design, 2nd edition, Butterworth-Heinemann, Oxford (2012).

2 Wankat, Phillip, C., Separation Process Engineering, Prentice Hall, London (2006).

3 Wark, K., Thermodynamics, McGraw-Hill, New York (1977).

4 Nayef, G., Redhouane, H., Principles of Chemical Engineering Processes, Taylor & Francis Group, London (2009).

5 Ma, L.L., Zhang, Z.Z., Guo, K., “Explorative research on the dynamic dissolution equilibrium in the carbon dioxide-water system”, Journal of Beijing University of Chemical Technology, 36, 11-15 (2009). (in Chinese)

6 Zhu, Z.C., Xie, P., Ou, G.F., Cui, B.L., Li, Y., “Design and experimental analyses of small-flow high-head centrifugal-vortex pump for gas-liquid two-phase mixture”, Chin. J. Chem. Eng., 16 (4), 528-534 (2008).

7 Sun, Z.F., Yu, K.T., Wang, S.Y., Miao, Y.Z., “Absorption and desorption of carbon dioxide into and from organic solvents: Effects of Rayleigh and Marangoni instability”, Ind. Eng. Chem. Res., 41, 1905-1913 (2002).

8 Lu, H.H., Yang, Y.M., Maa, J.R., “On the induction criterion of the Marangoni convection at the gas/liquid interface”, Ind. Eng. Chem. Res., 36, 474-482 (1997).

9 Qian, Z., Guo, K., “Modeling and kinetic study on absorption of CO₂ by aqueous solutions of N-methyldiethanolamine in a modified wetted wall column”, Chin. J. Chem. Eng., 17 (4), 571-579 (2009).

10 Sandler, S.I., Chemical and Engineering Thermodynamic, 3rd edition, John Wiley & Sons Inc., New York (1999).

11 Lockett, M.J., Distillation Tray Fundamentals, Cambridge University Press, New York (1986).

12 Chen, J.B., Liu, C.J., Yuan, X.G., Yu, G.C., “CFD simulation of flow and mass transfer in structured packing distillation columns”, Chin. J. Chem. Eng., 17 (3), 381-388 (2009).

13 Mahmoud, R.S., Azam, M., Sadegh, M., Mehran, D., Saeed, S., “Mathematical modeling and numerical simulation of CO₂ transport through hollow-fiber membranes”, Appl. Math. Model., 35, 174-188 (2011).

14 Dalmolin, I., Skovroinski, E., Biasi, A., Corazza, M.L., Dariva, C., Vladimir Oliveira, J., “Solubility of carbon dioxide in binary and ternary mixtures with ethanol and water”, Fluid Phase Equilib., 245, 193-200 (2006).

15 Li, H.L., Jakobsen, J.P., Wilhelmsen, O., Yan, J.Y., “PVTxy properties of CO₂ mixtures relevant for CO₂ capture, transport and storage: Review of available experimental data and theoretical models”, Energy, 88 (11), 3567-3579 (2011).

[1]	Chaojie Li, Xianxin Fang, Meiling Sun, Jihai Duan, Weiwen Wang. Study on two-phase cloud dispersion from liquefied CO₂ release[J]. 中国化学工程学报, 2023, 60(8): 37-45.
[2]	Xun Tao, Fan Zhou, Xinlei Yu, Songling Guo, Yunfei Gao, Lu Ding, Guangsuo Yu, Zhenghua Dai, Fuchen Wang. Effect of carbon dioxide on oxy-fuel combustion of hydrogen sulfide: An experimental and kinetic modeling[J]. 中国化学工程学报, 2023, 59(7): 105-117.
[3]	Hongwei Liang, Wenling Li, Zisheng Feng, Jianming Chen, Guangwen Chu, Yang Xiang. Numerical simulation of gas-liquid flow in the bubble column using Wray-Agarwal turbulence model coupled with population balance model[J]. 中国化学工程学报, 2023, 58(6): 205-223.
[4]	Yutong Jiang, Yifeng Chen, Fuliu Yang, Jixue Fan, Jun Li, Zhuhong Yang, Xiaoyan Ji. Efficient SO₂ removal using aqueous ionic liquid at low partial pressure[J]. 中国化学工程学报, 2023, 58(6): 355-363.
[5]	Tatyana P. Adamova, Sergey S. Skiba, Andrey Yu. Manakov, Sergey Y. Misyura. Growth rate of CO₂ hydrate film on water–oil and water–gaseous CO₂ interface[J]. 中国化学工程学报, 2023, 56(4): 266-272.
[6]	Bowen Jiang, Jia Liu, Guoqiang Yang, Zhibing Zhang. Efficient conversion of CO₂ into cyclic carbonates under atmospheric by halogen and metal-free poly(ionic liquid)s[J]. 中国化学工程学报, 2023, 55(3): 202-211.
[7]	Mingdong Sun, Dongxin Pan, Tingting Ye, Jing Gu, Yu Zhou, Jun Wang. Ionic porous polyamide derived N-doped carbon towards highly selective electroreduction of CO₂[J]. 中国化学工程学报, 2023, 55(3): 212-221.
[8]	Mengge Shang, Jing Zhang, Jinqiang Sun, Shimo Yu, Feng Hua, Xiaoxu Xuan, Xun Sun, Serguei Filatov, Xibin Yi. Amine-functionalized mesoporous UiO-66 aerogel for CO₂ adsorption[J]. 中国化学工程学报, 2023, 54(2): 36-43.
[9]	Xianglin Liu, Minjie Xu, Chenxi Cao, Zixu Yang, Jing Xu. Effects of zinc on χ-Fe₅C₂ for carbon dioxide hydrogenation to olefins: Insights from experimental and density function theory calculations[J]. 中国化学工程学报, 2023, 54(2): 206-214.
[10]	Zhongyao Zhang, Ming Gao, Xiaopeng Chen, Xiaojie Wei, Jiezhen Liang, Chenghong Wu, Linlin Wang. The Joule–Thomson effect of (CO₂ + H₂) binary system relevant to gas switching reforming with carbon capture and storage (CCS)[J]. 中国化学工程学报, 2023, 54(2): 215-231.
[11]	Jun Li, Liqiang Zhang, Xiao Zhu, Mengze Zhang, Tai Feng, Xiqiang Zhao, Tao Wang, Zhanlong Song, Chunyuan Ma. Systematic investigation of SO₂ adsorption and desorption by porous powdered activated coke: Interaction between adsorption temperature and desorption energy consumption[J]. 中国化学工程学报, 2022, 48(8): 140-148.
[12]	Vladimir S. Derevschikov, Janna V. Veselovskaya, Anton S. Shalygin, Dmitry A. Yatsenko, Andrey Z. Sheshkovas, Oleg N. Martyanov. Operating limits and features of direct air capture on K₂CO₃/ZrO₂ composite sorbent[J]. 中国化学工程学报, 2022, 46(6): 11-20.
[13]	Jipeng Dong, Fei Wang, Guanghui Chen, Shougui Wang, Cailin Ji, Fei Gao. Fabrication of nickel oxide functionalized zeolite USY composite as a promising adsorbent for CO₂ capture[J]. 中国化学工程学报, 2022, 46(6): 207-213.
[14]	Tao Sun, Mingjun Pang, Yang Fei. Numerical study on hydrodynamic characteristics of spherical bubble contaminated by surfactants under higher Reynolds numbers[J]. 中国化学工程学报, 2022, 45(5): 268-283.
[15]	Xiaocui Sun, Xue Liu, Guang-Rong Zhao. Separation of salidroside from the fermentation broth of engineered Escherichia coli using macroporous adsorbent resins[J]. 中国化学工程学报, 2022, 44(4): 260-267.

Deviation of Carbon Dioxide-Water Gas-Liquid Balance from Thermodynamic Equilibrium in Turbulence Ⅰ: Experiment and Correlation

Deviation of Carbon Dioxide-Water Gas-Liquid Balance from Thermodynamic Equilibrium in Turbulence Ⅰ: Experiment and Correlation

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价