Pinch Location of the Hydrogen Network with Purification Reuse

doi:10.1016/S1004-9541(13)60637-0

Chinese Journal of Chemical Engineering ›› 2013, Vol. 21 ›› Issue (12): 1332-1340.DOI: 10.1016/S1004-9541(13)60637-0

• 过程系统工程与过程安全 • 上一篇下一篇

Pinch Location of the Hydrogen Network with Purification Reuse

刘桂莲¹, 黎浩², 冯霄³, 邓春³

1 Department of Chemical Engineering, School of Chemical Engineering and Technology, Xi'an Jiaotong University, Xi'an 710049, China;
2 WISDRI Engineering & Research Incorporation Limited, Wuhan 430223, China;
3 State Key Laboratory of Heavy Oil Processing, China University of Petroleum, Beijing 102249, China

收稿日期:2012-07-06 修回日期:2012-10-07 出版日期:2013-12-28 发布日期:2013-12-27
通讯作者: LIU Guilian
基金资助:
Supported by the State Key Development Program for Basic Research of China (2012CB720500), the National Natural Science Foundation of China (21276205, 20936004) and the State Key Laboratory of Heavy Oil Processing.

Pinch Location of the Hydrogen Network with Purification Reuse

LIU Guilian¹, LI Hao², FENG Xiao³, DENG Chun³

1 Department of Chemical Engineering, School of Chemical Engineering and Technology, Xi'an Jiaotong University, Xi'an 710049, China;
2 WISDRI Engineering & Research Incorporation Limited, Wuhan 430223, China;
3 State Key Laboratory of Heavy Oil Processing, China University of Petroleum, Beijing 102249, China

Received:2012-07-06 Revised:2012-10-07 Online:2013-12-28 Published:2013-12-27
Supported by:
Supported by the State Key Development Program for Basic Research of China (2012CB720500), the National Natural Science Foundation of China (21276205, 20936004) and the State Key Laboratory of Heavy Oil Processing.

摘要/Abstract

摘要： In the hydrogen network with the minimum hydrogen utility flow rate, the pinch appears at the point with zero hydrogen surplus, while the hydrogen surpluses of all the other points are positive. In the hydrogen purity profiles, the pinch can only lie at the sink-tie-line intersecting the source purity profile. According to the alternative distribution of the negative and positive regions, the effect of the purification to the hydrogen surplus is analyzed. The results show that when the purification is applied, the pinch point will appear neither above the purification feed nor between the initial pinch point and the purification feed, no matter the purification feed lies above or below the initial pinch point. This is validated by two case studies.

关键词: purification, pinch, hydrogen network, hydrogen surplus, hydrogen utility flow rate

Abstract: In the hydrogen network with the minimum hydrogen utility flow rate, the pinch appears at the point with zero hydrogen surplus, while the hydrogen surpluses of all the other points are positive. In the hydrogen purity profiles, the pinch can only lie at the sink-tie-line intersecting the source purity profile. According to the alternative distribution of the negative and positive regions, the effect of the purification to the hydrogen surplus is analyzed. The results show that when the purification is applied, the pinch point will appear neither above the purification feed nor between the initial pinch point and the purification feed, no matter the purification feed lies above or below the initial pinch point. This is validated by two case studies.

Key words: purification, pinch, hydrogen network, hydrogen surplus, hydrogen utility flow rate

刘桂莲, 黎浩, 冯霄, 邓春. Pinch Location of the Hydrogen Network with Purification Reuse[J]. Chinese Journal of Chemical Engineering, 2013, 21(12): 1332-1340.

LIU Guilian, LI Hao, FENG Xiao, DENG Chun. Pinch Location of the Hydrogen Network with Purification Reuse[J]. Chin.J.Chem.Eng., 2013, 21(12): 1332-1340.

参考文献

1 Alves, J.J., Towler, G.P., “Analysis of refinery hydrogen distribution systems”, Ind. Eng. Chem. Res., 41 (23), 5759-5769 (2002).
2 El-Halwagi, M.M., Gabriel, F., Harell, D., “Rigorous graphical targeting for resource conservation via material recycle/reuse networks”, Ind. Eng. Chem. Res., 42 (19), 4319-4328 (2003).
3 Kazantzi, V., El-Halwagi, M.M., “Targeting material reuse via property integration”, Chem. Eng. Prog., 101 (8), 28-37 (2005).
4 Zhao, Z.H., Liu, G.L., Feng, X., “New graphical method for the integration of hydrogen distribution systems”, Ind. Eng. Chem. Res., 45 (8), 6512-6517 (2006).
5 Agrawal, V., Shenoy, U.V., “Unified conceptual approach to targeting and design of water and hydrogen networks”, AIChE J., 52 (3), 1071-1082 (2006).
6 Bandyopadhyay, S., “Source composite curve for waste reduction”, Chem. Eng. J., 125 (2), 99-110 (2006).
7 Alwi, S.R.W., Aripin, A., Manan, Z.A., “A generic graphical approach for simultaneous targeting and design of a gas network”, Resour. Conserv. Recy., 53 (10), 588-591 (2009).
8 Foo, D.C.Y., Manan, Z.A., “Setting the minimum utility gas flowrate targets using cascade analysis technique”, Ind. Eng. Chem. Res., 45 (17), 5986-5995 (2006).
9 Foo, D.C.Y., Kazantzi, V., El-Halwagi, M.M., Abdul Manan, Z., “Surplus diagram and cascade analysis technique for targeting property- based material reuse network”, Chem. Eng. Sci., 61 (8), 2626-2642 (2006).
10 Alves, J.J., “Analysis and design of refinery hydrogen distribution systems”, Ph.D. Thesis, UMIST, UK (1999).
11 Liu, F., Zhang, N., “Strategy of purifier selection and integration in hydrogen networks”, Chem. Eng. Res. Des., 82 (A10), 1315-1330 (2004).
12 Ng, D.K.S., Foo, D.C.Y., Tan, R.R., “Automated targeting technique for single-impurity resource conservation networks. Part 2: Single-pass and partitioning waste-interception systems”, Ind. Eng. Chem. Res., 48 (16), 7647-7661 (2009).
13 Ng, D.K.S., Foo, D.C.Y., Tan, R.R., El-Halwagi, M., “Automated targeting technique for concentration-and property-based total resource conservation network”, Comp. Chem. Eng., 34 (5), 825-845 (2010).
14 Ng, D.K.S., Foo, D.C.Y., Tan, R.R., Pau, C.H., Tan, Y.L., “Automated targeting for conventional and bilateral property-based resource conservation network”, Chem. Eng. J., 149 (1-3), 87-101 (2009).
15 Nelson, A.M., Liu, Y.A., “Hydrogen-pinch analysis made easy”, Chem. Eng., 115 (6), 56-61 (2008).
16 Tan, R.R., Ng, D.K.S., Foo, D.C.Y., “Graphical approach to minimum flowrate targeting for partitioning water pretreatment units”, Chem. Eng. Res. Des., 88 (4A), 393-402 (2010).
17 Zhang, Q., Feng, X., Liu, G., Chu, K.H., “A novel graphical method for the integration of hydrogen distribution systems with purification reuse”, Chem. Eng. Sci., 66 (4), 797-809 (2011).
18 Liao, Z., Wang, J., Yang, Y., Rong, G., “Integrating purifiers in refinery hydrogen networks: a retrofit case study”, J. Clean. Prod., 18 (3), 233-241 (2010).
19 Liao, Z., Rong, G., Wang, J., Yang, Y., “Rigorous algorithmic targeting methods for hydrogen networks. Part Ⅰ: Systems with no hydrogen purification”, Chem. Eng. Sci., 66 (5), 813-820 (2011).
20 Liao, Z., Rong, G., Wang, J., Yang, Y., “Rigorous algorithmic targeting methods for hydrogen networks. Part Ⅱ: Systems with one hydrogen purification unit”, Chem. Eng. Sci., 66 (5), 821-833 (2011).

[1]	Yuan Liu, Hanting Xiong, Jingwen Chen, Shixia Chen, Zhenyu Zhou, Zheling Zeng, Shuguang Deng, Jun Wang. One-step ethylene separation from ternary C₂ hydrocarbon mixture with a robust zirconium metal-organic framework[J]. 中国化学工程学报, 2023, 59(7): 9-15.
[2]	Yong Xu, Qingbai Chen, Yang Gao, Jianyou Wang, Huiqing Fan, Fei Zhao. Performance comparison of lithium fractionation from magnesium via continuous selective nanofiltration/electrodialysis[J]. 中国化学工程学报, 2023, 59(7): 42-50.
[3]	Runze Chen, Yuran Chen, Xuemin Liang, Yapeng Kong, Yangyang Fan, Quan Liu, Zhenyu Yang, Feiying Tang, Johnny Muya Chabu, Maru Dessie Walle, Liqiang Wang. Oxidative exfoliation of spent cathode carbon: A two-in-one strategy for its decontamination and high-valued application[J]. 中国化学工程学报, 2023, 59(7): 262-269.
[4]	Yunchang Fan, Chunyan Zhu, Sheli Zhang, Lei Zhang, Qiang Wang, Feng Wang. Efficient and selective extraction of sinomenine by deep eutectic solvents[J]. 中国化学工程学报, 2023, 57(5): 109-117.
[5]	Juanjuan Liu, Xiaolong Lu, Guiming Shu, Ke Li, Shuyun Zheng, Xiao Kong, Tao Li, Jun Yang. The facile method developed for preparing polyvinylidene fluoride plasma separation membrane via macromolecular interaction[J]. 中国化学工程学报, 2022, 49(9): 140-149.
[6]	Chun Deng, Xuantong Lu, Qixin Zhang, Jian Liu, Jui-Yuan Lee, Xiao Feng. Fuzzy optimization design of multicomponent refinery hydrogen network[J]. 中国化学工程学报, 2022, 48(8): 125-139.
[7]	Wenjian Zhu, Xuhua Shen, Rui Ou, Manoj Murugesan, Aihua Yuan, Jianfeng Liu, Xiaocai Hu, Zhen Yang, Ming Shen, Fu Yang. Superhigh selective capture of volatile organic compounds exploiting cigarette butts-derived engineering carbonaceous adsorbent[J]. 中国化学工程学报, 2022, 46(6): 194-206.
[8]	Song Hu, Jinlong Li, Qihua Wang, Weisheng Yang. Design and optimization of an integrated process for the purification of propylene oxide and the separation of propylene glycol by-product[J]. 中国化学工程学报, 2022, 45(5): 111-120.
[9]	Puxu Liu, Yong Wang, Yang Chen, Xiaoqing Wang, Jiangfeng Yang, Libo Li, Jinping Li. Stable titanium metal-organic framework with strong binding affinity for ethane removal[J]. 中国化学工程学报, 2022, 42(2): 35-41.
[10]	Xionghui Liu, Jianfeng Du, Yu Ye, Yuchuan Liu, Shun Wang, Xianyu Meng, Xiaowei Song, Zhiqiang Liang, Wenfu Yan. Boosting selective C₂H₂/CH₄, C₂H₄/CH₄ and CO₂/CH₄ adsorption performance via 1,2,3-triazole functionalized triazine-based porous organic polymers[J]. 中国化学工程学报, 2022, 42(2): 64-72.
[11]	Tiefeng Wang, Jinxiang Dong. Ethylene glycol purification by melt crystallization: Removal of 2-methoxyethanol impurity[J]. 中国化学工程学报, 2021, 37(9): 39-45.
[12]	Piqiang Tan, Xiaoyu Li, Shiyan Wang, Zhiyuan Hu, Diming Lou. Selective catalytic reduction failure of low NH₃-NO_x ratio[J]. 中国化学工程学报, 2021, 32(4): 231-240.
[13]	Minbo Yang, Xiao Feng, Liang Zhao. Coupling pinch analysis and rigorous process simulation for hydrogen networks with light hydrocarbon recovery[J]. 中国化学工程学报, 2021, 40(12): 141-148.
[14]	Kai Zhu, Chaoqun Yao, Yanyan Liu, Guangwen Chen. Using expansion units to improve CO₂ absorption for natural gas purification-A study on the hydrodynamics and mass transfer[J]. 中国化学工程学报, 2021, 29(1): 35-46.
[15]	Xue Gao, Sisi Wen, Bingling Yang, Jian Xue, Haihui Wang. Enhanced air filtration performance under high-humidity condition through electrospun membranes with optimized structure[J]. 中国化学工程学报, 2020, 28(7): 1788-1795.

Pinch Location of the Hydrogen Network with Purification Reuse

Pinch Location of the Hydrogen Network with Purification Reuse

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价