Improved Kernel PLS-based Fault Detection Approach for Nonlinear Chemical Processes

doi:10.1016/S1004-9541(14)60088-4

Chinese Journal of Chemical Engineering ›› 2014, Vol. 22 ›› Issue (6): 657-663.DOI: 10.1016/S1004-9541(14)60088-4

• 催化、动力学与反应工程 • 上一篇下一篇

Improved Kernel PLS-based Fault Detection Approach for Nonlinear Chemical Processes

王丽¹, 侍洪波²

1. School of Electrical and Electronic Engineering, Shanghai Institute of Technology, Shanghai 200230, China;
2. Key Laboratory of Advanced Control and Optimization for Chemical Processes of Ministry of Education, East China University of Science and Technology, Shanghai 200237, China

收稿日期:2013-06-10 修回日期:2013-08-26 出版日期:2014-06-28 发布日期:2014-06-06
通讯作者: Ali Akbar Amooey
基金资助:
Supported by the Special Scientific Research of Selection and Cultivation of Excellent Young Teachers in Shanghai Universities (YYY11076).

Improved Kernel PLS-based Fault Detection Approach for Nonlinear Chemical Processes

WANG Li¹, SHI Hongbo ²

1. School of Electrical and Electronic Engineering, Shanghai Institute of Technology, Shanghai 200230, China;
2. Key Laboratory of Advanced Control and Optimization for Chemical Processes of Ministry of Education, East China University of Science and Technology, Shanghai 200237, China

Received:2013-06-10 Revised:2013-08-26 Online:2014-06-28 Published:2014-06-06
Supported by:
Supported by the Special Scientific Research of Selection and Cultivation of Excellent Young Teachers in Shanghai Universities (YYY11076).

摘要/Abstract

摘要： In this paper, an improved nonlinear process fault detection method is proposed based on modified kernel partial least squares (KPLS). By integrating the statistical local approach (SLA) into the KPLS framework, two new statistics are established to monitor changes in the underlying model. The new modeling strategy can avoid the Gaussian distribution assumption of KPLS. Besides, advantage of the proposed method is that the kernel latent variables can be obtained directly through the eigen value decomposition instead of the iterative calculation, which can improve the computing speed. The new method is applied to fault detection in the simulation benchmark of the Tennessee Eastman process. The simulation results show superiority on detection sensitivity and accuracy in comparison to KPLS monitoring.

关键词: nonlinear process, fault detection, kernel partial least squares, statistical local approach

Abstract: In this paper, an improved nonlinear process fault detection method is proposed based on modified kernel partial least squares (KPLS). By integrating the statistical local approach (SLA) into the KPLS framework, two new statistics are established to monitor changes in the underlying model. The new modeling strategy can avoid the Gaussian distribution assumption of KPLS. Besides, advantage of the proposed method is that the kernel latent variables can be obtained directly through the eigen value decomposition instead of the iterative calculation, which can improve the computing speed. The new method is applied to fault detection in the simulation benchmark of the Tennessee Eastman process. The simulation results show superiority on detection sensitivity and accuracy in comparison to KPLS monitoring.

Key words: nonlinear process, fault detection, kernel partial least squares, statistical local approach

王丽, 侍洪波. Improved Kernel PLS-based Fault Detection Approach for Nonlinear Chemical Processes[J]. Chinese Journal of Chemical Engineering, 2014, 22(6): 657-663.

WANG Li, SHI Hongbo . Improved Kernel PLS-based Fault Detection Approach for Nonlinear Chemical Processes[J]. Chin.J.Chem.Eng., 2014, 22(6): 657-663.

参考文献

1 Wold, S., "Nonlinear partial least squares modeling: II. Spline inner relation", Chemometrics and Intelligent Laboratory Systems, 14, 71-84 (1992).

2 Qin, S.J., McAvoy, T.J., "Nolinear PLS modeling using neural networks", Computers and Chemical Engineering, 16, 379-391 (1992).

3 Malthouse, E.C., Tamhane, A.C., Mah, R.S.H., "Nonlinear partial least squares", Computers and Chemical Engineering, 21, 875-890 (1997).

4 Rosipal, R., Trejo, L.J., "Kernel partial least squares regression in reproducing kernel Hilbert space", Journal of Machine Learning Research, 2, 97-123 (2001).

5 Ge, Z.Q., Yang, C.J., Song, Z.H., "Improved kernel PCA-based monitoring approach for nonlinear processes", Chemical Engineering Science, 64, 2245-2255 (2009).

6 Basseville, M., "On-board component fault detection and isolation using the statistical local approach", Automatic, 34(11), 1391-1415 (1998).

7 Kruger, U., Kumar, S., Littler, T., "Improved principal component monitoring using the local approach", Automatic, 43, 1532-1542 (2007).

8 Kruger, U., Dimitriadis, G., "Diagnosis of process faults in chemical systems using a local partial least squares approach", AIChE Journal, 54, 2581-2596 (2008).

9 Hu, Y., Ma, H.H., Shi, H.B., "Enhanced batch process monitoring using just-in-time-learning based kernel partial least squares", Chemometrics and Intelligent Laboratory Systems, 123, 15-27 (2013).

10 Zhang, Y.W., Teng, Y.D., "Process data modeling using modified kernel partial least squares", Chemical Engineering Science, 65, 6353-6361 (2010).

11 Wang, L., Shi, H.B., "Multivariate statistical process monitoring using an improved independent component analysis", Chemical Engineering Research and Design, 88, 403-414 (2010).

12 Chiang, L.H., Russell, E.L., Braatz, R.D., Fault Detection and Diagnosis in Industrial Systems, Springer, London, 175-281 (2001).

13 Li, G., Qin, S.J., Zhou, D.H., "Geometric properties of partial least squares for process monitoring", Automatica, 46, 204-210 (2010).

14 Xie, X., Shi, H.B., "Multimode process monitoring based on fuzzy C-means in locality preserving projection subspace", Chin. J. Chem. Eng., 20(6), 1174-1179 (2012).

[1]	Muhammad Nawaz, Abdulhalim Shah Maulud, Haslinda Zabiri, Syed Ali Ammar Taqvi, Alamin Idris. Improved process monitoring using the CUSUM and EWMA-based multiscale PCA fault detection framework[J]. 中国化学工程学报, 2021, 29(1): 253-265.
[2]	Cen Guo, Wenkai Hu, Fan Yang, Dexian Huang. Deep learning technique for process fault detection and diagnosis in the presence of incomplete data[J]. 中国化学工程学报, 2020, 28(9): 2358-2367.
[3]	Liangliang Sun, Jianghua Wu, Haiqi Jia, Xuebin Liu. Research on fault detection method for heat pump air conditioning system under cold weather[J]. Chinese Journal of Chemical Engineering, 2017, 25(12): 1812-1819.
[4]	Guozhu Wang, Jianchang Liu, Yuan Li, Cheng Zhang. Fault diagnosis of chemical processes based on partitioning PCA and variable reasoning strategy[J]. , 2016, 24(7): 869-880.
[5]	Fan Wang, Honglin Zhu, Shuai Tan, Hongbo Shi. Orthogonal nonnegative matrix factorization based local hidden Markov model for multimode process monitoring[J]. , 2016, 24(7): 856-860.
[6]	Yawei Yang, Yuxin Ma, Bing Song, Hongbo Shi. An aligned mixture probabilistic principal component analysis for fault detection of multimode chemical processes[J]. Chinese Journal of Chemical Engineering, 2015, 23(8): 1357-1363.
[7]	Kangling Liu, Xin Jin, Zhengshun Fei, Jun Liang. Adaptive partitioning PCA model for improving fault detection and isolation[J]. Chinese Journal of Chemical Engineering, 2015, 23(6): 981-991.
[8]	Jian Tang, Tianyou Chai, Zhuo Liu, Wen Yu. Selective ensemble modeling based on nonlinear frequency spectral feature extraction for predicting load parameter in ball mills[J]. Chinese Journal of Chemical Engineering, 2015, 23(12): 2020-2028.
[9]	Shijin Ren, Zhihuan Song, Maoyun Yang, Jianguo Ren . A novel multimode processmonitoring method integrating LCGMMwith modified LFDA[J]. Chinese Journal of Chemical Engineering, 2015, 23(12): 1970-1980.
[10]	Bing Song, Yuxin Ma, Hongbo Shi. Improved performance of process monitoring based on selection of key principal components[J]. Chinese Journal of Chemical Engineering, 2015, 23(12): 1951-1957.
[11]	Yuxin Ma, Hongbo Shi, Mengling Wang. Adaptive Local Outlier Probability for Dynamic Process Monitoring[J]. , 2014, 22(7): 820-827.
[12]	Xiaogang Deng, Xuemin Tian. Multimode Process Fault Detection Using Local Neighborhood Similarity Analysis[J]. , 2014, 22(11/12): 1260-1267.
[13]	邓晓刚, 田学民. Sparse Kernel Locality Preserving Projection and Its Application in Nonlinear Process Fault Detection[J]. Chinese Journal of Chemical Engineering, 2013, 21(2): 163-170.
[14]	李运锋,汪志锋, 袁景淇. 基于支持向量机MPLS的间歇过程故障诊断方法[J]. , 2006, 14(6): 754-758.
[15]	王东, 周东华, 金以慧. 一类非线性时滞过程的主动容错控制[J]. , 2004, 12(1): 60-65.

Improved Kernel PLS-based Fault Detection Approach for Nonlinear Chemical Processes

Improved Kernel PLS-based Fault Detection Approach for Nonlinear Chemical Processes

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价