Ag-Co3O4: Synthesis, characterization and evaluation of its photocatalytic activity towards degradation of rhodamine B dye in aqueous medium

doi:10.1016/j.cjche.2018.02.024

摘要/Abstract

摘要： Synthesis, characterization of Co₃O₄ and Ag-Co₃O₄ composites and evaluation of their photo-catalytic activities towards photo-degradation of aqueous solution of rhodamine B dye under irradiation of visible light have been described in this paper. Co₃O₄ was prepared by solid phase mechano chemical process using Co(NO₃)₂·6H₂O and NH₄HCO₃ as precursor materials. Ag was deposited on Co₃O₄ from AgNO₃ using Calotropis gigantea extract as reducing agent. XRD, SEM and FTIR were used for characterization of prepared composites. Photo-catalytic efficiencies of as-prepared Co₃O₄ and Ag-Co₃O₄ were evaluated for aqueous phase photo-degradation of rhodamine B. It was found that deposition of Ag on Co₃O₄ highly enhanced the photo-catalytic activity of Co₃O₄. Photo-catalytic degradation followed the Eley-Rideal mechanism. About 100% and 91% photo-degradation of 40 ml dye solution achieved at 313 K in 90 and 120 min over 0.05 g of Ag-Co₃O₄ as photo-catalyst using 100 and 200 mg·L^-1 as initial concentration of dye respectively.

关键词: Co₃O₄, Ag-Co₃O₄, Photo-catalysis, Photo-degradation, Calotropis gigantea, Rhodamine B, Elay-Rideal mechanism

Abstract: Synthesis, characterization of Co₃O₄ and Ag-Co₃O₄ composites and evaluation of their photo-catalytic activities towards photo-degradation of aqueous solution of rhodamine B dye under irradiation of visible light have been described in this paper. Co₃O₄ was prepared by solid phase mechano chemical process using Co(NO₃)₂·6H₂O and NH₄HCO₃ as precursor materials. Ag was deposited on Co₃O₄ from AgNO₃ using Calotropis gigantea extract as reducing agent. XRD, SEM and FTIR were used for characterization of prepared composites. Photo-catalytic efficiencies of as-prepared Co₃O₄ and Ag-Co₃O₄ were evaluated for aqueous phase photo-degradation of rhodamine B. It was found that deposition of Ag on Co₃O₄ highly enhanced the photo-catalytic activity of Co₃O₄. Photo-catalytic degradation followed the Eley-Rideal mechanism. About 100% and 91% photo-degradation of 40 ml dye solution achieved at 313 K in 90 and 120 min over 0.05 g of Ag-Co₃O₄ as photo-catalyst using 100 and 200 mg·L^-1 as initial concentration of dye respectively.

Key words: Co₃O₄, Ag-Co₃O₄, Photo-catalysis, Photo-degradation, Calotropis gigantea, Rhodamine B, Elay-Rideal mechanism

Muhammad Saeed, Majid Muneer, Nida Mumtaz, Mohsin Siddique, Nadia Akram, Muhammad Hamayun. Ag-Co₃O₄: Synthesis, characterization and evaluation of its photocatalytic activity towards degradation of rhodamine B dye in aqueous medium[J]. Chinese Journal of Chemical Engineering, 2018, 26(6): 1264-1269.

参考文献

[1] B. Jankovi?, B.A. Yevi?, S. Mentus, The kinetic study of temperature-programmed reduction of nickel oxide in hydrogen atmosphere, Chem. Eng. Sci. 63(3) (2008) 567-575.

[2] P. Hu, M. Long, Cobalt-catalyzed sulfate radical-based advanced oxidation:A review on heterogeneous catalysts and applications, Appl. Catal. B Environ. 181(2016) 103-117.

[3] A.H. Zayed, M.N. Daud, S.M. Zain, Global structural optimization and growth mechanism of cobalt oxide nanoclusters by genetic algorithm with spin-polarized DFT, J. Alloys Compd. 695(20172513-2518.

[4] G.P. Anipsitakis, E. Stathatos, D.D. Dionysiou, Heterogeneous activation of oxone using Co₂O₃, J. Phys. Chem. B 109(2005) 13052-13055.

[5] K.H. Chan, D. Chu, Degradation of atrazine by cobalt-mediated activation of peroxymonosulfate:Different cobalt counter anions in homogenous process and cobalt oxide catalysts in photolytic heterogeneous process, Water Res. 43(20092513-2521.

[6] Z. Yu, M. Bensimon, D. Laub, L.K. Minsker, W. Jardim, E. Mielczarski, J. Mielczarski, J. Kiwi, Accelerated photodegradation (minute range) of the commercial azo-dye Orange Ⅱ mediated by Co₃O₄/Raschig rings in the presence of oxone, J. Mol. Catal. A Chem. 272(2007) 11-19.

[7] J. Mu, L. Zhang, M. Zhao, Y. Wang, Co₃O₄ nanoparticles as an efficient catalase mimic:Properties, mechanism and its electrocatalytic sensing application for hydrogen peroxide, J. Mol. Catal. A Chem. 378(2013) 30-37.

[8] J. Jiu, Y. Ge, X. Li, L. Nie, Preparation of Co₃O₄ nano-particles by a polymer combustion route, Mater. Lett. 54(2002260-263.

[9] S. Farhadi, K. Pourzare, S. Bazgir, Co₂O₃ nanoplates:Synthesis, characterization and study of optical and magnetic properties, J. Alloys Compd. 587(2014) 632-637.

[10] N.N. Binitha, P.V. Suraja, Z. Yaakob, M.R. Resmi, P.P. Silija, Simple synthesis of Co₃O₄ nanoflakes using a low temperature sol-gel method suitable for photodegradation of dyes, J. Sol-Gel Sci. Technol. 53(2010) 466-469.

[11] R.W. Grimes, A.N. Fitch, Thermal decomposition of cobalt (Ⅱ) acetate tetrahydrate studied with time-resolved neutron diffraction and thermogravimetric analysis, J. Mater. Chem. 1(1991) 461-468.

[12] D.S. Wang, T. Xie, Q. Peng, S.Y. Zhang, J. Chen, Y.D. Li, Direct thermal decomposition of metal nitrates in octadecylamine to metal oxide nanocrystals, Chem. Eur. J. 14(8) (20082507-2513.

[13] K. Kalpanadevi, C.R. Sinduja, R. Manimekalai, Characterization of nanostructured Co₃O₄ synthesized by the thermal decomposition of an inorganic precursor, Aust. J. Chem. 67(2014) 1671-1674.

[14] G. Chen, X. Si, J. Yu, H. Bai, X. Zhang, Doping nano-Co₂O₃ surface with bigger nanosized Ag and its photocatalytic properties for visible light photodegradation of organic dyes, Appl. Surf. Sci. 330(2015) 191-199.

[15] M. Ilyas, M. Saeed, Oxidation of benzyl alcohol in liquid phase catalyzed by cobalt oxide, Int. J. Chem. React. Eng. 8(2010) A77.

[16] B. Varghese, T.C. Hoong, Z. Yanwu, M.V. Reddy, B.V.R. Chowdari, A.T.S. Wee, T.B.C. Vincent, C.T. Lim, C.H. Sow, Co₃O₄ nanostructures with different morphologies and their Field-Emission properties, Adv. Funct. Mater. 17(2007) 1932-1939.

[17] Z. Liu, C. Ma, Q. Cai, T. Hong, K. Guo, L. Yan, Promising cobalt oxide and cobalt oxide/silver photocathodes for photo electrochemical water splitting, Sol. Energy Mater. Sol. Cells 161(2017) 46-51.

[18] Z.J. Jiang, C.Y. Liu, L.W. Sun, Catalytic properties of silver nanoparticles supported on silica spheres, J. Phys. Chem. B 109(2005) 1730-1735.

[19] X. Yang, L. Xu, X. Yu, Y. Guo, One-step preparation of silver and indium oxide codoped TiO₂ photocatalyst for the degradation of rhodamine B, Catal. Commun. 9(6) (2008) 1224-1229.

[20] H. Yang, Y. Hu, X. Zhang, G. Qiu, Mechanochemical synthesis of cobalt oxide nanoparticles, Mater. Lett. 58(2004) 387-389.

[21] K. Mittal, Y. Chisti, U.C. Banerjee, Synthesis of metallic nanoparticles using plant extracts, Biotechnol. Adv. 31(2013) 346-356.

[22] M. Singh, K. Javed, Comparative study of chemical composition of Calotropis gigantea flower, leaf and fruit essential oil, Eur. Chem. Bull. 4(2015) 477-480.

[23] M. Manickam, V. Ponnuswamy, C. Sankar, R. Suresh, R. Mariappan, J. Chandrasekaran, The effect of solution pH on the properties of cobalt oxide thin films prepared by nebulizer spray pyrolysis technique, Int. J. Thin Films Sci. Technol. 5(2016) 155-161.

[24] V. Patil1, P. Joshi, M. Chougule, S. Sen, Synthesis and characterization of Co₃O₄ thin film, Soft Nanosci. Lett. 2(2012) 1-7.

[25] K.F. Wadekar, K.R. Nemade, S.A. Waghuley, Chemical synthesis of cobalt oxide (Co₃O₄) nanoparticles using Co precipitation method, Res. J. Chem. Sci. 7(2017) 53-55.

[26] R. Manigandan, K. Giribabu, R. Suresh, L. Vijayalakshmi, A. Stephen, V. Narayanan, Cobalt oxide nanoparticles:Characterization and its electrocatalytic activity towards nitrobenzene, Chem. Sci. Trans. 2(2013) S47-50.

[27] M.T. Makhlouf, B.M. Abu-Zied, T.H. Mansoure, Direct fabrication of cobalt oxide nanoparticles employing sucrose as a combustion fuel, J. Nanopart. 2013(2013), 384350.

[28] M. Xu, Y. Wang, J. Geng, D. Jing, Photodecomposition of NOx on Ag/TiO₂ composite catalysts in a gas phase reactor, Chem. Eng. J. 307(2017) 181-188.

[29] S.A. Ansari, M.M. Khan, M.O. Ansari, M.H. Cho, Silver nanoparticles and defect-induced visible light photocatalytic and photoelectrochemical performance of Ag@m-TiO₂ nanocomposite, Sol. Energy Mater. Sol. Cells 141(2015) 162-170.

[30] S.S. Bhagade, S.R. Chaurasia, B.M. Bhanage, Reductive-hydroformylation of 1-octene to nonanol using fibrous Co₃O₄ catalyst, Catal. Today 309(2018) 147-152.

[31] G.P. Glaspell, P.W. Jadodzinski, A. Manivannan, Formation of cobalt nitrate hydrate, cobalt oxide, and cobalt nanoparticles using laser vaporization controlled condensation, J. Phys. Chem. B 108(28) (2004) 9604-9607.

[32] M. Saeed, M. Siddique, M. Usman, A. Haq, S.G. Khan, A. Rauf, Synthesis and characterization of Zinc oxide and evaluation of its catalytic activities for oxidative degradation of Rhodamine B dye in aqueous medium, Z. Phys. Chem. 231(2017) 1559-1572.

[33] A.R. Vartooni, M. Nasrollahzadeh, M.S. Niasari, M. Atarod, Photocatalytic degradation of azo dyes by titanium dioxide supported silver nanoparticles prepared by a green method using Carpobrotus acinaciformis extract, J. Alloys Compd. 689(2016) 15-20.

[34] N. Rana, S. Chand, A.K. Gathania, Synthesis and characterization of flower-like ZnO structures and their applications in photocatalytic degradation of Rhodamine B dye, J. Mater. Sci.-Mater. Electron. 27(20162504-2510.

[35] A. Umar, M.S. Akhtar, A. Al-Hajry, M.S. Al-Assiri, N.Y. Almehbad, Hydrothermally grown ZnO nanoflowers for environmental remediation and clean energy applications, Mater. Res. Bull. 47(20122407-2414.

[36] Y. Liang, N. Guo, L. Li, R. Li, G. Ji, S. Gan, Fabrication of porous 3D flower-like Ag/ZnO heterostructure composites with enhanced photocatalytic performance, Appl. Surf. Sci. 332(2015) 32-39.

[37] Y. Yang, L. Xu, C. Su, J. Che, W. Sun, H. Gao, Electrospun ZnO/Bi₂O₃ nanofibers with enhanced photocatalytic activity, J. Nanomater. 2014(2014), 130539.

[38] Y. Liang, N. Guo, L. Li, R. Li, G. Ji, S. Gan, Preparation of porous 3D Ce-doped ZnO microflowers with enhanced photocatalytic performance, RSC Adv. 5(2015) 59887-59894.

[39] Y.L. Pang, S. Bhatia, A.Z. Abdullah, Process behaviorofTiO₂ nanotube-enhanced sonocatalytic degradation of Rhodamine B in aqueous solution, Sep. Purif. Technol. 77(2011) 331-338.

[40] K.P. Mishra, P.R. Gogate, Intensification of degradation of aqueous solutions of rhodamine B using sonochemical reactors at operating capacity of 7 L, J. Environ. Manag. 92(2011) 1972-1977.

[41] P.V. Nidheesh, R. Gandhimathi, N.S. Sanjini, NaHCO₃ enhanced Rhodamine B removal from aqueous solution by graphite-graphite electro Fenton system, Sep. Purif. Technol. 132(2014) 568-576.

[42] Q.I. Rahman, M. Ahmad, S.K. Misra, M. Lohani, Effective photocatalytic degradation of rhodamine B dye by ZnO nanoparticles, Mater. Lett. 91(2013) 170-175.

[43] K.W. Jo, S.K. Kumar, M.A. Isaacs, A.F. Lee, S. Karthikeyan, Cobalt promoted TiO₂/GO for the photocatalytic degradation of oxytetracycline and Congo Red, Appl. Catal. B Environ. 201(2017) 159-168.

[44] M. Ilyas, M. Sadiq, Liquid phase aerobic oxidation of benzyl alcohol catalyzed by Pt/ZrO₂, Chem. Eng. Technol. 30(2007) 1391-1399.

[45] V.D. Makwana, Y.C. Son, A.R. Howell, S.L. Steven, The role of lattice oxygen in selective benzyl alcohol oxidation using OMS-2 catalyst:A kinetic and isotope-labeling study, J. Catal. 210(1) (2002) 46-52.

[46] R.J. Davis, J.L. Gainer, G. Neal, I. Wenwu, Photocatalytic decolourisation of wastewater dyes, Water Environ. Res. 66(1994) 50-53.

[47] B. Pare, S.B. Jonnalagadda, H. Tomar, P. Singh, V.W. Bhagwat, ZnO assisted photocatalytic degradation of acridine orange in aqueous solution using visible irradiation, Desalination 232(2008) 80-90.

Ag-Co₃O₄: Synthesis, characterization and evaluation of its photocatalytic activity towards degradation of rhodamine B dye in aqueous medium

Ag-Co₃O₄: Synthesis, characterization and evaluation of its photocatalytic activity towards degradation of rhodamine B dye in aqueous medium

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 6

编辑推荐

Metrics

本文评价

[1]	Shusheng Li, Rui Kuang, Xiangzheng Kong, Xiaoli Zhu, Xubao Jiang. Immobilization of cobalt oxide nanoparticles on porous nitrogen-doped carbon as electrocatalyst for oxygen evolution[J]. 中国化学工程学报, 2022, 52(12): 10-18.
[2]	Xiang Li, Bo Yang, Yaqin Wu, Saisai Lin, Lin Zhang. Homogeneous Co₃O₄ film electrode with enhanced oxygen evolution electrocatalysis via surface reduction[J]. 中国化学工程学报, 2021, 29(1): 221-227.
[3]	Yuwen Zhou, Yuexiu Jiang, Zuzeng Qin, Qinruo Xie, Hongbing Ji. Influence of Zr, Ce, and La on Co₃O₄ catalyst for CO₂ methanation at low temperature[J]. Chinese Journal of Chemical Engineering, 2018, 26(4): 768-774.
[4]	Mojtaba Amini, Mostafa Khaksar, Arkady Ellern, L. Keith Woo. A new nanocluster polyoxomolybdate[Mo₃₆O₁₁₀(NO)₄(H₂O)₁₄]·52H₂O: Synthesis, characterization and application in oxidative degradation of common organic dyes[J]. Chinese Journal of Chemical Engineering, 2018, 26(2): 337-342.
[5]	Huihui Gan, Futao Yi, Huining Zhang, Yongxing Qian, Huixia Jin, Kefeng Zhang. Facile ultrasonic-assisted synthesis of micro-nanosheet structure Bi₄Ti₃O₁₂/g-C₃N₄ composites with enhanced photocatalytic activity on organic pollutants[J]. Chinese Journal of Chemical Engineering, 2018, 26(12): 2628-2635.
[6]	Muhammad Ammar, Yan Cao, Peng He, Liguo Wang, Jiaqiang Chen, Huiquan Li. An efficient green route for hexamethylene-1,6-diisocyanate synthesis by thermal decomposition of hexamethylene-1,6-dicarbamate over Co₃O₄/ZSM-5 catalyst: An indirect utilization of CO₂[J]. Chinese Journal of Chemical Engineering, 2017, 25(12): 1760-1770.