Simultaneous removal of copper and zinc ions by low cost natural snail shell/hydroxyapatite/chitosan composite

doi:10.1016/j.cjche.2020.07.066

摘要/Abstract

摘要： In this work, the snail shell/hydroxyapatite/chitosan composite was prepared as adsorbent. The adsorption potential of the composite was studied for simultaneous sorption behavior of Zn (II) and Cu (II) ions in a batch system. Chitosan and hydroxyapatite (HAP) were extracted from shrimp shell and bone ash, respectively, so this is a low cost natural composite. To prepare the composite, chitosan was dissolved in acetic acid, then HAP and snail shell powders were added to the chitosan solution. The morphology and characterization of the composite was studied by SEM and EDX analysis. Atomic adsorption was used to measure the amount of the ions. Experimental parameters were optimized with Design Expert Software and five parameters such as the concentration of ions, pH, adsorbent amount and contact time were studied at room temperature. Optimized value for the parameters of Zn (II) and Cu (II) concentrations, pH, adsorbent dose, and contact time were 3.01 mg·L^-1, 5.5, 0.02 g and 95 min, respectively. The adsorption isotherms for Zn (II) and Cu (II) showed Langmuir and Tempkin, respectively. Kinetic and equilibrium studies showed the experimental data of Zn (II) and Cu (II) ions were best described by the pseudo-second-order model. Studies on thermodynamic show the adsorption process were physical and spontaneous.

关键词: Hydroxyapatite, Chitosan, Composite, Adsorbent

Abstract: In this work, the snail shell/hydroxyapatite/chitosan composite was prepared as adsorbent. The adsorption potential of the composite was studied for simultaneous sorption behavior of Zn (II) and Cu (II) ions in a batch system. Chitosan and hydroxyapatite (HAP) were extracted from shrimp shell and bone ash, respectively, so this is a low cost natural composite. To prepare the composite, chitosan was dissolved in acetic acid, then HAP and snail shell powders were added to the chitosan solution. The morphology and characterization of the composite was studied by SEM and EDX analysis. Atomic adsorption was used to measure the amount of the ions. Experimental parameters were optimized with Design Expert Software and five parameters such as the concentration of ions, pH, adsorbent amount and contact time were studied at room temperature. Optimized value for the parameters of Zn (II) and Cu (II) concentrations, pH, adsorbent dose, and contact time were 3.01 mg·L^-1, 5.5, 0.02 g and 95 min, respectively. The adsorption isotherms for Zn (II) and Cu (II) showed Langmuir and Tempkin, respectively. Kinetic and equilibrium studies showed the experimental data of Zn (II) and Cu (II) ions were best described by the pseudo-second-order model. Studies on thermodynamic show the adsorption process were physical and spontaneous.

Key words: Hydroxyapatite, Chitosan, Composite, Adsorbent

Abbas Bambaeero, Reza Bazargan-Lari. Simultaneous removal of copper and zinc ions by low cost natural snail shell/hydroxyapatite/chitosan composite[J]. 中国化学工程学报, 2021, 33(5): 221-230.

Abbas Bambaeero, Reza Bazargan-Lari. Simultaneous removal of copper and zinc ions by low cost natural snail shell/hydroxyapatite/chitosan composite[J]. Chinese Journal of Chemical Engineering, 2021, 33(5): 221-230.

参考文献

[1] J.R. Peralta-Videa, M.L. Lopez, M. Narayan, G. Saupe, J. Gardea-Torresdey, The biochemistry of environmental heavy metal uptake by plants: Implications for the food chain, Int. J. Biochem. Cell Biol. 41(2009) 1665-1677.
[2] U. Jadhav, H. Hocheng, A review of recovery of metals from industrial waste, J. Achiev. Mater. Manuf. Eng. 54(2012) 159-167.
[3] R. Wuana, F.E. Okieimen, Heavy metals in contaminated soils: A review of sources, chemistry, risks and best available strategies for remediation, ISRN Ecol. 2011(2011) 1-20.
[4] U. Förstner, Water pollution: wastewater, in: In: Integrated Pollution Control, Springer, Berlin Heidelelberg, (1998) 197-238.
[5] E. Barth, M. Ettinger, B.V. Salotto, Gt McDermott, Summary report on the effects of heavy metals on the biological treatment processes, J. Water Pollut. Control Fed. (1965) 86-96.
[6] M. Friedlova, The influence of heavy metals on soil biological and chemical properties, J. Soil Water. Sci. 5(2010) 21-27.
[7] V. Mushtakova, V. Fomina, V. Rogovin, Toxic effect of heavy metals on human blood neutrophils, Biol. Bull. 32(2005) 276-278.
[8] G. Notarachille, F. Arnesano, V. Calò, D. Meleleo, Heavy metals toxicity: Effect of cadmium ions on amyloid beta protein 1-42. Possible implications for Alzheimer’s disease, Biometals 27(2014) 371-388.
[9] J.M. Matés, J.A. Segura, F.J. Alonso, J. Márquez, Roles of dioxins and heavy metals in cancer and neurological diseases using ROS-mediated mechanisms, Free Radic. Biol. Med. 49(2010) 1328-1341.
[10] W. Shao, Q. Liu, X. He, H. Liu, A. Gu, Z. Jiang, Association between level of urinary trace heavy metals and obesity among children aged 6-19 years: NHANES 1999-2011, Environ. Sci. Pollut. Res. 24(2017) 11573-11581.
[11] I. Shiue, Association of urinary arsenic, heavy metal, and phthalate concentrations with food allergy in adults: National health and nutrition examination survey, 2005-2006, Ann. Allergy Asthma Immunol. 111(2013) 421-423.
[12] S. Podzimek, J. Prochazkova, L. Pribylova, J. Bártová, Z. Ulcová-Gallová, L. Mrklas, V. Stejskal, Effect of heavy metals on immune reactions in patients with infertility, Cas. Lek. Cesk. 142(2003) 285-288.
[13] E. Lynch, R. Braithwaite, A review of the clinical and toxicological aspects of ‘traditional’(herbal) medicines adulterated with heavy metals, Expert Opin. Drug Saf. 4(2005) 769-778.
[14] S.A. El Rehim, S. Sayyah, M. El Deeb, Electroplating of copper films on steel substrates from acidic gluconate baths, Appl. Sur. Sci. 165(2000) 249-254.
[15] J.C. Hsieh, C.C. Hu, T.C. Lee, The synergistic effects of additives on improving the electroplating of zinc under high current densities, J. Electrochem. Soc. 155(2008) D675-D681.
[16] V. Jassal, U. Shanker, B. Kaith, S. Shankar, Green synthesis of potassium zinc hexacyanoferrate nanocubes and their potential application in photocatalytic degradation of organic dyes, RSC Adv. 5(2015) 26141-26149.
[17] M. Hua, S. Zhang, B. Pan, W. Zhang, L. Lv, Q. Zhang, Heavy metal removal from water/wastewater by nanosized metal oxides: A review, J. Hazard. Mater. 211(2012) 317-331.
[18] F. Fu, Q. Wang, Removal of heavy metal ions from wastewaters: A review, J. Environ. Manage. 92(2011) 407-418.
[19] F. Veglio, F. Beolchini, Removal of metals by biosorption: A review, Hydrometallurgy 44(1997) 301-316.
[20] V. Renge, S. Khedkar, S.V. Pande, Removal of heavy metals from wastewater using low cost adsorbents: A review, Sci Revs Chem Commun 2(2012) 580-584.
[21] M. Saifuddin, P. Kumaran, Removal of heavy metal from industrial wastewater using chitosan coated oil palm shell charcoal, Electr. J. Biotechn. 8(2005) 43-53.
[22] L. Zhang, Y. Zeng, Z. Cheng, Removal of heavy metal ions using chitosan and modified chitosan: A review, J. Mol. Liq. 214(2016) 175-191.
[23] D.H.K. Reddy, S.M. Lee, Application of magnetic chitosan composites for the removal of toxic metal and dyes from aqueous solutions, Adv. Colloid Interface Sci. 201(2013) 68-93.
[24] R. Bazargan-Lari, H.R. Zafarani, M.E. Bahrololoom, A. Nemati, Removal of Cu (II) ions from aqueous solutions by low-cost natural hydroxyapatite/chitosan composite: Equilibrium, kinetic and thermodynamic studies, J. Taiwan Inst. Chem. Eng. 45(2014) 1642-1648.
[25] A. Ayoub, R.A. Venditti, J.J. Pawlak, A. Salam, M.A. Hubbe, Novel hemicellulose-chitosan biosorbent for water desalination and heavy metal removal, ACS Sustain. Chem. Eng. 1(2013) 1102-1109.
[26] N. Ahmad, S. Sultana, M.Z. Khan, S. Sabir, Chitosan based nanocomposites as efficient adsorbents for water treatment, In: Modern Age Waste Water Problems, Springer, 2020, pp. 69-83.
[27] R. Vidal, J. Moraes, Removal of organic pollutants from wastewater using chitosan: a literature review, Int. J. Environ. Sci. Technol. 16(2019) 1741-1754.
[28] C.L. Vieira, F.O.S. Neto, V.H. Carvalho-Silva, R. Signini, Design of apolar chitosan-type adsorbent for removal of Cu (II) and Pb (II): An experimental and DFT viewpoint of the complexation process, J. Environ. Chem. Eng. 7(2019) 103070.
[29] F. Heidari, M. Razavi, M.E. Bahrololoom, R. Bazargan-Lari, D. Vashaee, H. Kotturi, L. Tayebi, Mechanical properties of natural chitosan/ hydroxyapatite/magnetite nanocomposites for tissue engineering applications, Mater. Sci. Eng., C 6(2016) 338-344.
[30] W. Prongmanee, I. Alam, P. Asanithi, Hydroxyapatite/graphene oxide composite for electrochemical detection of L-Tryptophan, J. Taiwan Inst. Chem. Eng. 102(2019) 415-423.
[31] M. Aliabadi, M. Irani, J. Ismaeili, S. Najafzadeh, Design and evaluation of chitosan/hydroxyapatite composite nanofiber membrane for the removal of heavy metal ions from aqueous solution, J. Taiwan Inst. Chem. Eng. 45(2014) 518-526.
[32] A. Kaviani, S.M. Zebarjad, S. Javadpour, M. Ayatollahi, R Bazargan-Lari, Fabrication and characterization of low-cost freeze-gelated chitosan/collagen/hydroxyapatite hydrogel nanocomposite scaffold, Int. J. Polym. Anal. Charact. 24(2019) 191-203.
[33] R. Bazargan-Lari, M. Bahrololoom, A. Nemati, Sorption behavior of Zn (II) ions by low cost and biological natural hydroxyapatite/chitosan composite from industrial waste water, J. Food Agric. Environ. 9(2011) 892-897.
[34] E. Skwarek, Adsorption of Zn on synthetic hydroxyapatite from aqueous solution, Sep. Sci. Technol. 49(2014) 1654-1662.
[35] E. Skwarek, W. Janusz, Adsorption of Cd (II) ions at the hydroxyapatite/electrolyte solution interface, Separ. Sci. Technol. 51(2016) 11-21.
[36] W. Janusz, E. Skwarek, Study of sorption processes of strontium on the synthetic hydroxyapatite, Adsorption 22(2016) 697-706.
[37] W. Janusz, E. Skwarek, Effect of Co (II) ions adsorption in the hydroxyapatite/ aqueous NaClO₄ solution system on particles electrokinetics, Physicochem. Problems Min. Process. 54(2018) 31-39.
[38] A.M. Soliman, H.M. Elwy, T. Thiemann, Y. Majedi, F.T. Labata, N.A.F. AlRawashdehaf, Removal of Pb(II) ions from aqueous solutions by sulphuric acid-treated palm tree leaves, J. Taiwan Inst. Chem. Eng. 58(2016) 264-273.
[39] T. Guangqun, W. Yu, L. Yong, X. Dan, Removal of Pb(II) ions from aqueous solution by manganese oxide coated rice straw biochar A low-cost and highly effective sorbent, J. Taiwan Inst. Chem. Eng. 84(2018) 85-92.
[40] R. Bazargan-Lari, H.R. Zafarani, M.E. Bahrololoom, A. Nemati, Removal of Cu(II) ions from aqueous solution by low-cost natural hydroxyapatite/chitosan composite: Kinetic and thermodynamic studies, J. Taiwan Inst. Chem. Eng. 45(2013) 1642-1648.
[41] R. Bazargan-Lari, M.E. Bahrololoom, A. Nemati, Sorption behavior of Zn(II) ions by low cost and biological natural hydroxyapatite/chitosan composite from industrial waste water, J. Food Agric. Environ. 9(2011) 892-897.
[42] F. Heidari, M. Razavi, M.E. Bahrololoom, R. Bazargan-Lari, D. Vashaee, H. Kotturi, L. Tayebi, Mechanical properties of natural chitosan/ hydroxyapatite/magnetic nanocomposites for tissue engineering applications, Mater. Sci. Eng. 65(2016) 338-344.
[43] P. Ricou-Hoeffer, I. Lecuyer, P. Le Cloirec, Experimental design methodology applied to adsorption of metallic ions onto fly ash, Water Res. 35(2001) 965-976.
[44] S. Teixeira, C. Delerue-Matos, L. Santos, Application of experimental design methodology to optimize antibiotics removal by walnut shell based activated carbon, Sci. Total Environ. 646(2019) 168-176.
[45] M. Bahrami, M.J. Amiri, F. Bagheri, Optimization of the lead removal from aqueous solution using two starch based adsorbents: design of experiments using response surface methodology (RSM), J. Environ. Chem. Eng. 7(2019) 102793.
[46] B. Rahimi, A. Ebrahimi, Photocatalytic process for total arsenic removal using an innovative BiVO₄/TiO₂/LED system from aqueous solution: Optimization by responsesurfacemethodology(RSM), J. Taiwan Inst. Chem. Eng.101(2019)64-79.
[47] J. Shu, R. Liu, H. Wu, Z. Liu, X. Sun, C. Tao, Adsorption of methylene blue on modified electrolytic manganese residue: Kinetics, isotherm, thermodynamics and mechanism analysis, J. Taiwan Inst. Chem. Eng. 82(2018) 351-359.
[48] I. Langmuir, The constitution and fundamental properties of solids and liquids. Part I. Solids, J. Am. Chem. Soc. 38(1916) 2221-2295.
[49] H. Freundlich, Über die adsorption in lösungen, Z. Phys. Chem. 57(1907) 385-470.
[50] C. Pearce, J. Lloyd, J. Guthrie, The removal of colour from textile wastewater using whole bacterial cells: A review, Dyes Pigm. 58(2003) 179-196.
[51] M. Tempkin, V. Pyzhev, Kinetics of ammonia synthesis on promoted iron catalysts, Acta Physiochim. URSS 12(1940) 327-356.
[52] A. Özer, G. Akkaya, M. Turabik, Biosorption of Acid Red 274(AR 274) on Enteromorpha prolifera in a batch system, J. Hazard. Mater. 126(2005) 119-127.
[53] K. Tan, B. Hameed, Insight into the adsorption kinetics models for the removal of contaminants from aqueous solutions, J. Taiwan Inst. Chem. Eng. 74(2017) 25-48.
[54] S. Lagergren, Zur theorie der sogenannten adsorption geloster stoffe, Kungliga Svenska Vetenskapsakademiens Handlingar 24(1898) 1-39.
[55] Y.-S. Ho, G. McKay, Pseudo-second order model for sorption processes, Process Biochem. 34(1999) 451-465.
[56] C. Aharoni, F. Tompkins, Kinetics of adsorption and desorption and the Elovich equation, Advances in Catalysis, 21(1970) 1-49.
[57] W.J. Weber, J.C. Morris, Kinetics of adsorption on carbon from solution, Sanit. Eng. Div. 89(1963) 31-60.