Role of Periodic Input Composition and Sweeping Gas for Improvement of Hydrogen Production in a Palladium Membrane Reactor by Partial Oxidation of Methane

摘要/Abstract

摘要： The partial oxidation of methane under periodic operation over Ni/γ-Al₂O₃ catalyst was investigated in a Pd-membrane reactor.The effects of key parameters such as the inlet composition and the sweeping gas on methane conversion and the hydrogen recovery are numerically established with two periodic input functions.In order to analyze the effect of the inputs modulation,the reaction was performed under low steam to methane ratio at a moderate temperature and pressure.It was obtained that to achieve process intensification is to operate the process in a periodic way.The main results show that the periodic input functions can improve the performance of the process compared to the optimal steady state operation.Moreover,there is an optimum amplitude of manipulated inputs leads to a maximum of hydrogen recovery.It is noteworthy that the comparison between the predicted performance via the sinusoidal and the square ways show that the better average performance was obtained with the square way.

关键词: hydrogen production, modulation, periodic operation, Pd-membrane reactor

Abstract: The partial oxidation of methane under periodic operation over Ni/γ-Al₂O₃ catalyst was investigated in a Pd-membrane reactor.The effects of key parameters such as the inlet composition and the sweeping gas on methane conversion and the hydrogen recovery are numerically established with two periodic input functions.In order to analyze the effect of the inputs modulation,the reaction was performed under low steam to methane ratio at a moderate temperature and pressure.It was obtained that to achieve process intensification is to operate the process in a periodic way.The main results show that the periodic input functions can improve the performance of the process compared to the optimal steady state operation.Moreover,there is an optimum amplitude of manipulated inputs leads to a maximum of hydrogen recovery.It is noteworthy that the comparison between the predicted performance via the sinusoidal and the square ways show that the better average performance was obtained with the square way.

Key words: hydrogen production, modulation, periodic operation, Pd-membrane reactor

Lemnouer Chibane, Brahim Djellouli. Role of Periodic Input Composition and Sweeping Gas for Improvement of Hydrogen Production in a Palladium Membrane Reactor by Partial Oxidation of Methane[J]. , 2012, 20(3): 577-588.

参考文献

1 Dong, H., Shao, Z., Xiong, G., Tong, J., Sheng, S., Yang, W., "Investigation on POM reaction in a new perovskite membrane reactor", Catal. Today, 67, 3-13 (2001).
2 Lu, H., Tong, J., Cong, Y., Yang, W., "Partial oxidation of methane in Ba_0.5Sr_0.5Co_0.8Fe_0.2O_3-δ membrane reactor at high pressures", Catal. Today, 104, 154-159 (2005).
3 Nirmal, G.V., Reddy, B.V., Rosen, M.A., "Feasibility of an energy conversion system in Canada involving large-scale integrated hydrogen production using solid fuels", Int. J. Hydrogen Energy, 35, 4788-4807 (2010).
4 Eisler, M.N., "Getting power to the people: technological dramaturgy and the quest for the electrochemical engine", History and Technology, 25, 49-68 (2009).
5 Conte, M., Iacobazzy, A., Ronchetti, M., Vellone, R., "Hydrogen economy for a sustainable development: State of the art and technological perspectives", J. Power Sources, 100, 171-187 (2001).
6 Shu, J., Grandjean, B.P.A., Kaliaguine, S., "Methane steam reforming in asymmetric Pd and Pd-Ag/porous SS membrane reactors", Appl. Catal. A: Gen., 119, 305-325 (1994).
7 Froment, G.F., "Production of synthesis gas by steam-and CO₂-reforming of natural gas", J. Molec. Catal. A. Chem., 163, 147-156 (2000).
8 Chen, Z., Prasad, P., Yan, Y., Elnashaie, S.S.E.H., "Simulation for steam reforming of natural gas with oxygen input in a novel membrane reformer", Fuel Process. Technol., 83, 235-252 (2003).
9 Chen, Y., Xu, H., Wang, Y., Jin, X., Xiong, G., "Hydrogen production from liquid hydrocarbon fuels for PEMFC application", Fuel Process. Technol., 87, 971-978 (2006).
10 Chen, Y., Xu, H., Wang, Y., Xiong, G., "Hydrogen production from the steam reforming of liquid hydrocarbons in membrane reactor", Catal. Today, 118, 136-143 (2006).
11 Houtiet, A., Mahzoul, H., Ehrburger, P., Bernhardt, P., Legare, P., Garin, F., "Production of hydrogen by steam reforming of methanol over copper-based catalysts: The effect of cesium doping", Appl. Catal. A: Gen., 306, 22-28 (2006).
12 Kapdan, I.K., Kargi, F., "Bio-hydrogen production from waste materials", Enzyme Microbiol. Technol., 38, 569-582 (2006).
13 Steinfeld, A., "Solar thermochemical production of hydrogen-A review", Solar Energy, 78, 603-615 (2005).
14 Basile, A., Paturzo, L., "An experimental study of multilayered composite palladium membrane reactors for partial oxidation of methane to syngas", Catal. Today, 67, 55-64 (2001).
15 Basile, A., Paturzo, L., Lagana, F., "The partial oxidation of methane to syngas in a palladium membrane reactor: simulation and experimental studies", Catal. Today, 67, 65-75 (2001).
16 De Groote, A.M., Froment, G.F., "Simulation of the catalytic partial oxidation of methane to synthesis gas", Appl. Catal. A: Gen., 138, 245-264 (1996).
17 Rui, Z., Zhang, K., Li, Y., Lin, Y.S., "Simulation of methane conversion to syngas in a membrane reactor. Part Ⅰ: A model including product oxidation", Int. J. Hydrogen Energy, 33, 2246-2253 (2008).
18 Christian, E.B., Lodeng, R., Holmen, A., "A review of catalytic partial oxidation of methane to synthesis gas with emphasis on reaction mechanisms over transition metal catalysts", App. Cat. A. Gen., 346, 1-27 (2008).
19 Galuszka, J., Pandey, R.N., Ahmed, S., "Methane conversion to syngas in a palladium membrane reactor", Catal. Today, 46, 83-89 (1998).
20 Chen, Y., Wang, Y., Xu, H., Xiong, G., "Efficient production of hydrogen from natural gas steam reforming in palladium membrane reactor", Appl. Catal. B: Environ., 81, 283-294 (2008).
21 Oklany, J.S., Hou, K., Hughes, R., "A simulative comparison of dense and microporous membrane reactors for the steam reforming of methane", Appl. Catal. A: Gen., 170, 13-22 (1998).
22 Yu, W., Ohmori, T., Yamamoto, T., Endo, A., Nakaiwa, M., Itoh, N., "Optimal design and operation of methane steam reforming in a porous ceramic membrane reactor for hydrogen production", Chem. Eng. Sci., 62, 5627-5631 (2007).
23 Bouwmeester, H.J.M., "Dense ceramic membranes for methane conversion", Catal. Today, 82, 141-150 (2003).
24 De Falco, M., Di Paola, L., Marrelli, L., Nardella, P., "Simulation of large-scale membrane reformers by two-dimensional model", Chem. Eng. J., 128, 115-125 (2007).
25 Armor, J.N., "Applications of catalytic inorganic membrane reactors to refinery products", J. Membr. Sci., 147, 217-233 (1998).
26 Matsumura, Y., Uragami, M., Nakamori, T., Morimoto, S., "A proposal of new hydrogen production process employing equilibrium-shift technology", J. Jpn. Pet. Inst., 46, 166-171 (2003).
27 Bonrath, W., "Ultrasound supported catalysis", Ultrasonics Sonochemistry, 12, 103-106 (2005).
28 Silveston, P.L., Hudgins, R.R., "Periodic pressure forcing of catalytic reactions", Chem. Eng. Sci., 59, 4055-4064 (2004).
29 Silveston, P.L., Hudgins, R.R., Renken, A., "Periodic operation of catalytic reactors-introduction and overview", Catal. Today, 25, 91-112 (1995).
30 Petkovska, M., Nikolic, D., Markovic, A., Seidel, M.A., "Fast evaluation of periodic operation of a heterogeneous reactor based on non linear frequency response analysis", Chem. Eng. Sci., 65, 3632-3637 (2010).
31 Benguerba, Y., Djellouli, B., "Enhancement of the catalytic performances in the case of a consecutive-parallel reaction scheme", Int. J. Chem. Reactor Eng., 8, A64 (2010).
32 Chan, S.H., Wang, H.M., "Thermodynamic analysis of natural gas fuel processing for fuel cell applications", Int. J. Hydrogen Energy, 25, 441-449 (2000).
33 Tong, J., Matsumura, Y., "Effect of catalytic activity on methane steam reforming in hydrogen-permeable membrane reactor", Appl. Catal. A: Gen., 286, 226-231 (2005).
34 Ma, L., Trimm, D.L., Jiang, C., "The design and testing of an autothermal reactor for the conversion of light hydrocarbons to hydrogen-I. The kinetics of the catalytic oxidation of light hydrocarbons", Appl. Catal. A: Gen., 138, 275-283 (1996).
35 Xu, J., Froment, G.F., "Methane steam reforming, methanation and water-gas shift: I. Intrinsic kinetics", AIChE J., 35, 88-96 (1989).
36 Trimm, D.L., Lam, C.W., "The combustion of methane on platinum-alumina fiber catalysts-I: kinetics and mechanism", Chem. Eng. Sci., 35, 1405-1413 (1980).
37 De Smet, C.R.H., De Croon, M.H.J.M., Berger, R.J., Marin, G.B., Schouten, J.C., "Design of adiabatic fixed-bed reactors for the partial oxidation of methane to synthesis gas. Application to production of methanol and hydrogen-for-fuel-cells", Chem. Eng. Sci., 56, 4849-4861 (2001)
38 Zhang, Y., Xiong, G., Sheng, S., Yang, W., "Deactivation studies over NiO/γ-Al₂O₃ catalyst for partial oxidation of methane to syngas", Catal. Today, 63, 517-522 (2000).
39 Xiu, G.H., Li, P., Rodrigues, A.E., "Sorption-enhanced reaction process with reactive regeneration", Chem. Eng. Sci., 57, 3893-3908 (2002).
40 Hoang, D.L., Chan, S.H., "Effect of reactor dimensions on the performance of an O₂ pump integrated partial oxidation reformer: a modeling approach", Int. J. Hydrogen Energy, 31, 1-12 (2006).
41 Halabi, M.H., De Croon, M.H.J.M., Van der Schaaf, J., Cobden, P.D., Schouten, J.C., "Modeling and analysis of autothermal reforming of methane to hydrogen in a fixed bed reformer", Chem. Eng. J., 137, 568-578 (2008).
42 Barbieri, G., Brunetti, A., Tricoli, G., Drioli, E., "An innovative configuration of a Pd-based membrane reactor for the production of pure hydrogen: Experimental analysis of water gas shift", J. Power Sources, 182, 160-167 (2008).
43 Fernandes, F.A.N., Soares, A.B.Jr, "Methane steam reforming modeling in a palladium membrane reactor", Fuel, 85, 569-573 (2006).
44 Hickman, D.A., Schmidt, L.D., "Synthesis gas formation by direct oxidation of methane over Pt monoliths", J. Catal., 138, 267-282 (1992).
45 Aida, T., Silveston, P.L., Periodic Operation in "Cyclic Separating Reactors", Blackwell Publishing Ltd., 12-23 (2005)

[1]	Yishuang Wang, Na Li, Mingqiang Chen, Defang Liang, Chang Li, Quan Liu, Zhonglian Yang, Jun Wang. Glycerol steam reforming over hydrothermal synthetic Ni-Ca/attapulgite for green hydrogen generation[J]. 中国化学工程学报, 2022, 48(8): 176-190.
[2]	Ying Zhou, Ruiying Li, Zexuan Lv, Jian Liu, Hongjun Zhou, Chunming Xu. Green hydrogen: A promising way to the carbon-free society[J]. 中国化学工程学报, 2022, 43(3): 2-13.
[3]	Xuanyi Jia, Xiaomin Hu, Qiao Wang, Baiquan Chen, Xingyue Xie, Lihong Huang. Auto-thermal reforming of acetic acid for hydrogen production by Zn_xNi_yCrO_m±δ catalysts: Effect of Cr promoted Ni-Zn intermetallic compound[J]. 中国化学工程学报, 2022, 43(3): 216-221.
[4]	Xueting Liu, Chunhui Hu, Jingjing Wu, Peng Cui, Fengyu Wei. Defective NH₂-UiO-66 (Zr) effectively converting CO₂ into cyclic carbonate under ambient pressure, solvent-free and co-catalyst-free conditions[J]. 中国化学工程学报, 2022, 43(3): 222-229.
[5]	Feng Guo, Haoran Sun, Yuxing Shi, Fengyu Zhou, Weilong Shi. CdS nanoparticles decorated hexagonal Fe₂O₃ nanosheets with a Z-scheme photogenerated electron transfer path for improved visible-light photocatalytic hydrogen production[J]. 中国化学工程学报, 2022, 43(3): 266-274.
[6]	Yixuan Gong, Jiasai Yao, Ping Wang, Zhenxing Li, Hongjun Zhou, Chunming Xu. Perspective of hydrogen energy and recent progress in electrocatalytic water splitting[J]. 中国化学工程学报, 2022, 43(3): 282-296.
[7]	Jiankang Wang, Yajing Wang, Zhongping Yao, Zhaohua Jiang. Metal-organic framework-derived Ni doped Co₃S₄ hierarchical nanosheets as a monolithic electrocatalyst for highly efficient hydrogen evolution reaction in alkaline solution[J]. 中国化学工程学报, 2022, 42(2): 380-388.
[8]	Hang Yao, Yuwei He, Jinrong Ma, Lang Jiang, Jingan Li, Jin Wang, Nan Huang. Recent advances in cardiovascular stent for treatment of in-stent restenosis: Mechanisms and strategies[J]. 中国化学工程学报, 2021, 37(9): 12-29.
[9]	Patsakol Prayoonpunratn, Trin Jedsukontorn, Mali Hunsom. Photocatalytic activity of metal nanoparticle-decorated titanium dioxide for simultaneous H₂ production and biodiesel wastewater remediation[J]. 中国化学工程学报, 2021, 36(8): 86-100.
[10]	Xuehua Ruan, Wenbo Huo, Jiaming Wang, Minggang Guo, Wenji Zheng, Yun Zou, Aibin Huang, Jianxiang Shou, Gaohong He. Multi-technique integration separation frameworks after steam reforming for coal-based hydrogen generation[J]. 中国化学工程学报, 2021, 35(7): 163-172.
[11]	Abd El-Aziz S. Fouda, Mohamed A. Ismail, Abdulraqeb A. Al-Khamri, Ashraf S. Abousalem. Corrosion inhibition of carbon steel in hydrochloric acid by cationic arylthiophenes as new eco-friendly inhibitors: Experimental and quantum chemical study[J]. 中国化学工程学报, 2021, 40(12): 197-217.
[12]	Vivekanand S. V. B., Raju V. R. K.. Effect of wall temperature modulation on the heat transfer characteristics of droplet-train flow inside a rectangular microchannel[J]. 中国化学工程学报, 2020, 28(3): 685-697.
[13]	Anis H. Fakeeha, Ahmed S. Al-Fatesh, Biswajit Chowdhury, Ahmed A. Ibrahim, Wasim U. Khan, Shahid Hassan, Kasim Sasudeen, Ahmed Elhag Abasaeed. Bi-metallic catalysts of mesoporous Al₂O₃ supported on Fe, Ni and Mn for methane decomposition: Effect of activation temperature[J]. Chinese Journal of Chemical Engineering, 2018, 26(9): 1904-1911.
[14]	Zhongping Yao, Yajun Zhang, Yaqiong He, Qixing Xia, Zhaohua Jiang. Synthesis of hierarchical dendritic micro-nano structure ZnFe₂O₄ and photocatalytic activities for water splitting[J]. , 2016, 24(8): 1112-1116.
[15]	王保伟, 孙启梅, 吕一军, 杨美琳, 闫文娟. Steam Reforming of Dimethyl Ether by Gliding Arc Gas Discharge Plasma for Hydrogen Production[J]. Chinese Journal of Chemical Engineering, 2014, 22(1): 104-112.