Coordination of distinctive pesticide adjuvants and atomization nozzles on droplet spectrum evolution for spatial drift reduction

doi:10.1016/j.cjche.2023.10.001

中国化学工程学报 ›› 2024, Vol. 66 ›› Issue (2): 250-262.DOI: 10.1016/j.cjche.2023.10.001

• Full Length Article • 上一篇下一篇

Coordination of distinctive pesticide adjuvants and atomization nozzles on droplet spectrum evolution for spatial drift reduction

Shidong Xue^1,2, Jingkun Han^1,3, Xi Xi⁴, Zhong Lan¹, Rongfu Wen¹, Xuehu Ma¹

1. State Key Laboratory of Fine Chemicals, Liaoning Key Laboratory of Clean Utilization of Chemical Resources, Institute of Chemical Engineering, School of Chemical Engineering, Dalian University of Technology, Dalian 16024, China;
2. School of Fashion and Textiles, The Hong Kong Polytechnic University, Hong Kong 999077, China;
3. China Tianchen Engineering Corporation, Tianjin 300400, China;
4. School of Energy and Power Engineering, Dalian University of Technology, Dalian 116024, China

收稿日期:2023-06-10 修回日期:2023-10-07 出版日期:2024-02-28 发布日期:2024-04-20
通讯作者: Xuehu Ma,E-mail:xuehuma@dlut.edu.cn
基金资助:
This work was financially supported by the National Key Research and Development Program of China (2017YFD0200304).

Coordination of distinctive pesticide adjuvants and atomization nozzles on droplet spectrum evolution for spatial drift reduction

Shidong Xue^1,2, Jingkun Han^1,3, Xi Xi⁴, Zhong Lan¹, Rongfu Wen¹, Xuehu Ma¹

1. State Key Laboratory of Fine Chemicals, Liaoning Key Laboratory of Clean Utilization of Chemical Resources, Institute of Chemical Engineering, School of Chemical Engineering, Dalian University of Technology, Dalian 16024, China;
2. School of Fashion and Textiles, The Hong Kong Polytechnic University, Hong Kong 999077, China;
3. China Tianchen Engineering Corporation, Tianjin 300400, China;
4. School of Energy and Power Engineering, Dalian University of Technology, Dalian 116024, China

Received:2023-06-10 Revised:2023-10-07 Online:2024-02-28 Published:2024-04-20
Contact: Xuehu Ma,E-mail:xuehuma@dlut.edu.cn
Supported by:
This work was financially supported by the National Key Research and Development Program of China (2017YFD0200304).

摘要/Abstract

摘要： Pesticide adjuvants, as crop protection products, have been widely used to reduce drift loss and improve utilization efficiency by regulating droplet spectrum. However, the coordinated regulation mechanisms of adjuvants and nozzles on droplet spectrum remain unclear. Here, we established the relationship between droplet spectrum evolution and liquid atomization by investigating the typical characteristics of droplet diameter distribution near the nozzle. Based on this, the regulation mechanisms of distinctive pesticide adjuvants on droplet spectrum were clarified, and the corresponding drift reduction performances were quantitively evaluated by wind tunnel experiments. It shows that the droplet diameter firstly shifts to the smaller due to the liquid sheet breakup and then prefers to increase caused by droplet interactions. Reducing the surface tension of sprayed liquid facilitates the uniform liquid breakup and increasing the viscosity inhibits the liquid deformation, which prolong the atomization process and effectively improve the droplet spectrum. As a result, the drift losses of flat-fan and hollow cone nozzles are reduced by about 50 % after adding organosilicon and vegetable oil adjuvants. By contrast, the air induction nozzle shows a superior anti-drift ability, regardless of distinctive adjuvants. Our findings provide insights into rational adjuvant design and nozzle selection in the field application.

关键词: Pesticide drift, Spray droplets, Particle size distribution, Spray atomization, Transport processes, Adjuvants

Abstract: Pesticide adjuvants, as crop protection products, have been widely used to reduce drift loss and improve utilization efficiency by regulating droplet spectrum. However, the coordinated regulation mechanisms of adjuvants and nozzles on droplet spectrum remain unclear. Here, we established the relationship between droplet spectrum evolution and liquid atomization by investigating the typical characteristics of droplet diameter distribution near the nozzle. Based on this, the regulation mechanisms of distinctive pesticide adjuvants on droplet spectrum were clarified, and the corresponding drift reduction performances were quantitively evaluated by wind tunnel experiments. It shows that the droplet diameter firstly shifts to the smaller due to the liquid sheet breakup and then prefers to increase caused by droplet interactions. Reducing the surface tension of sprayed liquid facilitates the uniform liquid breakup and increasing the viscosity inhibits the liquid deformation, which prolong the atomization process and effectively improve the droplet spectrum. As a result, the drift losses of flat-fan and hollow cone nozzles are reduced by about 50 % after adding organosilicon and vegetable oil adjuvants. By contrast, the air induction nozzle shows a superior anti-drift ability, regardless of distinctive adjuvants. Our findings provide insights into rational adjuvant design and nozzle selection in the field application.

Key words: Pesticide drift, Spray droplets, Particle size distribution, Spray atomization, Transport processes, Adjuvants

Shidong Xue, Jingkun Han, Xi Xi, Zhong Lan, Rongfu Wen, Xuehu Ma. Coordination of distinctive pesticide adjuvants and atomization nozzles on droplet spectrum evolution for spatial drift reduction[J]. 中国化学工程学报, 2024, 66(2): 250-262.

参考文献

[1] X.L. Pan, F.S. Dong, X.H. Wu, J. Xu, X.G. Liu, Y.Q. Zheng, Progress of the discovery, application, and control technologies of chemical pesticides in China, J. Integr. Agric. 18(4)(2019)840-853.
[2] C.D. Osteen, J. Fernandez-Cornejo, Economic and policy issues of U.S. agricultural pesticide use trends, Pest Manag. Sci. 69(9)(2013)1001-1025.
[3] F.H.M. Tang, M. Lenzen, A. McBratney, F. Maggi, Risk of pesticide pollution at the global scale, Nat. Geosci. 14(4)(2021)206-210.
[4] A.R.C. Braga, V.V. de Rosso, C.A.Y. Harayashiki, P.C. Jimenez, I.B. Castro, Global health risks from pesticide use in Brazil, Nat. Food 1(6)(2020)312-314.
[5] N. De Cock, M. Massinon, S.O.T. Salah, F. Lebeau, Investigation on optimal spray properties for ground based agricultural applications using deposition and retention models, Biosyst. Eng. 162(2017)99-111.
[6] X. Zhao, H.X. Cui, Y. Wang, C.J. Sun, B. Cui, Z.H. Zeng, Development strategies and prospects of nano-based smart pesticide formulation, J. Agric. Food Chem. 66(26)(2018)6504-6512.
[7] C. Cao, Z.L. Zhou, L.D. Cao, L. Zheng, J. Xu, F.M. Li, Q.L. Huang, Influence of the surface limiting elasticity modulus on the impact behavior of droplets of difenoconazole-loaded mesoporous silica nanoparticles with associated SDS, Soft Matter 14(29)(2018)6070-6075.
[8] ISO 22866:2005, Equipment for crop protection-Methods for field measurement of spray drift, 2005.
[9] C.L. Wang, A. Herbst, A.J. Zeng, S. Wongsuk, B.Y. Qiao, P. Qi, J. Bonds, V. Overbeck, Y. Yang, W.L. Gao, X.K. He, Assessment of spray deposition, drift and mass balance from unmanned aerial vehicle sprayer using an artificial vineyard, Sci. Total Environ. 777(2021)146181.
[10] J.C. Ferguson, C.C. O'Donnell, B.S. Chauhan, S.W. Adkins, G.R. Kruger, R.B. Wang, P.H. Urach Ferreira, A.J. Hewitt, Determining the uniformity and consistency of droplet size across spray drift reducing nozzles in a wind tunnel, Crop Prot. 76(2015)1-6.
[11] S.W. Hong, J. Park, H. Jeong, S. Lee, L. Choi, L.Y. Zhao, H.P. Zhu, Fluid dynamic approaches for prediction of spray drift from ground pesticide applications:A review, Agronomy 11(6)(2021)1182.
[12] M. Al Heidary, J.P. Douzals, C. Sinfort, A. Vallet, Influence of spray characteristics on potential spray drift of field crop sprayers:A literature review, Crop Prot. 63(2014)120-130.
[13] D. Nuyttens, I.K.A. Zwertvaegher, D. Dekeyser, Spray drift assessment of different application techniques using a drift test bench and comparison with other assessment methods, Biosyst. Eng. 154(2017)14-24.
[14] M. Taylor, S.M. Lyons, C.L. Davie-Martin, T.S. Geoghegan, K.J. Hageman, Understanding trends in pesticide volatilization from agricultural fields using the pesticide loss via volatilization model, Environ. Sci. Technol. 54(4)(2020)2202-2209.
[15] Z.C. Wang, L.C. Lan, X.K. He, A. Herbst, Dynamic evaporation of droplet with adjuvants under different environment conditions, Int. J. Agric. Biol. Eng. 13(2)(2020)1-6.
[16] S.D. Xue, J.K. Han, X. Xi, J.Y. Zhao, Z. Lan, R.F. Wen, X.H. Ma, Rapid velocity reduction and drift potential assessment of off-nozzle pesticide droplets, Chin. J. Chem. Eng. 46(2022)243-254.
[17] S.D. Xue, X. Xi, Z. Lan, R.F. Wen, X.H. Ma, Longitudinal drift behaviors and spatial transport efficiency for spraying pesticide droplets, Int. J. Heat Mass Transf. 177(2021)121516.
[18] M. Massinon, N. De Cock, S.O.T. Salah, F. Lebeau, Reduced span spray-Part 1:Retention, Asp. Appl. Biol. 132(2016)1-8.
[19] S.H. Yu, Y.T. Yun, Y. Choi, R.A. Dafsari, J. Lee, Effect of injection angle on drift potential reduction in pesticide injection nozzle spray applied in domestic agricultural drones, J. Biosyst. Eng. 46(2)(2021)129-138.
[20] H.B. Chen, B. K Fritz, Y.B. Lan, Z.Y. Zhou, J.F. Zheng, Overview of spray nozzles for plant protection from manned aircrafts:Present research and prospective, Int. J. Precis. Agric. Aviat. 1(1)(2018)1-12.
[21] Q. Liu, C.F. Shan, H.Y. Zhang, C.C. Song, Y.B. Lan, Evaluation of liquid atomization and spray drift reduction of hydraulic nozzles with four spray adjuvant solutions, Agriculture 13(2)(2023)236.
[22] E. Hilz, A.W.P. Vermeer, Spray drift review:The extent to which a formulation can contribute to spray drift reduction, Crop Prot. 44(2013)75-83.
[23] R. Sijs, S. Kooij, D. Bonn, How surfactants influence the drop size in sprays from flat fan and hollow cone nozzles, Phys. Fluids 33(11)(2021)113608.
[24] P. Spanoghe, M. De Schampheleire, P. Van der Meeren, W. Steurbaut, Influence of agricultural adjuvants on droplet spectra, Pest. Manag. Sci. 63(1)(2007)4-16.
[25] W.T. Yang, W.D. Jia, M.X. Ou, W. Zhong, L. Jiang, X.W. Wang, Effect of physical properties of an emulsion pesticide on the atomisation process and the spatial distribution of droplet size, Agriculture 12(7)(2022)949.
[26] X.G. Zhang, L.X. Xiong, Effect of adjuvants on the spray droplet size of pesticide dilute emulsion, Colloids Surf. A 619(2021)126557.
[27] S. Kooij, R. Sijs, M.M. Denn, E. Villermaux, D. Bonn, What determines the drop size in sprays?Phys. Rev. X 8(3)(2018)031019.
[28] I. Makhnenko, E.R. Alonzi, S.A. Fredericks, C.M. Colby, C.S. Dutcher, A review of liquid sheet breakup:Perspectives from agricultural sprays, J. Aerosol Sci. 157(2021)105805.
[29] Y.Y. Song, F. Zhu, C. Cao, L.D. Cao, F.M. Li, P.Y. Zhao, Q.L. Huang, Reducing pesticide spraying drift by folate/Zn²⁺ supramolecular hydrogels, Pest Manag. Sci. 77(11)(2021)5278-5285.
[30] B. Liu, Y.X. Fan, H.F. Li, W.W. Zhao, S.Q. Luo, H.A. Wang, B. Guan, Q.L. Li, J.L. Yue, Z.C. Dong, Y.L. Wang, L. Jiang, Control the entire journey of pesticide application on superhydrophobic plant surface by dynamic covalent trimeric surfactant coacervation, Adv. Funct. Mater. 31(5)(2021)2006606.
[31] D. Katzman, Y. Bohbot-Raviv, Y. Dubowski, Does polyacrylamide-based adjuvant actually reduce primary drift of airborne pesticides?Sci. Total Environ. 775(2021)145816.
[32] X.M. Song, X. Xi, S.D. Xue, J.Y. Zhao, J.K. Han, X.H. Ma, Z. Lan, T.T. Hao, Effects of pesticide adjuvants on spray pendant droplet evaporation, J. Chem. Eng. Chin. Univ. 34(5)(2020)1143-1150, in Chinese.
[33] S.C. Gao, G.B. Wang, Y.Y. Zhou, M. Wang, D.B. Yang, H.Z. Yuan, X.J. Yan, Water-soluble food dye of Allura Red as a tracer to determine the spray deposition of pesticide on target crops, Pest Manag. Sci. 75(10)(2019)2592-2597.
[34] Y. He, S.P. Xiao, J.J. Wu, H. Fang, Influence of multiple factors on the wettability and surface free energy of leaf surface, Appl. Sci. 9(3)(2019)593.
[35] Y.Y. Song, Q.L. Huang, G.Z. Huang, M.X. Liu, L.D. Cao, F.M. Li, P.Y. Zhao, C. Cao, The effects of adjuvants on the wetting and deposition of insecticide solutions on hydrophobic wheat leaves, Agronomy 12(9)(2022)2148.
[36] A.L. Altieri, S.A. Cryer, Break-up of sprayed emulsions from flat-fan nozzles using a hole kinematics model, Biosyst. Eng. 169(2018)104-114.
[37] R.B. Wang, G. Dorr, A. Hewitt, J. Cooper-White, Impacts of polymer/surfactant interactions on spray drift, Colloids Surf. A 500(2016)88-97.
[38] C.L. Wang, A.J. Zeng, X.K. He, J.L. Song, A. Herbst, W.L. Gao, Spray drift characteristics test of unmanned aerial vehicle spray unit under wind tunnel conditions, Int. J. Agric. Biol. Eng. 13(3)(2020)13-21.
[39] M.C. Butler Ellis, A.G. Lane, C.M. O'Sullivan, S. Jones, Wind tunnel investigation of the ability of drift-reducing nozzles to provide mitigation measures for bystander exposure to pesticides, Biosyst. Eng. 202(2021)152-164.
[40] R. Alidoost Dafsari, S. Yu, Y. Choi, J. Lee, Effect of geometrical parameters of air-induction nozzles on droplet characteristics and behaviour, Biosyst. Eng. 209(2021)14-29.
[41] J. Hu, C.X. Liu, Z.C. Wang, Y.F. Li, J.L. Song, Y.J. Liu, X. Chu, Motion model for describing the quantity of air in droplets through changing the structure of air induction nozzle, Int. J. Agric. Biol. Eng. 14(5)(2021)35-40.

Coordination of distinctive pesticide adjuvants and atomization nozzles on droplet spectrum evolution for spatial drift reduction

Coordination of distinctive pesticide adjuvants and atomization nozzles on droplet spectrum evolution for spatial drift reduction

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 10

编辑推荐

Metrics

本文评价

[1]	Shidong Xue, Jingkun Han, Xi Xi, Junyi Zhao, Zhong Lan, Rongfu Wen, Xuehu Ma. Rapid velocity reduction and drift potential assessment of off-nozzle pesticide droplets[J]. 中国化学工程学报, 2022, 46(6): 243-254.
[2]	Xianchao Liang, Limin He, Xiaoming Luo, Qingping Li, Yuanpeng You, Yiqiu Xu. Experimental study on sand particles accumulation, migration and separation efficiency in slug catcher[J]. 中国化学工程学报, 2021, 32(4): 134-143.
[3]	Ziqing Yuan, Ziyu Chen, Jianxin Mao, Renxian Zhou. The size effect and high activity of nanosized platinum supported catalysts for low temperature oxidation of volatile organic compounds[J]. 中国化学工程学报, 2021, 39(11): 135-143.
[4]	Shuaifeng Zhang, Qinghua Zhang, Jianzhuang Shang, Zaisha Mao, Chao Yang. Measurement methods of particle size distribution in emulsion polymerization[J]. 中国化学工程学报, 2021, 39(11): 1-15.
[5]	Jiangyuan Qu, Nana Qi, Kai Zhang, Lifeng Li, Pengcheng Wang. Wet flue gas desulfurization performance of 330 MW coal-fired power unit based on computational fluid dynamics region identification of flow pattern and transfer process[J]. 中国化学工程学报, 2021, 29(1): 13-26.
[6]	Jimin Wang, Shen Lan, Tao Chen, Wenke Li, Huaqiang Chu. Numerical simulation and combination optimization of aluminum holding furnace linings based on simulated annealing[J]. Chinese Journal of Chemical Engineering, 2015, 23(6): 880-889.
[7]	Weiwei E, Jingcai Cheng, Chao Yang, Zaisha Mao. Experimental study by onlinemeasurement of the precipitation of nickel hydroxide: Effects of operating conditions[J]. Chinese Journal of Chemical Engineering, 2015, 23(5): 860-867.
[8]	Changxiao Shao, Kun Luo, Jianshan Yang, Song Chen, Jianren Fan. Accurate level set method for simulations of liquid atomization[J]. Chinese Journal of Chemical Engineering, 2015, 23(4): 597-604.
[9]	Pei Sun, Lei Xie, Junghui Chen. Spatial batch optimal design based on self-learning gaussian process models for LPCVD processes[J]. Chinese Journal of Chemical Engineering, 2015, 23(12): 1958-1964.
[10]	孙慧娟, 白博峰, 严俊杰, 张海滨 . Single-jet Spray Mixing with a Confined Crossflow[J]. Chinese Journal of Chemical Engineering, 2013, 21(1): 14-24.