Comprehensive treatment of latex wastewater and resource utilization of concentrated liquid

doi:10.1016/j.cjche.2022.09.011

中国化学工程学报 ›› 2023, Vol. 57 ›› Issue (5): 183-192.DOI: 10.1016/j.cjche.2022.09.011

• Full Length Article • 上一篇下一篇

Comprehensive treatment of latex wastewater and resource utilization of concentrated liquid

Shichao Tian, Yuming Tu, Rujie Li, Yufan Du, Zhiyong Zhou, Fan Zhang, Zhongqi Ren

State Key Laboratory of Chemical Resource Engineering, Beijing University of Chemical Technology, Beijing 100029, China

收稿日期:2022-06-05 修回日期:2022-08-28 出版日期:2023-05-28 发布日期:2023-07-08
通讯作者: Zhongqi Ren,E-mail:renzq@mail.buct.edu.cn
基金资助:
This work was supported by the National Natural Science Foundation of China (22125802 and 22108012), Natural Science Foundation of Beijing Municipality (2222017), and Fundamental Research Funds for the Central Universities (BUCTRC-202109).

Comprehensive treatment of latex wastewater and resource utilization of concentrated liquid

Shichao Tian, Yuming Tu, Rujie Li, Yufan Du, Zhiyong Zhou, Fan Zhang, Zhongqi Ren

State Key Laboratory of Chemical Resource Engineering, Beijing University of Chemical Technology, Beijing 100029, China

Received:2022-06-05 Revised:2022-08-28 Online:2023-05-28 Published:2023-07-08
Contact: Zhongqi Ren,E-mail:renzq@mail.buct.edu.cn
Supported by:
This work was supported by the National Natural Science Foundation of China (22125802 and 22108012), Natural Science Foundation of Beijing Municipality (2222017), and Fundamental Research Funds for the Central Universities (BUCTRC-202109).

摘要/Abstract

摘要： Latex wastewater is a kind of refractory organic wastewater containing high concentrations of organics and ammonia nitrogen. In this work, the combined process of forward osmosis (FO) and reverse osmosis (RO) was designed to treat the latex wastewater in the whole process, achieving the water recovery rate of 99% and basically no waste discharge after the catalytic oxidation process. The turbidity of the latex wastewater was decreased to below 1 NTU by microfiltration pretreatment, and then using MgCl₂ worked as the draw solution for FO process to treat the latex wastewater. Different operation conditions including adding acid or scale inhibitor as the pretreatment methods were conducted to improve the treatment performance of the combined process. After the treatment of the whole process, the concentration of COD was less than 20 mg·L^-1, the concentration of NH₃-N was less than 10 mg·L^-1, and the concentration of TP was less than 0.5 mg·L^-1 for the treated latex wastewater. The water quality met standards of industrial water reuse after the complete analysis of the treated latex wastewater, meanwhile, useful substances of L-Quebrachitol (L-Q) were successfully extracted from the concentrated solution. Therefore, the combined process of FO and RO could realize the efficient treatment and reuse of latex wastewater, which provided with some important guidance on the industrial application.

关键词: Latex wastewater, Resource utilization, Forward osmosis, Reverse osmosis, Concentrated liquid

Abstract: Latex wastewater is a kind of refractory organic wastewater containing high concentrations of organics and ammonia nitrogen. In this work, the combined process of forward osmosis (FO) and reverse osmosis (RO) was designed to treat the latex wastewater in the whole process, achieving the water recovery rate of 99% and basically no waste discharge after the catalytic oxidation process. The turbidity of the latex wastewater was decreased to below 1 NTU by microfiltration pretreatment, and then using MgCl₂ worked as the draw solution for FO process to treat the latex wastewater. Different operation conditions including adding acid or scale inhibitor as the pretreatment methods were conducted to improve the treatment performance of the combined process. After the treatment of the whole process, the concentration of COD was less than 20 mg·L^-1, the concentration of NH₃-N was less than 10 mg·L^-1, and the concentration of TP was less than 0.5 mg·L^-1 for the treated latex wastewater. The water quality met standards of industrial water reuse after the complete analysis of the treated latex wastewater, meanwhile, useful substances of L-Quebrachitol (L-Q) were successfully extracted from the concentrated solution. Therefore, the combined process of FO and RO could realize the efficient treatment and reuse of latex wastewater, which provided with some important guidance on the industrial application.

Key words: Latex wastewater, Resource utilization, Forward osmosis, Reverse osmosis, Concentrated liquid

Shichao Tian, Yuming Tu, Rujie Li, Yufan Du, Zhiyong Zhou, Fan Zhang, Zhongqi Ren. Comprehensive treatment of latex wastewater and resource utilization of concentrated liquid[J]. 中国化学工程学报, 2023, 57(5): 183-192.

参考文献

[1] D. Tanikawa, T. Kataoka, H. Sonaka, Y. Hirakata, M. Hatamoto, T. Yamaguchi, Evaluation of key factors for residual rubber coagulation in natural rubber processing wastewater, J. Water Process. Eng. 33 (2020) 101041.Doi: 10.1016/j.jwpe.2019.101041
[2] T.D. Kusworo, A.C. Kumoro, D.P. Utomo, F.M. Kusumah, M.D. Pratiwi, Performance of the crosslinked PVA coated PES-TiO₂ nano hybrid membrane for the treatment of pretreated natural rubber wastewater involving sequential adsorption - ozonation processes, J. Environ. Chem. Eng. 9 (2) (2021) 104855.Doi: 10.1016/j.jece.2020.104855
[3] A. Abdelrasoul, H. Doan, A. Lohi, C.H. Cheng, The influence of aggregation of latex particles on membrane fouling attachments & ultrafiltration performance in ultrafiltration of latex contaminated water and wastewater, J. Environ. Sci. (China) 52 (2017) 118–129.https://pubmed.ncbi.nlm.nih.gov/28254030/
[4] P. Dunuwila, V.H.L. Rodrigo, N. Goto, Improving financial and environmental sustainability in concentrated latex manufacture, J. Clean. Prod. 255 (2020) 120202.Doi: 10.1016/j.jclepro.2020.120202
[5] M. Wawrzkiewicz, P. Bartczak, T. Jesionowski, Enhanced removal of hazardous dye form aqueous solutions and real textile wastewater using bifunctional chitin/lignin biosorbent, Int. J. Biol. Macromol. 99 (2017) 754–764.https://pubmed.ncbi.nlm.nih.gov/28283458/
[6] T. Watari, T.C. Mai, D. Tanikawa, Y. Hirakata, M. Hatamoto, K. Syutsubo, M. Fukuda, N.B. Nguyen, T. Yamaguchi, Performance evaluation of the pilot scale upflow anaerobic sludge blanket - Downflow hanging sponge system for natural rubber processing wastewater treatment in South Vietnam, Bioresour. Technol. 237 (2017) 204–212.Doi: 10.1016/j.biortech.2017.02.058
[7] K. Promnuan, T. Higuchi, T. Imai, P. Kongjan, A. Reungsang, S. O-Thong, Simultaneous biohythane production and sulfate removal from rubber sheet wastewater by two-stage anaerobic digestion, Int. J. Hydrog. Energy 45 (1) (2020) 263–274.Doi: 10.1016/j.ijhydene.2019.10.237
[8] K. Vijayaraghavan, D. Ahmad, A.Y. Ahmad Yazid, Electrolytic treatment of latex wastewater, Desalination 219 (1–3) (2008) 214–221.Doi: 10.1016/j.desal.2007.05.014
[9] M. Sun, M.H. Qin, C. Wang, G.M. Weng, M.X. Huo, A.D. Taylor, J.H. Qu, M. Elimelech, Electrochemical-osmotic process for simultaneous recovery of electric energy, water, and metals from wastewater, Environ. Sci. Technol. 54 (13) (2020) 8430–8442.Doi: 10.1021/acs.est.0c01891
[10] Y. Zhang, L.M. Yang, K.P. Pramoda, W.X. Gai, S. Zhang, Highly permeable and fouling-resistant hollow fiber membranes for reverse osmosis, Chem. Eng. Sci. 207 (2019) 903–910.Doi: 10.1016/j.ces.2019.07.014
[11] C. Wang, M. Sun, Y.M. Zhao, M.X. Huo, X.Z. Wang, M. Elimelech, Photo-electrochemical osmotic system enables simultaneous metal recovery and electricity generation from wastewater, Environ. Sci. Technol. 55 (1) (2021) 604–613.Doi: 10.1021/acs.est.0c04375
[12] G. Han, S. Zhang, X. Li, N. Widjojo, T.S. Chung, Thin film composite forward osmosis membranes based on polydopamine modified polysulfone substrates with enhancements in both water flux and salt rejection, Chem. Eng. Sci. 80 (2012) 219–231.Doi: 10.1016/j.ces.2012.05.033
[13] K. Park, D.Y. Kim, Y.H. Jang, M.G. Kim, D.R. Yang, S. Hong, Comprehensive analysis of a hybrid FO/crystallization/RO process for improving its economic feasibility to seawater desalination, Water Res. 171 (2020) 115426.Doi: 10.1016/j.watres.2019.115426
[14] C. Lee, T.T. Nguyen, R.S. Adha, H.K. Shon, I.S. Kim, Influence of hydrodynamic operating conditions on organic fouling of spiral-wound forward osmosis membranes: Fouling-induced performance deterioration in FO-RO hybrid system, Water Res. 185 (2020) 116154.Doi: 10.1016/j.watres.2020.116154
[15] W.L. Ang, A.W. Mohammad, D. Johnson, N. Hilal, Unlocking the application potential of forward osmosis through integrated/hybrid process, Sci. Total Environ. 706 (2020) 136047.https://pubmed.ncbi.nlm.nih.gov/31864996/
[16] K.Y. Wang, M.M. Teoh, A. Nugroho, T.S. Chung, Integrated forward osmosis-membrane distillation (FO-MD) hybrid system for the concentration of protein solutions, Chem. Eng. Sci. 66 (11) (2011) 2421–2430.Doi: 10.1016/j.ces.2011.03.001
[17] J.J. Zhang, D. Wang, Y. Chen, B.Y. Gao, Z.N. Wang, Scaling control of forward osmosis-membrane distillation (FO-MD) integrated process for pre-treated landfill leachate treatment, Desalination 520 (2021) 115342.Doi: 10.1016/j.desal.2021.115342
[18] M.S. Nawaz, H.S. Son, Y. Jin, Y. Kim, S. Soukane, M.A. Al-Hajji, M. Abu-Ghdaib, N. Ghaffour, Investigation of flux stability and fouling mechanism during simultaneous treatment of different produced water streams using forward osmosis and membrane distillation, Water Res. 198 (2021) 117157.Doi: 10.1016/j.watres.2021.117157
[19] M.A. Hafiz, A.H. Hawari, A. Altaee, A hybrid forward osmosis/reverse osmosis process for the supply of fertilizing solution from treated wastewater, J. Water Process. Eng. 32 (2019) 100975.Doi: 10.1016/j.jwpe.2019.100975
[20] B.M. Jun, Y.A.J. Al-Hamadani, A. Son, C.M. Park, M. Jang, A. Jang, N.C. Kim, Y. Yoon, Applications of metal-organic framework based membranes in water purification: A review, Sep. Purif. Technol. 247 (2020) 116947.Doi: 10.1016/j.seppur.2020.116947
[21] G.Z. Ramon, T.V. Nguyen, E.M.V. Hoek, Osmosis-assisted cleaning of organic-fouled seawater RO membranes, Chem. Eng. J. 218 (2013) 173–182.Doi: 10.1016/j.cej.2012.12.006
[22] S. Lee, Y. Kim, J. Park, H.K. Shon, S. Hong, Treatment of medical radioactive liquid waste using Forward Osmosis (FO) membrane process, J. Membr. Sci. 556 (2018) 238–247.Doi: 10.1016/j.memsci.2018.04.008
[23] R. Valladares Linares, Z. Li, V. Yangali-Quintanilla, N. Ghaffour, G. Amy, T. Leiknes, J.S. Vrouwenvelder, Life cycle cost of a hybrid forward osmosis - low pressure reverse osmosis system for seawater desalination and wastewater recovery, Water Res. 88 (2016) 225–234.https://pubmed.ncbi.nlm.nih.gov/26512800/
[24] M. Arjmandi, M. Pourafshari Chenar, A. Altaee, A. Arjmandi, M. Peyravi, M. Jahanshahi, E. Binaeian, Caspian seawater desalination and whey concentration through forward osmosis (FO)-reverse osmosis (RO) and FO-FO-RO hybrid systems: Experimental and theoretical study, J. Water Process. Eng. 37 (2020) 101492.Doi: 10.1016/j.jwpe.2020.101492
[25] W.Y. Fu, J.H. Chen, C.Y. Li, L.C. Jiang, M. Qiu, X. Li, Y.G. Wang, L.F. Cui, Enhanced flux and fouling resistance forward osmosis membrane based on a hydrogel/MOF hybrid selective layer, J. Colloid Interface Sci. 585 (2021) 158–166.https://pubmed.ncbi.nlm.nih.gov/33279698/
[26] J.T. Hu, W.Y. Fu, F. Ni, X.H. Zhang, C.P. Yang, J.Q. Sang, An integrated process for the advanced treatment of hypersaline petrochemical wastewater: A pilot study, Water Res. 182 (2020) 116019.https://pubmed.ncbi.nlm.nih.gov/32544732/
[27] S. Tian, Z. Zhang, X. Zhang, K. Ken Ostrikov, Capacitative deionization using commercial activated carbon fiber decorated with polyaniline, J. Colloid Interface Sci. 537 (2019) 247–255.https://pubmed.ncbi.nlm.nih.gov/30448645/
[28] Y.S. Khoo, W.J. Lau, H. Chamani, T. Matsuura, A.F. Ismail, Water flux increase by inverting the membrane from its normal position - Is it occurring in FO and PRO? J. Water Process. Eng. 37 (2020) 101366.Doi: 10.1016/j.jwpe.2020.101366
[29] S.H. Oh, S.J. Im, S. Jeong, A. Jang, Nanoparticle charge affects water and reverse salt fluxes in forward osmosis process, Desalination 438 (2018) 10–18.Doi: 10.1016/j.desal.2018.03.015
[30] L.S. Ma, L. Gutierrez, T. van Vooren, M. Vanoppen, M. Kazemabad, A. Verliefde, E. Cornelissen, Fate of organic micropollutants in reverse electrodialysis: Influence of membrane fouling and channel clogging, Desalination 512 (2021) 115114.Doi: 10.1016/j.desal.2021.115114
[31] M. Zhan, Y. Kim, J. Lim, S. Hong, Application of fouling index for forward osmosis hybrid system: A pilot demonstration, J. Membr. Sci. 617 (2021) 118624.Doi: 10.1016/j.memsci.2020.118624
[32] M. Arjmandi, M. Peyravi, A. Altaee, A. Arjmandi, M. Pourafshari Chenar, M. Jahanshahi, E. Binaeian, A state-of-the-art protocol to minimize the internal concentration polarization in forward osmosis membranes, Desalination 480 (2020) 114355.Doi: 10.1016/j.desal.2020.114355
[33] M. Kahrizi, J.Y. Lin, G.Z. Ji, L.X. Kong, C.W. Song, L.F. Dumée, S. Sahebi, S.F. Zhao, Relating forward water and reverse salt fluxes to membrane porosity and tortuosity in forward osmosis: CFD modelling, Sep. Purif. Technol. 241 (2020) 116727.Doi: 10.1016/j.seppur.2020.116727
[34] X.X. Cheng, H. Liang, A. Ding, X.B. Tang, B. Liu, X.W. Zhu, Z.D. Gan, D.J. Wu, G.B. Li, Ferrous iron/peroxymonosulfate oxidation as a pretreatment for ceramic ultrafiltration membrane: Control of natural organic matter fouling and degradation of atrazine, Water Res. 113 (2017) 32–41.Doi: 10.1016/j.watres.2017.01.055
[35] S.C. He, D.Y. Jiang, M.H. Hong, Z.H. Liu, Hazard-free treatment and resource utilisation of electrolytic manganese residue: A review, J. Clean. Prod. 306 (2021) 127224.Doi: 10.1016/j.jclepro.2021.127224
[36] B. Tansel, G. Lunn, O. Monje, Struvite formation and decomposition characteristics for ammonia and phosphorus recovery: A review of magnesium-ammonia-phosphate interactions, Chemosphere 194 (2018) 504–514.https://pubmed.ncbi.nlm.nih.gov/29241124/
[37] H.L. Wang, X.H. Wang, F.G. Meng, X.F. Li, Y.P. Ren, Q.H. She, Effect of driving force on the performance of anaerobic osmotic membrane bioreactors: New insight into enhancing water flux of FO membrane via controlling driving force in a two-stage pattern, J. Membr. Sci. 569 (2019) 41–47.Doi: 10.1016/j.memsci.2018.10.010
[38] Y.H. Li, X.F. Zhang, Y.L. Wang, J.F. Wang, D.G. Wang, Feasibility study of multi-effect distillation dealing with high-salinity organic RO concentrates: Experiment and theoretical analysis, Desalination 505 (2021) 115007.Doi: 10.1016/j.desal.2021.115007
[39] C. Jacquin, G. Lesage, J. Traber, W. Pronk, M. Heran, Three-dimensional excitation and emission matrix fluorescence (3DEEM) for quick and pseudo-quantitative determination of protein- and humic-like substances in full-scale membrane bioreactor (MBR), Water Res. 118 (2017) 82–92.Doi: 10.1016/j.watres.2017.04.009
[40] F.H. Song, F.C. Wu, W.Y. Feng, Z. Tang, J.P. Giesy, F. Guo, D. Shi, X.F. Liu, N. Qin, B.S. Xing, Y.C. Bai, Fluorescence regional integration and differential fluorescence spectroscopy for analysis of structural characteristics and proton binding properties of fulvic acid sub-fractions, J. Environ. Sci. 74 (2018) 116–125.Doi: 10.1016/j.jes.2018.02.015
[41] K. Zhang, Z.H. Zhang, H. Wang, X.M. Wang, X.H. Zhang, Y.F. Xie, Synergistic effects of combining ozonation, ceramic membrane filtration and biologically active carbon filtration for wastewater reclamation, J. Hazard. Mater. 382 (2020) 121091.Doi: 10.1016/j.jhazmat.2019.121091
[42] S. Lee, H.K. Shon, S. Hong, Dewatering of activated sludge by forward osmosis (FO) with ultrasound for fouling control, Desalination 421 (2017) 79–88.Doi: 10.1016/j.desal.2017.02.010
[43] P. Danwanichakul, W. Pohom, J. Yingsampancharoen, L-Quebrachitol from acidic serum obtained after rubber coagulation of skim natural rubber latex, Ind. Crops Prod. 137 (2019) 157–161.Doi: 10.1016/j.indcrop.2019.04.072
[44] Y. Xue, Q. Miao, A. Zhao, Y.D. Zheng, Y.M. Zhang, P.Y. Wang, H. Kallio, B.R. Yang, Effects of sea buckthorn (Hippophaë rhamnoides) juice and L-quebrachitol on type 2 diabetes mellitus in db/db mice, J. Funct. Foods 16 (2015) 223–233.Doi: 10.1016/j.jff.2015.04.041

Comprehensive treatment of latex wastewater and resource utilization of concentrated liquid

Comprehensive treatment of latex wastewater and resource utilization of concentrated liquid

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	Aneela Sabir, Wail Falath, Muhammad Shafiq, Nafisa Gull, Maria Wasim, Karl I. Jacob. Effective desalination and anti-biofouling performance via surface immobilized MWCNTs on RO membrane[J]. 中国化学工程学报, 2023, 56(4): 33-45.
[2]	Kai Zhang, Huan-Huan Wu, Hui-Qian Huo, Yan-Li Ji, Yong Zhou, Cong-Jie Gao. Recent advances in nanofiltration, reverse osmosis membranes and their applications in biomedical separation field[J]. 中国化学工程学报, 2022, 49(9): 76-99.
[3]	Dongze Ma, Ye Tian, Tiefei He, Xiaobiao Zhu. Preparation of novel magnetic nanoparticles as draw solutes in forward osmosis desalination[J]. 中国化学工程学报, 2022, 46(6): 223-230.
[4]	Jing Dou, Shuo Han, Saisai Lin, Zhikan Yao, Lian Hou, Lin Zhang. Highly permeable reverse osmosis membranes incorporated with hydrophilic polymers of intrinsic microporosity via interfacial polymerization[J]. 中国化学工程学报, 2022, 45(5): 194-202.
[5]	Santiago Gutiérrez Ruiz, Juan Antonio López-Ramírez, Mohammed Hassani Zerrouk, Agata Egea-Corbacho Lopera, José María Quiroga Alonso. Study of reverse osmosis membranes fouling by inorganic salts and colloidal particles during seawater desalination[J]. 中国化学工程学报, 2020, 28(3): 733-742.
[6]	Wan Nur Ain Shuhada Abdullah, Sirinan Tiandee, Woeijye Lau, Farhana Aziz, Ahmad Fauzi Ismail. Potential use of nanofiltration like-forward osmosis membranes for copper ion removal[J]. 中国化学工程学报, 2020, 28(2): 420-428.
[7]	Zhiqiang Li, Lanying Jiang, Chongjian Tang. Investigation on removing recalcitrant toxic organic polluters in coking wastewater by forward osmosis[J]. 中国化学工程学报, 2020, 28(1): 122-135.
[8]	Jeng Yih Law, Abdul Wahab Mohammad. Osmotic concentration of succinic acid by forward osmosis: Influence of feed solution pH and evaluation of seawater as draw solution[J]. Chinese Journal of Chemical Engineering, 2018, 26(5): 976-983.
[9]	Mostafa Taherian, Seyed Mahmoud Mousavi, Hooman Chamani. An agent-based simulation with NetLogo platform to evaluate forward osmosis process (PRO Mode)[J]. Chinese Journal of Chemical Engineering, 2018, 26(12): 2487-2494.
[10]	Jie Li, Mingjie Wei, Yong Wang. Substrate matters:The influences of substrate layers on the performances of thin-film composite reverse osmosis membranes[J]. Chinese Journal of Chemical Engineering, 2017, 25(11): 1676-1684.
[11]	Yanni Wang, Hairong Yu, Rui Xie, Kuangmin Zhao, Xiaojie Ju, WeiWang, Zhuang Liu, Liangyin Chu. An easily recoverable thermo-sensitive polyelectrolyte as draw agent for forward osmosis process[J]. Chinese Journal of Chemical Engineering, 2016, 24(1): 86-93.
[12]	Dieling Zhao, Shucheng Chen, Chun Xian Guo, Qipeng Zhao, Xianmao Lu. Multi-functional forward osmosis draw solutes for seawater desalination[J]. Chinese Journal of Chemical Engineering, 2016, 24(1): 23-30.
[13]	吴现力, 胡仰栋, 伍联营, 李红. Model and Design of Cogeneration System for Different Demands of Desalination Water, Heat and Power Production[J]. Chinese Journal of Chemical Engineering, 2014, 22(3): 330-338.
[14]	钱智, 刘新春, 余志晟, 张洪勋, 琚宜文. A Pilot-scale Demonstration of Reverse Osmosis Unit for Treatment of Coal-bed Methane Co-produced Water and Its Modeling[J]. Chinese Journal of Chemical Engineering, 2012, 20(2): 302-311.
[15]	刘飞妮, 张国亮, 孟琴, 章宏梓. Performance of Nanofiltration and Reverse Osmosis Membranes in Metal Effluent Treatment[J]. , 2008, 16(3): 441-445.